Table of Contents
Advertisement
Innovative Hearth Products
Superior
DRT40 Direct Vent Gas Fireplace
TM
TABLE OF CONTENTS
Packaging ................................................ Page
Introduction ............................................. Page
General Information ................................. Page
Requirements ........................................... Page
Cold Climate Insulation ............................ Page
Manufactured Home Requirements ......... Page
Location ................................................... Page
Vent Termination Clearances ................... Page
Appliance and Vent Clearances ................ Page 10
Pre-Installation Steps ............................... Page 11
Typical Installation Sequence .................. Page 11
Step 1. Framing ........................................ Page 11
Step 2. Routing Gas Line ......................... Page 13
Step 3. Appliance Vent Collar ................... Page 14
Step 4. Install The Venting System .......... Page 14
Vertical Termination Systems ................... Page 15
Horizontal Termination System ................ Page 20
Step 10. Remove/Install Glass Door ...... Page 32
Step 11. Burner Adjustments ................. Page 32
Step 12. Hood Installation ...................... Page 34
Finishing Requirements ........................... Page 34
Installation Accessories ........................... Page 34
Gas Conversion Kits ................................ Page 36
Important Safety Information ................... Page 38
Appliance Operation Notices ................... Page 40
General Information ................................. Page 40
Operation/Care of Your Appliance ............ Page 42
Gas Controls Access ................................ Page 42
Variable Flame Adjustment ....................... Page 43
Maintenance ............................................ Page 44
Install Volcanic Stone, Embers and Logs . Page 46
Burner Flame Appearance/Sooting and
Adjustments ............................................. Page 48
Wiring Diagrams ..................................... Page 50
Accessory Components ........................... Page 51
Maintenance Schedule ............................. Page 54
Lighting Instructions ................................ Page 55
Troubleshooting Guide ............................ Page 59
Replacement Parts List ........................... Page 61
Warranty ................................................. Page 63
Please read and understand these
instructions before beginning your
installation.
4
PACKAGING
4
The assembled vented gas fireplace heater is
4
packaged with:
4
1 - logs in a carton located within the firebox.
6
2 - one plastic bag of glowing embers in the
7
bottom compartment.
7
7
3 - literature package containing this manual,
8
warning labels and warranty; envelope is
located in the bottom compartment.
4 - one vent restrictor to be applied as shown on
Page 12 ; restrictor is taped to the envelope.
5 - one hood
6 - front face assembly with barrier installed
7 - 4" top stand off taped diagonally to the rear
of the fireplace
INTRODUCTION
The Millivolt appliances have a millivolt gas
control valve with piezo ignition system. If any
optional accessories that will require electrical
power are to be installed, the electrical power
must be provided at the time of appliance instal-
lation. The Electronic appliances are designed to
operate on natural or propane gas. An electronic
intermittent pilot ignition system provides safe,
efficient operation. External electrical power is
required to operate these units.
These vented gas fireplace heaters are sealed
combustion, air-circulating gas fireplaces de-
signed for residential applications.
Approved Vent Components - These fireplaces
are designed, tested and listed for operation
and installation with the following vent com-
ponents only:
•
Secure Vent
Direct-Vent System Compo-
®
nents manufactured by IHP,
•
Secure Flex
Flexible Vent Components
®
manufactured by IHP and
•
Z-FLEX
Model GA Venting Systems listed
®
to UL1777 and ULCS635 manufactured by
Flexmaster Canada Limited.
Use only the correct size venting (4-1/2" inner
and 7-1/2" outer).
These approved vent system components are
labeled for identification. DO NOT use any
other manufacturer's vent components with
these appliances.
NOTE:
• If the barrier becomes dam-
aged, the barrier shall be re-
placed with the manufacturer's
barrier for this appliance.
• For use with barrier(s) Part
No(s). J7420 (40" Models) and
J7428 (45" Models).
Installation and Operation Instructions
900357-00, 06/2015
GENERAL INFORMATION
WARNING
Young children should be care-
fully supervised when they are
in the same room as the appli-
ance. Toddlers, young children
and others may be susceptible
to accidental contact burns. A
physical barrier is recommended
if there are at risk individuals in
the house. To restrict access to
a fireplace or stove, install an
adjustable safety gate to keep
toddlers, young children and
other at risk individuals out of
the room and away from hot
surfaces.
AVERTISSEMENT
Les jeunes enfants devraient être
surveillés étroitement lorsqu'ils
se trouvent dans la même pièce
que l'appareil. Les tout petits,
les jeunes enfants ou les adultes
peuvent subir des brûlures s'ils
viennent en contact avec la sur-
face chaude. Il est recommandé
d'installer une barrière physique
si des personnes à risques habi-
tent la maison. Pour empêcher
l'accès à un foyer ou à un poêle,
installez une barrière de sécu-
rité; cette mesure empêchera les
tout petits, les jeunes enfants et
toute autre personne à risque
d'avoir accès à la pièce et aux
surfaces chaudes.
Children and adults should be alerted to the
hazards of high surface temperature and
should stay away to avoid burns or clothing
ignition.
Les enfants et les adultes devraient être infor-
més des dangers que posent les températures
de surface élevées et se tenir à distance afin
d'éviter des brûlures ou que leurs vêtements
ne s'enflamment.
DO NOT ATTEMPT TO ALTER OR MODIFY
THE CONSTRUCTION OF THE APPLIANCE OR
ITS COMPONENTS. ANY MODIFICATION OR
ALTERATION MAY VOID THE WARRANTY, CER-
TIFICATION AND LISTINGS OF THIS UNIT.
Hide quick links:
Advertisement
Table of Contents
