Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Cabela's 860-0010
Summary of Contents for Cabela's 860-0010
- Page 1 ASSEMBLY & OPERATING INSTRUCTIONS 30 0 40 0 20 0 6 00 70 0 Model: 860-0010 FOR OUTDOOR USE ONLY FOR PROPANE GAS USE ONLY G28Y06P-1 PLEASE CONTACT 1-866-984-7455 FOR ASSISTANCE ABOUT ASSEMBLY OR GRILL OPERATION DO NOT RETURN TO THE PLACE OF PURCHASE...
-
Page 2: Table Of Contents
Table of Contents Safety Instruction ..... Trouble Shooting ..... 23-26 Assembly Instruction . -
Page 3: Safety Instruction
Safety Instruction WARNING ELECTRICAL GROUNDING INSTRUCTIONS This appliance (light and rotisserie motor) is equipped with a plug and should be plugged directly into a properly grounded receptacle. When installed, must be electrically grounded in accordance with local codes or in the absence of local codes, with the National Electrical Code, ANSI/NFPA 70 .CSA C22.1 DO NOT cut or remove the grounding prong from this plug. - Page 4 Safety Instruction WARNING CAUTION: Beware of Flashback Do not try lighting this appliance without reading the CAUTION: Spiders and small insects occasionally “LIGHTING INSTRUCTIONS” section of this manual. spin webs or make nest in the grill burner tubes during transit and warehousing.
- Page 5 Safety Instruction continued LP-Gas Supply System PROPER PLACEMENT AND CLEARANCE OF • If the information is not followed exactly, a fire resulting in GRILL death or serious injury could occur. §A 20lb tank of approximately # 1/4 inches in diameter by 18-1/4 •Never use your gas grill in a garage, porch, shed, inches high is the maximum size LP gas tank to use.
- Page 6 Safety Instruction continued SAFETY PRACTICES TO AVOID PERSONAL WARNING INJURY Your grill will get very hot. Never lean over the cooking area while using your grill. Do not touch When properly cared for, your grill will provide safe, cooking surfaces, grill housing, lid or any other grill reliable service for many years.
-
Page 7: Safety Instruction
Safety Instruction continued Do not heat unopened food containers. A build-up of Do not use the grill to cook excessively fatty meats or pressure may cause the containers to burst. other products which promote flare – ups. Use a covered hand when opening the grill lid. Do not operate the grill under unprotected combustible constructions. -
Page 8: Assembly Instruction
Assembly Instruction Please read the instructions carefully and follow step. Tools required: Philips head screwdriver and wrench-not provided Step 1: Loose the 2 screws attaching the drawer handle on the inner surface of the drawer door. Step 2: Align the door handle with the 2 holes on the outer surface of the drawer door. Attach the door handle to the drawer door by fastening the 2 screws from the inner surface of the drawer door. - Page 9 Assembly Instruction continued Step 3: Remove the battery cap by turning it counter-clockwise, slot a AA battery with the negative end inward, and then restore the battery cap. 3 00 4 00 20 0 6 00 1 00 7 00 8 00 Step 4: Install the rotisserie bracket with the 2 screws pre-screwed on the bracket.
