Page 1 ® ® V 4 5 8 O W N E R S M A N U A L 0 9 0 - 2 8 8 6...
Page 3 – or if it does not meet your expectations at any time during your ownership experience – please contact your Four Winns Dealer or our customer service department. In the event they are unable to assist you, or if you do not receive the response you expect, I invite you to contact me directly.
Page 4 Table of Contents Table of Contents Owner’s Manual Page 1...
Page 5 Table of Contents Owner’s Manual Page 2...
Page 6 Table of Contents Owner’s Manual Page 3...
Page 7 Table of Contents Owner’s Manual Page 4...
Page 8 Table of Contents Owner’s Manual Page 5...
Page 9 Table of Contents Owner’s Manual Page 6...
Page 10 Table of Contents Owner’s Manual Page 7...
Page 11 Table of Contents Owner’s Manual Page 8...
Page 12 Be sure to read the contents thoroughly. This manual will acquaint you with the use and maintenance of your new Four Winns boat. This manual also pro vides special information critical to the safety of the passengers, and longevity of the equipment. The infor- mation on the following page lists the graphics used to increase the visibility of these important messages.
Page 13: Safety Messages
Safety Messages The popularity of boating and other water sports has grown tremendously in the past few years. Because of this, safety is an important issue for everyone who shares our waterways. Remember that along with the freedom and exhilaration of boating comes the responsibility that you have for the safety of your passengers and the other boaters who share the water with you.
Page 14 We’d also like to remind you to be kind to our environment while you’re boating. Don’t throw garbage and other refuse overboard. Do your best to keep harmful compounds like gasoline, oil and antifreeze out of the water. Please see the notifications below: DISCHARGE OF OIL PROHIBITED THE FEDERAL WATER POLLUTION CONTROL ACT PROHIBITS THE DISCHARGE OF OIL OR OILY WASTE INTO OR UPON THE NAVIGABLE WATERS OF THE UNITED STATES, OR THE...
Page 15 Many of these stickers and labels are not required by the US Coast Guard but are important to ensure the safe operation of your Four Winns boat. In addition, the Hull Identifica tion Number plate is permanently attached below the ®...
Page 16 YACHT CERTIFICATION & WARNING LABELS NMMA Yacht Certification Plate EU Builders Plate - CE Certification Plate (Export) Canadian Conformity Label Winning Edge Sticker NMMA Certified Sticker Preface Owner’s Manual Page 14...
Page 17 Ensure slings are in proper location as indicated by the sling label location. Failure to do so may result in permanent hull structure damage and will invalidate the hull structure warranty. SLING SLING Carbon Monoxide - Cabin Doors Warning Label No Ventilation - Do Not Store Fuel Warning Label Shore Power Inlet Warning Label Carbon Monoxide - Canvas Warning Label...
Page 18 Gasoline Vapor-Blower Warning Label Rotating Propeller - Helm Warning Label Rotating Propeller - Ladder Warning Label Leaking Fuel Warning Label CO Swim Platform and Ski Tow Warning Label Lounging Area Warning Label CO-Cabin Warning Label Transom/Side Door Warning Label CO-Helm Warning Label Preface Owner’s Manual Page 16...
Page 19: Operation
SAFETY EQUIPMENT ed. Books on this subject are also available from local libraries. Besides the equipment installed on the boat by Four Winns certain other equipment is re quired A - 6 LIGHTNING for passenger safety. A booklet listing the Federal equipment requirements is included in the owner’s...
Page 20: Drugs And Alcohol
1. Visibly check the engine to be sure there are no apparent water or oil leaks. Have fun in your Four Winns boat, but also have ® the good sense to be mentally alert and physically 2.
Page 21: Engine Operation Al Proce Dures
A - 9 ENGINE OPERATION AL 5. Turn the HELM MAIN circuit breaker switch ON located on the 12VDC cabin panel. See Figure A2. PROCE DURES NOTICE Consult engine operator’s manual for specific procedure for your particular model. The following information is general in nature.
Page 22 6. As soon as engine starts, release key to the ON or RUN position. NOTICE Allow the engine to idle for the first ten seconds. Monitor all instruments and displays to ensure normal readings are shown. Check that no alarms are displayed and that no warning lights are flashing.
