Upper And Lower Frame Components; Check Valve Assembly Removal; Valve Service Cover Removal - Electrolux EIDW6105GS0 Technical & Service Manual

C C h h e e c c k k V V a a l l v v e e A A s s s s e e m m b b l l y y R R e e m m o o v v a a l l
The check valve assembly is mounted in a slot on
the left side of the sump. A rubber flap acts as a
check valve to prevent the unfiltered water from
flowing into the delivery tube.
To remove the check valve assembly:
1. Remove the upper and lower wire rack.
2. Remove the lower spray arm.
3. Remove the fine mesh filter.
4. Remove the glass trap and vertical filter.
5. Remove the stainless steel filter.
6. Remove lower spray arm support.
7. Pull the check valve assembly out from slot in
sump. (See Figure 5-21)
U U p p p p e e r r a a n n d d L L o o w w e e r r F F r r a a m m e e C C o o m m p p o o n n e e n n t t s s
V V a a l l v v e e S S e e r r v v i i c c e e C C o o v v e e r r R R e e m m o o v v a a l l
The valve service cover is a plastic cover that
houses the floor LED and serves as a cover for
components mounted to the underside of the unit.
To remove the valve service cover:
1. Remove the outer door panel.
2. Remove toe and kickplate.
3. Using a #20 Torx bit, extract the 4 screws
securing the door assembly reinforcement to
the door hinge assembly. (See Figure 5-22)
4. Using a #20 Torx bit, extract the 2 screws
securing the valve service cover to the unit
frame.
5. Pull valve service cover downward and
carefully pull away from unit. Use caution not
to strain the wire leads of the floor LED.
6. Carefully pull back the insulation covering the
access holes of the LED light. Press in on the
retaining latches of the LED and remove from
valve service cover. (See Figure 5-23)
C C o o m m p p o o n n e e n n t t T T e e a a r r d d o o w w n n
F F i i g g u u r r e e 5 5 - - 2 2 1 1 . . V V e e r r t t i i c c a a l l F F i i l l t t e e r r R R e e m m o o v v a a l l
Door Assembly Reinforcement
F F i i g g u u r r e e 5 5 - - 2 2 2 2 . . V V a a l l v v e e S S e e r r v v i i c c e e C C o o v v e e r r R R e e m m o o v v a a l l
Press In Here
F F i i g g u u r r e e 5 5 - - 2 2 3 3 . . F F l l o o o o r r B B e e a a m m L L E E D D R R e e m m o o v v a a l l
4-11
Check Valve Assembly
Screws
Screws
Insulation