-
Page 10: Assembly Instruction
Assembly Instruction continued Step 5: Propane Gas Tank Installation Attach propane gas tank to regulator inlet fitting by turning the regulator coupling clockwise as shown below. LP gas cylinder must be fitted with a listed overfill prevention device (OPD). CAUTION! DO NOT USE ANY TOOL TO ATTACH REGULATOR / HOSE ASSEMBLY TO PROPANE TANK Place the gas tank in the gas tank tray. -
Page 11: Gas Hook–Up
Gas Hook - Up NEVER CONNECT AN UNREGULATED GAS SUPPLY QCC1 in the standard for compressed gas cylinder LINE TO THE APPLIANCE. USE THE valve outlet and inlet connection ANSI/CGA-V-1. REGULATOR/HOSE ASSEMBLY SUPPLIED. Manifold pressure: 11”(27.94cm) water column (W.C.). This is a liquid propane configured grill. Do not attempt L.P. -
Page 12: Gas Hook–Up
Gas Hook – Up continued 5. When connecting regulator assembly to the valve, 7. If you have a gas connection leak you cannot repair, hand tighten the quick coupling nut clockwise to a turn gas OFF at supply tank, disconnect fuel line complete stop. -
Page 13: Leak Testing
Leak Testing GENERAL Only those parts recommended by the manufacturer should be used on the grill. Although all gas connections on the grill are leak tested at the factory prior to shipment, a complete Substitution will void the warranty. Do not use gas tightness check must be performed at the the grill until all connections have been checked installation site due to possible mishandling in... -
Page 14: Leak Testing
Leak Testing continued CAUTIONS Place dust cap on cylinder valve outlet when the cylinder is not in use. Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in leakage of propane. The gas must be turned off at the supply cylinder when the unit is not in use. -
Page 15: Operating Instruction
Operating Instructions GENERAL USE OF THE GRILL AND WARNING: IMPORTANT! ROTISSERIE USING THE SIDE BURNER: Each main burner is rated at 10,000 Btu/hr. Inspect the gas supply hose prior to turning The main grill burners encompass the entire the gas “ON”. If there is evidence of cuts, cooking area and are side ported to wear or abrasion, it must be replaced prior minimize blockage from falling grease and... -
Page 16: Grill Lighting Instruction
Grill Lighting Instructions WARNING: IMPORTANT! WARNING: Always keep your face and body as far away from the burner as possible when BEFORE LIGHTING… lighting. Inspect the gas supply hose prior to turning TO LIGHT THE SIDE BURNER the gas “ON”. If there is evidence of cuts, To light the side burner, remove any cooking wear, or abrasion, it must be replaced prior utensils from the burner grate. - Page 17 Grill Lighting Instructions continued NOTE: Remove all packaging, including straps, before using the grill! Lighting Main & Side Burner: Lighting Searing & Rotisserie Burner : Step 1. Step 1. Make sure the Lid is open Make sure the Lid is open Step 2.
- Page 18 Grill Lighting Instructions continued TO MATCH LIGHT THE GRILL TO MATCH LIGHT THE SIDE BURNER If the burner will not light after several attempts Hold a lit extended match near the side then the burner can be match lit. burner ports, turn the control knob counterclockwise to “IGNITE/HI”.
-
Page 19: Grill Lighting Instruction
Grill Lighting Instructions continued FLAME CHARACTERISTICS flame is noisy and tends to lift away from the burner, it indicates too much air. Check for proper burner flame characteristics. Each burner is adjusted prior to Burner flames should be blue and stable with shipment;... -
Page 20: Motor Instruction
Motor Instruction • TO USE MOTOR SAFELY, PLEASE READ WARNING BEFORE OPERATION. ROTISSERIE DRIVE MOTOR USE ONLY FOR OUTDOORS. DO NOT EXPOSE TO RAIN. CAUTION: TO ENSURE CONTINUED PROTECTION AGAINST RISK OF ELECTRIC SHOCK, CONNECT TO PROPERLY GROUNDED OUTLETS ONLY. TO REDUCE THE RISK OF ELECTRIC SHOCK, KEEP EXTENSION CORD CONNECTION DRY AND OFF THE GROUND. -
Page 21: Care And Maintenance
Care and Maintenance STAINLESS STEEL MAIN GRILL BURNER CLEANING There are many different stainless steel Ensure the gas supply is off and the knobs are cleaners available. Always use the mildest in the “OFF” position. Make sure the grill is cool. cleaning procedure first, scrubbing in the Clean the exterior of the burner with a wire direction of the grain. -
Page 22: Care And Maintenance
Care and Maintenance continued HOW TO REPLACE MAIN BURNER STAINLESS STEEL : There are many different stainless steel Step 1. Insert the burner onto the orifice. cleaners available. Always use the mildest cleaning procedure first, scrubbing in the direction of the grain. Do not use steel wool as it will scratch the surface. -
Page 23: Troubleshooting
Troubleshooting SPIDER AND INSECT WARNING WHEN TO LOOK FOR SPIDERS You should inspect the burners at least once Checking and cleaning burner/venturi tubes a year or immediately after any of the for insects and insect nests. A clogged tube following conditions occur: can lead to a fire beneath the grill. - Page 24 Troubleshooting continued PREHEATING: The grill lid should be in a closed position during the preheat time period. It is necessary to preheat the grill before cooking certain foods, depending on the type of food and the cooking temperature. Food that requires a high cooking temperature needs a pre-heat period of five minutes;...