Page 23 3. To go in REVERSE - move the shift/throttle If you suspect there is a problem, see your engine lever(s) rearward. Once rearward gear engage- manufacturer’s authorized service center as soon as possible for proper diagnosis and required service or ment is complete, push shift/throttle lever(s) adjustment.
Page 24: Grounding And Towing
(2628) or by visiting their website at: www.boatus.com/ by improper towing have resulted in fatal injuries. courseline. Because of this, Four Winns strongly suggests that these activities be left to those who have the equip- The United States Power Squadron also offers free...
Page 25: Boat Owner Registration
boater as well as the experienced boater alike. For more information contact your local US Coast Guard Unit or call the Coast Guard info line at 1 800 The Canadian Power and Sail Squadron offers 368-5647, or visit the US Power Squadron website seamanship courses.
Page 26: Accident Reporting
A - 13 ACCIDENT REPORTING A - 16 MARPOL TREATY The operator of the boat is responsible for filing a Boats 26 feet or longer must display a sign stating the report with the appropriate authorities. In general, disposal regulations of the Federal Water Pollution reports are necessary for accidents involving loss of Control Act.
Page 27 NOTICE NOTE: Some states and localities have legal limits on speed, noise and trailer specifications. It is your responsibility to be aware of these laws and limits and to insure that your boat (and trailer) comply. Consult with your local Marine Patrol or local Coast Guard office.
Page 28: Boating Safety
Boating Safety B - 1 GENERAL The size of the PFD should be appropriate for the wearer. Body weight or chest size are common methods used to size PFDs. It is your responsibility to As the owner/operator of the boat, you are responsible ensure that you have the proper number and types of for assuring that all required safety equipment is PFDs on board and that your passengers know where...
Page 29: Fire Extinguisher
3. Teach children how to put a PFD on and allow them to try it in the water. That way, they know what the PFD is for and how it works. They will feel more comfortable with it if they suddenly find themselves in the water.
Page 30 Visual distress signal devices approved by the US at a distance of at least one-half (1/2) mile. The V458 Coast Guard are required on all recreational boats model is equipped with a dual trumpet horn which operating on coastal waters and to boats owned in meets this requirement.
Page 31: Carbon Monoxide
J. Additional Recommended Equipment swim near engine or generator exhausts when engines are running. Four Winns recommends that you acquire additional equipment for safe, enjoyable cruising. This list, Carbon monoxide accumulation is affected by many which is not all inclusive, includes items you should variables (e.g., boat geometry, hatch, window and...
Page 32 D. Effects of Carbon Monoxide NOTICE Boats fueled by diesel have limited carbon Carbon monoxide in high concentrations can be fatal mon oxide present in the exhaust in com pari- in a matter of minutes. Lower concentrations must not son to gasoline engine exhaust. However, the be ignored because the effects of expo sure to CO are boat owner should still be aware of the causes cumulative and can be just as lethal.
Page 33: Operation
3. Minimize the time spent on getting underway. F. Treatment (Evaluate, Ventilate, Evacuate, Investigate, Take Corrective Action) 4. In order to minimize CO buildup, do not warm up or run propulsion engine(s) for extended periods 1. Evaluate the situation and ventilate the area while the vessel is stationary.
Page 34: Exhaust Fumes
J. The Effect of Boats Moored Alongside A boat operator should be aware that carbon monox- ide is emitted from any boat’s exhaust. The operation, mooring, and anchoring in an area containing other boats may be in an atmosphere containing CO not of the operator’s making.
Page 35: Cabin Appliances
Figure B15: Exhaust Gas Accumulation - Dangerous Activity N. Cabin Appliances Figure B13: Operating at Slow Speed Boats having fuel burning appliances in accommo- with Following Wind dation areas should be provided with adequate ventilation and the appliance should be maintained 6.
Page 36 Gasoline powered portable generators are available specifica tions. in the marine market place and are not an option available through Four Winns. Portable generators c. Exhaust Back-Pressure - Certain alter ati ons will produce CO. These sets discharge their exhaust...
Page 37 AA. Carbon Monoxide Detection Systems 6. Checking hangers and other supports Four Winns has included three CO detectors as a 7. Ensuring blower/fan is operational standard feature. The CO detectors are located in the forward master stateroom, the main cabin/salon and 8.
Page 38: Safe Boating Practices
but it is also a Federal offense carrying a significant NOTICE penalty. These laws are vigorously enforced. The For information on CO Detection Systems, use of drugs and alcohol, singly or in combination, see American Boat and Yacht Council (ABYC decreases reaction time, impedes judgement, impairs Manual) Section A-24, “Carbon Monoxide vision, and inhibits your ability to operate a boat.
