Table of Contents
Advertisement
STORAGE
It is recommended that the boat be
taken to an authorized Sea-Doo Sport
Boats dealer for proper storage but the
following operations can be performed
by you with a minimum of tools.
NOTE: Leave drain plug out during
storage period.
NOTICE
Do not run the engines
during the storage period.
WARNING
Because
fuel
flammable, have an authorized
Sea-Doo Sport Boats dealer in-
spect the fuel and oil systems
integrity as specified in the
TENANCE SCHEDULE
Jet Pump Cleaning
Clean jet pump by spraying water in its
inlet and outlet and then apply a coat-
ing of XP-S Lube (P/N 293 600 016) or
equivalent.
WARNING
Always remove safety lanyard cap
from post to prevent unexpected
engine starting before cleaning
the jet pump area. Engine must
not be running for this operation.
Fuel System Protection
BRP fuel stabilizer (P/N 413 408 600)
(or equivalent), can be added in fuel
tank to prevent fuel deterioration and
fuel system gumming. Follow stabi-
lizer manufacturer's instructions for
proper use.
NOTICE
Fuel stabilizer should be
added before engine lubrication to
protect fuel system components
against varnish deposits.
Fill up fuel tank completely. Ensure
there is no water inside fuel tank.
______________
96
and
oil
are
MAIN-
.
NOTICE
Should any water be
trapped inside fuel tank, severe in-
ternal damage will occur to the fuel
injection system.
WARNING
Always stop the engines before re-
fueling. Fuel is flammable and ex-
plosive under certain conditions.
Always work in a well ventilated
area. Do not smoke or allow open
flames or sparks in the vicinity. Fu-
el tank may be pressurized. Slowly
turn cap when opening. Never use
an open flame to check fuel level.
When fueling, keep boat level. Do
not overfill or top off the fuel tank
and leave boat in the sun. As tem-
perature increases, fuel expands
and might overflow. Always wipe
off any fuel spillage from the boat.
Periodically verify fuel system.
Throttle Body Lubrication
Lubricate throttle body.
MAINTENANCE PROCEDURES
details.
Engine Oil and Filter
Replacement
The oil change and filter should be
performed by an authorized Sea-Doo
Sport Boats dealer.
Exhaust System Flushing
Flushing the exhaust system of each
engine with fresh water is essential to
neutralize corroding effects of salt or
other chemical products present in wa-
ter. It will help to clean up sand, salt,
shells or other particles in water jack-
ets (exhaust system and intercooler (if
so equipped)) and/or hoses.
Refer to
for
Advertisement
Table of Contents
