Compressor Cleaning; Filter Change; Maintenance; Specifications - DeVilbiss 4650D Instruction Manual

CoMpRESSoR ClEaNiNg

1. With power switch in the "Off" position, unplug power cord from wall outlet.
2. Wipe outside of the compressor cabinet with a clean damp cloth every few days to keep dust-free.
DaNgER
Do not submerge in water; doing so will result in compressor damage.

FilTER ChaNgE

1. F ilter should be changed every 6 months or sooner if filter turns completely gray in color.
2. R emove filter cap by grasping it firmly and pulling out of the unit
3. R emove dirty filter with fingers and discard.
4. R eplace with a new DeVilbiss filter (part #5650D-602). Additional filters should be purchased from your DeVilbiss
provider.
5. P ush filter cap with new filter into position.
CAUTION– Do not reuse or wash filter or substitute any other material such as cotton for a DeVilbiss air-inlet filter. It will
result in compressor damage.
NOTE– An extra filter is packaged with the 4650 series units.

MaiNTENaNCE

All maintenance must be performed by a qualified DeVilbiss provider or authorized service center.
DaNgER
Electric shock hazard. Do not remove compressor cabinet. All disassembly and maintenance must be done by a
qualified DeVilbiss provider.

SpECiFiCaTioNS

Size. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7" W x 3.8" H x 13" D (18 cm x 10 cm x 33 cm)
Weight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5.3 lbs. (2.40 kg)
Electrical Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.5 amps, 115 VAC (±10%) 60 Hz
Sound Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53-57 dBA
Power Consumption . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140 watts maximum
Maximum Compressor Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 psig (241 kPa)*
Compressor Free Air Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 lpm*
Operating Temperature Range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . +40° to +104°F (+5 to +40°C)
Operating Humidity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .up to 95% non-condensing
Storage/Transport Temperature Range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . -40° to +158°F (-40° to +70°C)
Storage/Transport Humidity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .up to 95% non-condensing
Supplied Nebulizer Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 ml (cc)
Supplied Nebulizer Nebulization Rate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0.15 ml/min or greater*
Supplied Nebulizer MMAD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 microns or less**
* Conditions may vary based on altitude above sea level, barometric pressure, and temperature.
**Value determined with minimum flow rate through the nebulizer (20°C, sea level).
There are no hazardous materials used in the construction of this unit, therefore, there are no known risks associated with
disposal of the equipment.
EN - 6 A-4650D