Page 39 Always use handholds and other safety hardware to F. Operation By Minors prevent falls. All nonswimmers, poor swimmers and small children should wear PFDs at all times. Minors should always be supervised by an adult whenever operating a boat. Many states have laws D.
Page 40 Slowly maneuver the boat forward to reduce tension weights to fit different boats, uses, and conditions. on the line and make retrieval of the anchor line Your Four Winns dealer can tell you which anchor easier. will work best for your boat.
Page 41: Water Sports
These are usually marked with a swim area buoy (see Figure B17). Do not swim alone or at night. PERSONAL INJURY Four Winns boats are not designed for and ® should not be used for pulling parasails, kites, gliders or any device which can become airborne.
Page 42 2. Allow no one who can not swim to water ski. 8. Approach a person in the water from the lee side Skiers must wear a USCG approved flotation (opposite the direction of the wind). Stop the motor device. A Type III water-ski vest is an approved at least a boat length from the person.
Page 43: Basic Seamanship
Basic Seamanship C - 1 GENERAL Basic rules of seamanship, general information about navigational aids, and sources for additional reading and boater education are presented in this portion of your owner’s manual. A. Boating Regulations The US Coast Guard is the authority of the waterways. State boating regulations are enforced by local authori- ties.
Page 44: Night Running
6. Night Running Boats operating between sunset and sunrise (hours vary by state), or in conditions of reduced visibility, must use navigational lights. Nighttime operation, especially during bad weather or fog, can be danger- ous. All “Rules of the Road” apply at night, but it is best to slow down and stay clear of all boats regard- less of who has right-of-way.
Page 45: Navigational Aids
blasts) if intent is not clear. A short blast is one or two buoys have a cone shaped top with their points seconds long. A long blast is 4 to 6 seconds long. The cut off. Do not pass too close to a buoy. You may Navigational Aids Chart at the end of this section lists foul the propeller in its chain.
Page 46: Recommended Reading
C - 3 RECOMMENDED READING seconds, or in groups such as two flashes and a pause. There are a number of flashing patterns, which help you identify the light at night. To identify a light, We recommend that you read the boating literature note its color and pattern or timing of flashes, and published by your state boating agency and the US compare it to your chart to find its location.
Page 47 The Service Information Sheet allows you to United States Coast Guard Auxiliary record all the pertinent information regarding your Local Flotilla or contact appropriate Coast Guard Four Winns boat. This sheet will be extremely District Headquarters ® helpful when ordering additional/optional parts for website: www.cgaux.org...
Page 48: Warranty And Service
Edge™ card within this time frame please contact The Four Winns Winning Edge™ Owner Protection your Four Winns selling dealer for resolution. If Plan provides the new Four Winns purchaser with one upon receipt of the card you discover a discrepancy, of the most comprehensive corporate commitments please notify Four Winns at 231 775-1343.
Page 49: Insurance Coverage
Four Winns® boat. A copy of this form is included in and makes a concerted effort to maintain compo- the owner’s packet. Using this form, you may want nents specifically to fill replacement part needs.
Page 50: Construction Standards
Along with boating, comes responsibility. Responsibility for safety, boating laws, and the environment. Please Show your colors! Four Winns offers a complete line think about the future of our waterways, oceans and of sports clothing designed to complement your new marine life while you’re out enjoying them and take all...
Page 51: Name / Address Change Form
NAME / ADDRESS CHANGE FORM Name & Address: ___________________________________________________ Please print clearly. ___________________________________________________ ___________________________________________________ ___________________________________________________ Telephone & E-Mail Address: ___________________________________________________ Hull Identification Number: ___________________________________________________ Boat Model: ___________________________________________________ NOTE: For warranty transfer please use the Warranty Transfer Request Form also Date of Purchase: ___________________ included in this manual.
Page 52 Warranty and Service - Section D Owner’s Manual Page 50...
Page 53: Warranty Registration Transfer Request
(5) years of the original retail sale. The transfer fee must be paid within fifteen (15) days of purchase of the used boat by check, money order or cashier’s check payable to Four Winns. We will notify the appropriate engine manufacturer of the boat warranty transfer.
Page 54 Warranty and Service - Section D Owner’s Manual Page 52...
