Lighting - Eastman Outdoors Revolution 37059 Instruction And Safety Manual

Before each use, inspect the cooking vessel for dents, cracks, or pinholes. Fill the cooking vessel
with water and dry off the outside of the cooking vessel. If water appears on the outside of cooking
vessel, there is a leak. Do NOT use the cooking vessel if there is a leak. Contact Eastman
Outdoors at 1-800-241-4833 on how to obtain replacement parts.
While operating burner, visually check flames. They should be deep blue to almost invisible in the
light (figure 23). If they are not, adjust the air shutter until deep blue flame is obtained (figure 24).
Fig. 23
If burner flames are yellow, blows out, does not light, or flames inside venturi tube, immediately
turn gas OFF at the LP tank. Spiders and other insects can build nests inside burner venturi
blocking air and gas flow. If this occurs, with the gas OFF at the LP tank and burner cooled to room
temperature, remove air shutter, spring, and hose assembly and clean venturi tube and casting
holes with a bent wire, pipe cleaner, or screwdriver through the air shutter holes. Compressed air
may help clear away smaller particles. If revolution burner casting is not clear, flush water or use
compressed air through the small casting holes to blow/wash out debris through the air shutter
holes. Once cleared, reassemble air shutter, spring, and hose assembly. If a flame occurs inside
venturi, this is caused by blockage and could cause damage to the hose and orifice assembly.
Step 2.1 Lighting
Locate the appliance outdoors in well-ventilated areas, clear of combustible materials, and on a level, stable,
noncombustible surface like brick, concrete, or dirt.
If there is wind, locate the appliance in an outdoor area that is protected from the wind.
Always have a Type BC or ABC dry chemical fire extinguisher readily available.
•
OUTDOOR USE ONLY / NEVER LEAVE UNATTENDED
Fig. 24
Do not allow your hands, hair, fabric, clothing, or any body part to be over
appliance or on appliance when lighting.
Failure to follow these instructions can lead to serious personal injury or
death.
Always locate LP tank a minimum of 3ft (0.9m) upwind from burner. (figure 25)
MAINTAIN A DISTANCE
OF 3 FT (0.9M) BETWEEN
LP TANK & BURNER
WIND
DIRECTION
Trip hazard. Do not step over/walk between LP tank and hose.
Do not use on porches, wooden decks, picnic tables or in a building, garage,
under overhangs, or any enclosed area.
Do not use on any surface that will burn or melt like wood, asphalt (blacktop),
vinyl, plastic or on a soft surface.
Failure to follow these instructions can lead to fire or explosion, which could
cause property damage, serious personal injury or death.
LP TANK
Fig.25
Page 9 of 19