- Page 25 Troubleshooting continued PROBLEM SOLUTION When attempting to light my grill, it will not • Make sure you have a spark while you are trying to light light immediately. the burner (if no spark). • Ensure that the wire is connected to the electrode assembly.
- Page 26 Troubleshooting continued Rotisserie motor will not turn. • Ensure the motor is connected to a properly grounded power supply. • Ensure the on/off switch is in the on position. • Ensure that the spit is fully inserted into the rotisserie motor.
-
Page 27: Exploded View
Exploded View 3 00 10 0... -
Page 28: Part List
Part List Part (Description) Part (Description) Main lid screw cover Cart leg E Main Lid screw Front trim panel, left Main Lid Front trim panel, right Temperature Gauge Front panel (Granite) Logo Drawer Slide Bracket Main Lid Handle Heat Insulating spacer A Drawer Slide Main Lid Handle Heat Insulating cover Drawer... - Page 29 Part List Part (Description) Part (Description) Side Burner Lid Hinge Rod Gas tank heat shield Shaft collar Spit fork Spit rod Rotisserie Heat Shield Rotisserie Burner pilot bracket Rotisserie burner pilot Rotisserie Burner Flex Gas line Rotisserie Burner pilot cover Rotisserie burner Rotisserie orifice w/brass elbow Main Lid Handle Heat Insulating spacer B...
-
Page 30: Ordering Parts
Ordering Parts IMPORTANT HOW TO ORDER REPLACEMENT PARTS Use only factory authorized parts. The use of any part To make sure you obtain the correct replacement that is not factory authorized can be dangerous. This part(s) for your gas grill, please refer to the parts list will also void your warranty. -
Page 31: Grill Cooking Chart
Grill Cooking Chart WEIGHT OR FLAME APPROXIMATE SPECIAL INSTRUCTIONS FOOD THICKNESS SIZE TIME AND TIPS Slice. Dot with butter or margarine. Wrap in VEGETABLES heavy-duty foil. Grill, turning occasionally. Fresh Beets Grill, turning once. Brush Medium 12 to 20 minutes Carrots occasionally with melted butter or margarine. - Page 32 Grill Cooking Chart continued WEIGHT OR FLAME APPROXIMATE SPECIAL INSTRUCTIONS FOOD THICKNESS SIZE TIME AND TIPS Trim edges. Grill, turning once. Cook to desired PORK 1 inch Medium 20 to 30 minutes doneness. Chops Well-done 1-1/2 inches Medium 30 to 40 minutes Grill, turning occasionally.
-
Page 33: Grill Recipe Suggestions
Grill Recipe Suggestions BBQ SALMON TANGY SEAFOOD KABOBS BBQ the chops brushing with the marinade occasionally. Serve with 1 lb. Large shrimp, shelled & 2 large salmon steaks deveined mixed salad, dressed with 2 tbs. Oil vinaigrette flavored with fresh dill. ¾... - Page 34 Grill Recipe Suggestions continued Preheat grill. Combine cheese, Pound flank steak to ¼ inch In blender, process 1/3 c. water, condensed soup, milk, BBQ sauce, thickness or flatten chicken breasts. onion, soy sauce, 2 tsp. oil and the oregano, salt and pepper in a large Mix oil, lime juice and seasonings next 8 ingredients until smooth.
- Page 35 Grill Recipe Suggestions continued CHICKEN TANDOORI STYLE Marinade ribs for 3 hours. Use TURKEY marinade for basting by adding 8 large chicken thighs or 12 lb. turkey drumsticks beer to it. Place pan under the ribs and baste frequently. To cook ribs Beer basting sauce: 1 c.
- Page 36 Limited Warranty...