Page 55: Engines, Drives And Instrumentation
Persons overcome by carbon monoxide may Four Winns does not manufacture engines or drives. exhibit the following symptoms: Because of the technical nature of the engine and drive systems, all manufac turers of these items a.
Page 56: Carbon Monoxide Monitor
V458. The CO Monitors are standard especially the sleeping areas. Open forward facing equipment and are located in the aft cabin, forward windows or deck hatches to provide fresh air cabin and main cabin.
Page 57 Oil Change Pump Battery Lid performance. It should be noted the V458 models include two counter-rotating Nibral propellers on each propulsion unit.. A. Diameter Diameter is twice the distance from the center of the prop shaft to the extreme tip of a propeller blade.
Page 58: Cooling Systems
The engine owners manual provides addi tional infor mation regarding service and mainte- For shipping reasons, the propellers are not factory nance of this equipment. See your Four Winns dealer installed. Initial installation of the propel lers will be for availability.
Page 59: Running Angle & Trim Tabs
Refer ence Section P-3 - Equipment Installation, in this manual for installa tion instruc tions and consult your Four Winns dealer regard ing any special equip ment that may be re- quired. Boat Properly Trimmed Never operate your engine without a thermostat.
Page 60 2) The lower button retracts the blades in parallel B. Control Listing (“BOW UP”). Wind, loading and many other factors can result in the 3) The left button lowers the starboard blade and boat tilting or leaning towards one side while running. retracts the port blade (“TILT PORT”).
Page 61: Engine Instrumentation
The labels on the trim tab switches indicate The V458’s helm station is equipped with a two what you want your boat to do, not what you want Electronic Vessel Control (EVC) system displays. One the tabs to do.
Page 62 Displays Switches Radio cooling systems. A sudden increase in the Figure E9: V458 Helm Station temperature could be a signal of a blocked cooling passage or a water pump malfunction. Operation information is shown on an LCD display. The driver can select the display mode function on...
Page 63 NOTICE NOTICE Speedometers/speed indicators are not Fuel gauges are not precision instruments. precision instru ments. The indications are The reading is relative, and should never relative and should never be used for naviga- be relied upon as the sole indicator of fuel tional purposes or similar critical situa tions availability.
Page 64 NOTICE D. Ignition Switch Four Winns does not limit you to this specific navigational package mentioned above. There The ignition switch has five positions: STOP, OFF, are many navigational systems on the market ON, ACCESSORY and START.
Page 65 3. Compass manu factur er’s literature included in the owner’s packet. A compass is standard on the V458 models. See Figure E15. The compass can provide directional 2. GPS/Plotter/Radar/Depth Sounder information when oper ating offshore, in unfamiliar waters, or in adverse weath er conditions.
Page 66: Instrument Maintenance
The ignition switches and all electronics, controls, etc. should be protected from the weath er when not in use. Four Winns provides a canvas helm cover for just such a purpose. Excessive expo sure can lead to display and igni tion switch difficulties. If these units and/or helm area itself come in contact with salt spray, simply wipe the affected surfaces with a soft.
Page 67: Control Systems
The control information included in this section Control systems permit operation of the engine’s is general only. For specific operation of the throttle and shift mechanisms. The V458 IPS models controls on your boat, refer to the control are equipped with a dual engine electronic binnacle manufacturer’s literature and engine...
Page 68: Engine Speed Synchronization
N - Neutral position. Drive-unit is disengaged 5. After shifting is completed, slowly push throttle and the engine runs at idle speed. lever(s) forward/rearward until desired speed is achieved. F - Reversing drive-unit engaged for forward movement (ahead). Any time the boat is operated, be aware of R - Reversing drive-unit engaged for rearward changes in shift system operation.
Page 69: Neutral Safety Switch
F - 3 NEUTRAL SAFETY SWITCH F - 5 CONTROL SYSTEM MAINTENANCE Every control system has a neutral safety switch The electronic binnacle control and Joystick control incorporated into it. This device prohibits the engine are designed to provide years of trouble-free operation from being started while the shift lever is in any with virtually no maintenance required.
Page 70: Steering Systems
Steering Systems G - 1 GENERAL The steering system is operated through the Electronic Vessel Control (EVC) system provides a smooth and exact steering. It offers steering capa- bilities which are not possible with traditional steering systems. Consult engine operator’s manual for specific information.
