Advertisement

Quick Links

P126764-01
P/N 126764-01 Rev. D 10/2015
This book is valuable. In addition to instructing you on how to install and maintain your appliance, it also
contains information that will enable you to obtain replacement parts or accessory items when needed. Keep
it with your other important papers.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
This wood burning fireplace complies with UL127
CAN/ULC-S610-M87 standard as a FACTORY
BUILT FIREPLACE.
This fireplace is approved for use as a wood burning fireplace or for use with a vented gas log approved to
ANSI Z21.60 or Z21.84 standards or for use with a vent-free gas log heater approved to ANSI Z21.11.2 standard .
An IHP hood must be installed when using a vent-free log heater (see Accessories, page 19).
FOR CANADA: The authority having jurisdiction
(such as the municipal building department, fire
department, etc.) should be contacted before
installation to determine the need to obtain a permit.
This appliance may be installed in an aftermarket permanently located, manufactured home (USA only) or
mobile home, where not prohibited by local codes.
This installation manual will enable you to obtain a safe, efficient and dependable installation of your fireplace
system. Please read and understand these instructions before beginning your installation.
Do not alter or modify the fireplace or its components under any circumstances. Any modification or alteration of
the fireplace system, including but not limited to the fireplace, chimney components and accessories, may void the
warranty, listings and approvals of this system and could result in an unsafe and potentially dangerous installation.
IMPORTANT! TO ASSURE PROPER ALIGNMENT OF GLASS DOORS: INSTALL THIS FIREPLACE IN A SQUARE
AND PLUMB CONDITION, USING SHIMS AS NECESSARY AT SIDES AND/OR BOTTOM.
PFS
®
C
US
Report No. F10-078
SAVE THIS BOOK
Installateur : Laissez cette notice avec l'appareil.
Consommateur : Conservez cette notice pour consultation ultérieure.
Ce foyer au bois est conforme aux UL 127 CAN/ULC-
S610-M87 norme comme une USINE CONSTRUITE
CHEMINÉE.
POUR LE CANADA: L'autorité compétente (comme le
service municipal du bâtiment, les pompiers, etc.) doit
être contacté avant l'installation afin de déterminer la
nécessité d'obtenir un permis.
Installation and Operation Instructions
Astria® Residential and Outdoor Wood-
Burning Fireplace
Tuscan36P2
Models
Tuscan36P3

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Tuscan36P2 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Astria Tuscan36P2

  • Page 1 Installation and Operation Instructions Astria® Residential and Outdoor Wood- Burning Fireplace Models ® P126764-01 Tuscan36P2 Tuscan36P3 P/N 126764-01 Rev. D 10/2015 Report No. F10-078 SAVE THIS BOOK This book is valuable. In addition to instructing you on how to install and maintain your appliance, it also contains information that will enable you to obtain replacement parts or accessory items when needed.
  • Page 2: Table Of Contents

    To help us keep you up-to-date on product information and of- Replacement Parts ...............14 fers, please take a few moments to register your product online Parts ....................15 at Astria.US.com Accessories ..................18 Warranty ..................23 Please read and understand these instructions before installing or operating.
  • Page 3 These woods burn excessively hot and may contain accumulated (1/8" [3 mm] or more) it shall be removed chemicals used to treat insects and fungus. When to reduce the risk of a chimney fire. burned, these chemicals can pose a significant hazard. Astria.US.com 126764-01D...
  • Page 4: Specifications

    22" 29" " " " " 41" " ROUND TOP TERMINATION 1" " 21" 37" SQUARE CHASE-TOP TERMINATION 8" 35" 41" 1" CAUTION: THE STRUCTURAL INTEGRITY OF THE MANUFACTURED HOME FLOOR, WALL, AND CEILING/ ROOF MUST BE MAINTAINED. Astria.US.com 126764-01D...
  • Page 5: Fireplace Installation

    3. Set fireplace directly in front of this opening and slide unit back be installed under the fireplace within the fireplace enclosure (see until nailing flanges touch side framing. Accessories on page 19). Astria.US.com 126764-01D...
  • Page 6 3 feet below the flue gas outlet of the termination. side edge of the black metal face of the fireplace just as long as the projection from the front face fall within the limit shown in Figure 4. Astria.US.com 126764-01D...
  • Page 7: Venting Installation

