(Except Oil Injection Models) - PowerTec 40Hp Owner's Manual

Maitenance
properly done, the engine will smoke ex-
cessively and almost stall.
Remove the outboard motor from the
test tank.
Install the silencer cover/cap of fogging
hole and top cowling.
If the "Fogging Oil" is not available, run
the engine at a fast idle until the fuel sys-
tem becomes empty and the engine
stops.
Drain the cooling water completely out
of the motor. Clean the body thoroughly.
If the "Fogging Oil" is not available, re-
move the spark plug(s). Pour a tea-
spoonful of clean engine oil into each
cylinder.
Crank several times manually.
Replace the spark plug(s).
Drain the fuel from the fuel tank.
NOTE:
Store the fuel tank in a dry, well-ventilated
place, not in direct sunlight.
Lubrication (except oil injection
models)
1.Grease the spark plug threads and in-
stall the spark plug(s) and torque to
proper specification. For information on
spark plug installation, see page 53.
2.Change the gear oil. For instructions,
see page 59. Inspect the oil for the pres-
ence of water that indicates a leaky seal.
Seal replacement should be performed
by an authorized PowertecOutBoards dealer
prior to use.
Grease all grease fittings. For further de-
42
tails, see page 52.
WARNING
Battery electrolytic fluid is dangerous; it con-
tains sulfuric acid and therefore is
poisonous and highly caustic.
Always follow these preventive mea-
sures:
Avoid bodily contact with electrolytic
fluid as it can cause severe burns or
permanent eye injury.
Wear protective eye gear when han-
dling or working near batteries.
Antidote (EXTERNAL):
SKIN - Flush with water.
EYES - Flush with water for 15 minutes
and get immediate medical attention.
Antidote (INTERNAL):
Drink large quantities of water or milk
followed by milk of magnesia, beaten
egg, or vegetable oil. Get immediate
medical attention.
Batteries also generate explosive hydro-
gen gas; therefore, you should always
follow these preventive measures:
Charge batteries in a well-ventilated ar-
ea.
Keep batteries away from fire, sparks,
or open flames (for example: welding
equipment, lighted cigarettes, and so
on.)
G DO NOT SMOKE when charging or han-
dling batteries.
KEEP BATTERIES AND ELECTROLYTIC
FLUID OUT OF REACH OF CHILDREN.