Page 71: Propeller Torque
Wind, water and currents can cause equivalent effects. On the V458 with IPS, there are two counter-rotating propellers on each propulsion unit which means there are no lateral forces to consider and that tracking is completely straight.
Page 72: Electrical Systems
AC electrical power is used for most export protection. model applications. The V458 is equipped with a triple battery system along with dockside power (including battery charg er) as standard features. The batteries are located in the DO NOT tamper with any electrical con nection,...
Page 73 Figure H3: Aft Circuit Breaker Panel and Location Figure H4: 240VAC Cabin Panel Electrical Systems - Section H Owner’s Manual Page 71...
Page 74 Figure H5: 12VDC Cabin Panel Figure H6: AC & DC Cabin Panel Locations Electrical Systems - Section H Owner’s Manual Page 72...
Page 75: System Voltage
NOTICE when the BATTERY CHARGER circuit breaker is Listed on the circuit breaker panels and cabin placed in the “ON” position. Note: On V458 models electrical panels are various labels for the with IPS the FWD BATTERY CHARGER circuit breakers protecting different component (if applicable) is not utilized.
Page 76: Volt Electrical Equipment
H - 5 12 VOLT ELECTRICAL EQUIPMENT A. Helm Equipment Helm equipment circuitry is protected by circuit breakers in the helm and/or aft circuit breaker panels, or in the cabin’s DC panel. The power is supplied to Figure H11: Helm Switch Panel the helm by the house battery when the battery is placed in the “active”...
Page 77 Navigation & Anchor Lights - Moving the NAV/ANC LIGHTS switch to the NAV position (up position) activates the bow lights, the front portion of the mast light and the instru ment lights on the dash. Move the switch to the ANC posi tion (down position) to activate the all-around portion of the mast light.
Page 78: Interior/Exterior Equipment
Below is a listing followed by a brief description of the When the engine hatch is raised, the engine room V458’s 12 volt cabin equipment. The equipment’s lights are automatically turned on. When the engine circuitry is protected by circuit breakers on the 12 volt hatch is closed the lights go off.
Page 79 pumps have a float switch which will activate the pump when the water level rises in the sump. The respective pump is protected by the SHOWER SUMP PUMP 1 or SHOWER SUMP PUMP 2 circuit breaker. Galley Refrigerator/Freezer - This refrigerator/freezer is a dual voltage unit and therefore has a circuit breaker provided on both the 240VAC cabin panel and on the 12VDC cabin panel to provide protection...
Page 80: Volt Electrical System Shutdown Procedures
H - 6 12 VOLT ELECTRICAL SYSTEM H - 7 240/120 (230V 50Hz) VOLT ELECTRI- CAL SYSTEM SHUTDOWN PROCEDURES When leaving your boat unattended for an ex tend ed The boat is equipped with 50 amp, 240/120 volt, 60 period of time it is advisable to shutdown the electrical Hertz AC electri cal wiring.
Page 81 Figure H19: Cablemaster Switch Location is activated/energized. See Figure H20. The V458 models have main circuit breakers on the Also on the AC main distribution panel is an ammeter 240V AC panel labeled SHORE and GENERATOR.
Page 82: Dockside Operation
L2 (Full 240 volt circuit). Place the switch (if appli- cable) to the OFF position when not in use. If the The V458 comes equipped with a Cablemaster shore ammeter selector switch is not installed then the full power cable storage system. This system allows one 240 volt circuit is being measured.
Page 83 Cockpit Icemaker - The cockpit icemaker is standard 1. Be sure the generator is OFF. Place the AC on the V458 models. ICEMAKER breaker located on lockout slider over the GENERATOR main circuit the 240VAC cabin panel must be ON to supply 120 breakers on the AC panel.
Page 84 ON position. Vacuum - The VACUUM circuit break er must be activated to supply power to the vacuum. Forward Battery Charger - Not applicable to the V458 with the Inboard Performance System (IPS) installed. Receptacles - The OUTLETS circuit breakers supply power to the corresponding recepta cles in the AC system.
Page 85 Operate blower for at least 4 minutes. Verify blower A diesel generator is standard on the V458 models. operation. The “green” LED when lit signifies the It provides 240 volt (230V) AC power when the boat is blower is operating.