    Square Chase-Top with Mesh 7" to ETL-8DM Square Chase-Top with Slip Section 15"* Square Chase-Top with Mesh & Slip Sec- 12" to ETLO-8DM tion "* * The lineal gain for the terminations is measured to the flue gas outlet height. Astria.US.com 126764-01D...
  • Page 8 Elbow Figure 7 - Typical Offset Terminations See Detail A Ceiling Support Pipe 12S-8DM 2" Min. See Detail B Straps Straps Straps Straps Detail A Detail B Return Elbow Angle Firestop Figure 8 - Ceiling Support Pipe 12S-8DM Astria.US.com 126764-01D...
  • Page 9 When penetrating a ceiling into an attic, a firestop thimble (38FST or FST30) is required to avoid intrusion by insulation and recom- mended to negotiate a joist (see Figure 11a). Thimble 38FST or FST30 Firestop Figure 9 - Elbow Offset Figure 11a - Firestop Thimble Astria.US.com 126764-01D...
  • Page 10 A roof coating must also be applied around or wind or the chimney is not drafting properly, an ADS-8DM (Anti- perimeter of flashing to provide a proper seal. Draft Shield) can be used with round terminations. Astria.US.com 126764-01D...
  • Page 11 50 FT. (ANY SYSTEM) EFFECTIVE HEIGHT EFFECTIVE HEIGHT OF TERMINATION CAP OF TERMINATION CAP 14.5 FT. 14.5 FT. MINIMUM MINIMUM UP TO HEIGHT HEIGHT 6FT. MAX. UP TO 6FT. MAX. 30E-8DM 30E-8DM Figure 18 - Typical Residential Installations Astria.US.com 126764-01D...
  • Page 12: Optional Gas Line Installation

    WARNING: To avoid the risk of damaging the fireplace the fully open position. materials and increasing the risk of spreading a fire, do not use the fireplace to cook or warm food. Astria.US.com 126764-01D...
  • Page 13: Operation And Maintenance Guidelines

    Figure 22 - Damper and Air Kit Handle WARNING: Risk of fire! Replace grate with IHP Doors model 111028-01 only. This grate has been designed to Fully Opened keep the operation of your fireplace safe and efficient. Fireplace Front Figure 21 - Glass Doors Astria.US.com 126764-01D...
  • Page 14: Technical Service

    1508 Elm Hill Pike, Suite 108 Nashville, TN 37210 Visit us at Astria.US.com TECHNICAL SERVICE You may have further questions about installation, operation, or troubleshooting. Please contact your IHP dealer for any questions Access or concerns.
  • Page 15: Parts

    PARTS WOOD BURNING FIREPLACE MODELS TUSCAN36P2 AND TUSCAN36P3 WARNING: Contact an IHP dealer to obtain any of these parts. Never use substitute materials not approved by IHP. Use of non-approved parts can result in poor performance and safety hazards. MODEL NO.
  • Page 16 PARTS WOOD BURNING FIREPLACE MODELS TUSCAN36P2 AND TUSCAN36P3 MODEL NO. CATALOG NO. Tuscan36P2 F0540 Tuscan36P3 F0541 33/34 Astria.US.com 126764-01D...
  • Page 17 PARTS WOOD BURNING FIREPLACE MODELS TUSCAN36P2 AND TUSCAN36P3 This list contains replaceable parts used in your fireplace. When ordering parts, see Replacement Parts on page 14 of this manual. WARNING: Contact an IHP dealer to obtain any of these parts. Never use substitute materials not approved by IHP.
  • Page 18: Accessories

    Outside Air Kit Collar, Hood & 3' Flex for Floor Venting STORM COLLAR F0915 SC1-1 Storm Collar FIRESTOP SPACER F0907 3600FS-8DM-1 1" Clearance Firestop Spacer ROOF FLASHING F0909 V6F-8DM Roof Flashing 0 to 6/12 Pitch (30" Base) F0910 V12F-8DM Roof Flashing 6/12 to12/12 Pitch Astria.US.com 126764-01D...
  • Page 19 UL127 Venting Label - 50 PK pipe pipe pipe • Consult manual for clearance requirements • Consult manual for clearance requirements • Consult manual for clearance requirements 50PK • Ensure proper connection • Ensure proper connection • Ensure proper connection 900599-01 Astria.US.com 126764-01D...
  • Page 20 IMPORTANT NOTICE NOTICE: The firebox canopy (hood) Canadian code CAN/ULC-S610-M87 and other pertinent A manufactured shroud which codes require stainless steel chimney for the installation must not be modified or replaced with of this fireplace. A Cold Air Climate Kit is also required has been approved by a na- a canopy that may be provided with in Canada and is recommended for cooler regions in the...
  • Page 21 NOTES ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ Astria.US.com 126764-01D...
  • Page 22 NOTES ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ Astria.US.com 126764-01D...
  • Page 23: Warranty

    IHP in writing. IHP must be notifi ed of the claimed defect in writing within 90 days of the date of failure. Notices should be directed to the IHP Warranty Department at 1508 Elm Hill Pike, Suite 108; Nashville, TN 37210 or visit our website at WWW.ASTRIA.US.COM.
  • Page 24 WARRANTY KEEP THIS WARRANTY Model Number Serial Number Date Installed Dealer's Name Dealer's Phone Number Keep receipt for warranty verification Innovative Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information.

This manual is also suitable for:

Tuscan36p3

Table of Contents