Charging Batteries; Disposing Of Batteries; Maintenance; A.notes - Quickie Xplore 2 Hybrid Owner's Manual

wrenches to 60 in-lbs (6.8 N.m).
4. Place the battery compartment lid on power base.
PROHIBITED!
Never make direct contact across both battery terminals, as
an ex plosion may occur. A spark may result in an explosion
and/or fire resulting in severe injury or death.
E. CHARGING BATTERIES
To avoid the risk of severe injury or death from electrical
shock, fire or explosion while charging:
PROHIBITED!
Never connect charger to a 240 volt source. The main
input voltage is 110 volts.
Never touch the charger after it is connected to an
electrical outlet. This may cause electrical shock.
• Never connect or disconnect charger from battery while
there is power to the charger.
1. Never use an extension cord. Use of an improper cord could
damage the charger or cause a fire or electrical shock.
2. A battery emits explosive hydrogen gas during charging. To
reduce the risk of fire or explosion:
• Make sure area is well vented. Never charge battery in a
closed-in area.
• Never smoke or allow a spark, flame or high heat near battery
during charging.
• Never allow metal tools or chair parts to make direct contact
across both battery terminals

A.NOTES

1. Proper maintenance will improve performance and extend the
useful life of your chair.
2. Clean your chair regularly. This will help you find loose or worn
parts and will make your chair easier to use.
3. To protect your investment, have all major service and repair
work done by your supplier.
1. Your chair needs regular maintenance for peak performance
and to avoid injury from chair failure, damage or premature
wear.
2. Inspect and maintain this chair strictly per the "Maintenance
Chart".
3. If you detect a problem, make sure to service or repair the chair
before use.
4. At least once a year, have a complete safety check and service
of your chair performed by a supplier.
B. CLEANING
1. Paint Finish:
• Clean the paint finish with mild soapy water monthly.
• Protect the paint with a coat of non-abrasive auto wax every
Quickie Xplore 2 Owner's Manual
WARNING
WARNING
WARNING
WARNING
3. Never look directly into cells when charging battery (wet cell
batteries).
ALWAYS:
1. Use the charger that comes with your wheelchair. Read and
follow all instructions and warnings.
2. Make sure room is well ventilated.
3. Turn off all power to your chair.
4. Connect and disconnect battery cables with caution.
Q-NOTE- Always remove and reattach the negative cable
(black cable) first.
5. Make sure to allow enough time to fully charge batteries.
Q-NOTE- Batteries should never be left for long period in
the discharged state. Unused or stored batteries should be
given a charge once per month.
6. To charge batteries, use the off-board charger by plugging off-
board charger plug into the off-board charger socket.
F. DISPOSING OF BATTERIES
1. All batteries once they have reached the end of their useful life
are deemed to be hazardous waste.
2. For further information on handling and recycling contact your
local recycling authority.
3. Always dispose of product through a recognized agent.
2. Motors:
• Clean around motor area weekly with a slightly damp (not wet)
cloth.
• Wipe off or blow away any fluff, dust, or dirt on or around the
motors.
Q-NOTE- You do not need to grease or oil the chair.
3. Upholstery:
• Hand-wash only as needed. Machine washing may
damagefabric.
• Drip-dry only. Heat from a dryer may damage fabric.
Q-NOTE- Washing the fabric may decrease fire retardant
properties.
C. STORAGE TIPS
1. Store your chair in a clean, dry area. If you fail to do so, parts
may rust or corrode.
2. Before using your chair, make sure it is in proper working order.
Inspect and service all items on the "Maintenance Chart".
3. If you store this chair for more than three months, have it
inspected by a supplier before use.
Rev. A
WARNING
XI. MAINTENANCE
29