Page 86: Electrical System Maintenance
7. Turn the generator’s main circuit breakers switch- es to the ON position. See Figure H27. Generator Strainer Generator Seawater Seacock Figure H25: Generator Seawater Seacock & Strainer NOTICE In order to use the generator, you must first open the seacock valve (handle parallel to the Figure H27: Generator Main Breakers - ON flow of valve).
Page 87: Electrical Wiring Maintenance
Check the battery fluid level often, especially when a B. Electrical Wiring Maintenance charger/converter is being used. Replen ish a battery indicating a low charge. Determine the reason for the Periodically, inspect all wiring for nicks, chaffing, dis charge. Lack of battery usage is as detrimental brittle ness, improper support, etc.
Page 88: Stray Current Corrosion
Con sult an experi enced marine electrician or contact your Four Winns dealer for assistance. The use of some shore power battery chargers, while the boat is in the water and the battery is connected to the system, can cause stray current corrosion.
Page 89: Fuel Systems
The V458 models are equipped with twin fuel tanks and come with a manual fuel valve system. The diesel fuel system used in the V458 is designed to See Figure I1. This fuel valve system allows you meet or exceed the requirements the National Marine...
Page 90: Fuel Fills
Be sure not to puncture the screen. The On the V458 separate thru-hull fuel vents are in- vent screens are designed to keep insects and foreign stalled. See Figure I3. While the tank is being filled, matter from contaminating the fuel and fuel sys tem.
Page 91: Fuel Pick-Up
EVC display. See Figure I5. the withdrawal. NOTICE On the V458 models, access to the fuel fittings is through the engine compartment. Fuel Vent Hose Diesel Return Tube Figure I5: Fuel Sender Operation...
Page 92: Fuel Filters
Because of boating conditions, speed, weight and other factors common to your situa tion, fuel consump- tion will vary between your boat and consumption figures developed by Four Winns. Avoid serious injury or death from fire or When the fuel begins to register below the “full”...
Page 93 3. Before starting to fuel: 5. After fueling: a. Ensure that boat is moored securely. a. Replace all fill caps securely. b. Close all ports, windows, doors and hatch es. b. Wipe up any spilled fuel. c. Be sure the proper type and grade of fuel as c.
Page 94 Figure I9: Fuel Valve System Components Fuel Systems - Section I Owner’s Manual Page 92...
Page 95 NOTE: GENERATOR OPTION HAS SEPARATE FUEL PICK-UP. Figure I10: Fuel Valve System Fuel Systems - Section I Owner’s Manual Page 93...
Page 96: Water And Waste Systems
For the potable water capacity, please refer to our Four Winns website at www.fourwinns.com. Tank All Four Winns V Series models are equipped with a monitoring systems are standard on the V458 model. fresh water supply system. This system consists of...
Page 97: Pressurized Water System
As drain slowly. If the system is not operat ing properly, the pressure builds, the pump will automatically shut have it checked by your authorized Four Winns off at 60 psi. Refer to Section H-5 - 12 Volt Electrical dealer.
Page 98: System Operation
C. Water Heating Systems Turn on the shower by lifting up on the shower handle. A water heater is a standard feature on the V458 Rotate the shower handle position to obtain the models. The capacity of the water heater may be de sired tempera ture.
Page 99: Gray Water System Option
Refer to the manufacturer’s literature included in the owner’s packet. Shore water connection is standard on the V458 models. This feature allows the direct con nection of a city or shoreside water supply to the boat’s water...
Page 100: Bow Washdown
Transom Dockside Water Inlet Shower Handle/ Sprayer Transom Shower Mixer (Hot/Cold) Figure J8: Transom Shower Figure J7: Dockside Water Inlet Location To use shore water, connect a hose from the shore Transom water faucet to the shore water fitting on the boat and Shower turn ON the shore water.
Page 101: Waste System
Forward Sump Fresh Water Tank Waste Holding Tank Figure J10: Bow Washdown w/ Quick Connect Hose Figure J11: Waste Holding Tank Location J - 7 WASTE SYSTEM The following basic toilet operations are discussed. Consult the toilet manufacturer’s owner’s manual for The various anti-pollution laws presently in effect have complete details regarding the toilet operations as well necessitated the use and availability of a wide variety...
Page 102 “HEAD DISCHARGE” Plate B. Head With Overboard Discharge This option is available on the V458 models. The head toilet operations are the same as the systems de- scribed earlier. A single “wye” connector is incorpo- rated into the waste holding tank system. See figure J13.
Page 103 NOTICE The discharge pump must be used to discharge waste overboard. However, DO NOT use the discharge pump to dis charge waste at a pumping station. To operate the overboard discharge system: 1. The seacock (discharge valve) is located in the Gray Water engine compartment labeled HEAD DISCHARGE.
Page 104: System Maintenance
C. Dockside Waste Pump Out 4. Remove the pump out con nection from the deck plate. Add at least 5 gallons of clean water to the On most V Series models waste pump out capability hold ing tank on most models through the waste is available.
Page 105 To winterize: NOTICE Fail ure to keep the water tank vent fit tings 1. Turn on the water pump and drain the water tank clean will cause ex ces sive pres sure build up by opening a fau cet (the pump will run faster when with in the tank dur ing fill ing.
Page 106 However, to prevent possible damage to components in your boat, Four Winns recom mends having the boat win terized by your Four Winns deal er. Water and Waste Systems - Section J Owner’s Manual Page 104...
Page 107: Ventilation And Drainage Systems
CABIN & COCKPIT VENTILATION Guard, the National Marine Manufacturers Associa- tion, and the Ameri can Boat and Yacht Coun cil. The V458 forward stateroom is equipped with a deck hatch for ventilation. See Figure K1. A. Natural Ventilation System This system includes air intake and exhaust com- ponents.
Page 108 The aft cabin window also opens to provide ventila- The center windshield may be slid open to allow tion. See Figure K3. ventilation of the cockpit as desired. See Figure K6. Figure K3: Aft Cabin Portlight Window The cabin side windows (portlight) may be opened to Figure K6 Center Windshield provide additional ventilation.
Page 109: Hull Drainage Systems
A forward and aft sump are installed in the floor, just B. Bilge Pumps forward and aft of the fresh water tank respectively. See the V458 locator drawing at the back of this Forward and aft bilge pumps are provided in the manual. These sumps collects gray water from the bottom of the hull to remove miscellaneous water various sinks &...
Page 110: Cockpit Drainage
E. Cockpit Drainage The V458 models incorporates a fiberglass self- draining cock pit. This feature minimizes water entry to the bilge or engine compartment areas by provid ing means for water to be drained over board. Periodically open all engine hatches and clean the aft bilge compartment.
Page 111: Interior Equipment
Figure L3: Sink Lid Storage safety procedures. C. Microwave Oven A microwave oven is standard on the V458 models. Microwave Flat Screen TV The circuit breaker labeled MICROWAVE on the 240V...
Page 112: Cockpit Refreshment Center
Consult the manufacturer’s information in the owner’s packet for specific operation instructions regarding your particular model. The V458 comes with a refreshment center built-in to the cockpit. The refreshment center comes with a The temperature may be controlled using the tem- solid surface countertop, blender, trash receptacle, perature control.
Page 113: Cockpit Storage
For stereo operation, please refer to the manufacturer’s manual included in the owner’s information packet. A “V458 Entertainment Quick Reference Guide” is included at the end of this section and also in the owner’s packet for convenient referral.
Page 114 Figure L11: Transom Stereo Remote Please note: Boaters may enjoy one radio station Also, the V458 comes equipped with satellite radio choice at a time in the three zones below deck, or if receiver (domestic only). Please see your Four Winns preferred, each separate zone may choose a separate dealer for information and activation.
Page 115 Satellite* Receiver Two: Channel 71 *Satellite Television System is optional. Note: A dockside phone/cable TV inlet is installed on the V458. This dockside inlet connection for telephone/cable TV is located on the starboard transom. See Figure L17. Figure L15: Private Stateroom TV Interior Equipment - Section L Owner’s Manual Page 113...
Page 116 These optional flat screen televisions are wired into the Bose Lifestyle 35 System. Please ® read the manufacturer’s information on the TV and DVD player in combination with the “V458 Entertainment Quick Reference Guide” for operation instructions. 1. Port Dash TV and DVD Player Lift Switch...
Page 117: Central Vacuum
Please read the manufacturer’s information regarding the satellite TV system along with the “V458 Enter- tainment Quick Reference Guide” for operation instructions. L - 5 CENTRAL VACUUM Central vacuum is standard equipment which makes cleaning your V458 convenient. The vacuum is...
Page 118 are adjustable to change air flow direction and can be NOTICE closed. Most air con di tion ers uti lize sur face wa ter as the cool ing me di um. Prior to us ing the air The seawater inlet valve (seacock) is identified with a con di tion ing, the boat must be in the wa ter and plate inscribed with the words “Air Conditioner Seawa- the sea cock to the air condi tion ing water intake...
Page 119 These monitors are sensitive and must be care for properly. Four Winns has included three CO Figure L25: Air Conditioner Master Stateroom detectors as a standard feature in the V458. Read the Control Panel Location manufacturer’s manual included in your owner’ packet regarding CO monitor operation, testing and mainte- nance procedures.
Page 120 V458 Entertainment Quick Reference Guide (Front) Interior Equipment - Section L Owner’s Manual Page 118...
Page 121 V458 Entertainment Quick Reference Guide (Back) Interior Equipment - Section L Owner’s Manual Page 119...
Page 122: Exterior Equipment
Their purpose is for securing the vessel to a dock, pier, mooring, or anchor. Four Winns does not recommend occupying the foredeck during bad weath er or on rough seas. DO NOT use walk-around deck instead...
Page 123: Companionway Door
M - 3 COMPANIONWAY DOOR To clean acrylic plastic (plexiglass): The V458 models have a one-piece sliding com- panionway door on a track. The companionway door 1) Rinse with plenty of water to wash off as much dirt includes a built-in screen for added ventilation and as possible.
Page 124: Foredeck Hatch
Figure M6: Forward Deck Hatch An optional windshield shade may be purchased to provide additional privacy for the cockpit. See your Four Winns does not recommend occupying Four Winns dealer for details. the foredeck during bad weath er or on rough seas.
Page 125: Extended Swim Platform
See Preface for Four Winns provides an aft, extended swim platform specific label information. on the V458 models. For better footing, a skid- resistant surface is provided. The port and starboard ladders are angled with wide step pads and deep reaching for ease of use and comfort.
Page 126: Swim Platform Lift Option
M - 7 SWIM PLATFORM LIFT OPTION If the optional swim platform lift is installed, the extended swim platform may be lowered into the water using hydraulic lifts. The control unit to operate the lift is located in the transom storage locker. See Figures M11 &...
Page 127: Bow Platform
Angled Leg Chain Stop Mount Figure M15: Transom Table Option M - 11 BOW PLATFORM Windlass The V458 models are designed with an integrated Anchor Foot Windlass bow platform. This bow platform provides a functional Locker Lid Switches base for anchoring.
Page 128: Underwater Lighting Option
Underwater lighting is an available option. With this option you can enjoy the view below the water. See The V458 models feature an engine hatch with an Figure M20. If installed please refer to the manufac- electric lift or screw jack. The screw jack lifts and turer’s literature included in the owner’s packet.
Page 129 (flag not included). The flag pole is quickly installed or removed from its holder by pushing in and rotating the pole. See Figure M24. Please consult with your Four Winns dealer regarding inqui- Figure M23: Engine Day Hatch ries with regard to this popular option.
Page 130: Interior Furnishings
Table Switch Figure N4: Dinette Table Switch Location B. Master Stateroom Four Winns provides an inner-spring mattress with fitted sheets for the master stateroom. The master stateroom also comes with a woodgrain, locking door, under berth storage, cedar lined, hanging locker, private shower (in separate area other than the head) and stand-up head.
Page 131 Figure N6: Drawer Storage Figure N9: Master Stateroom Head C. Mid Cabin Stateroom Figure N7: Under Berth Storage The mid cabin stateroom is equipped with oversized twin berths with fitted sheets. These twin berths can be converted into one large berth through the use of support boards and fill-in cushions.
Page 132: Exterior Furnishings
Figure N11: Storage Beneath Cushions Figure N12: Workstation/Desk Figure N14: Head w/Shower To pre vent per son al inju ry, be sure the mid cab in fill-in supports are se cure be fore use. N - 2 EXTERIOR FURNISHINGS Helm Seat The helm seat is double wide so it can seat two people comfortably.
Page 133: Cockpit Table
flexibility, increased visibility, and riding comfort. See Figures N15 & N16. Seat Adjustment Control Lever Figure N17: Helm Seat Under Armrest Storage B. Stern Seat Figure N15: Helm Seat w/Bolsters The custom L-shape stern seat includes a fiber glass base. The L-shape seating arrangement continues around the back of the boat to create more usable seating area.
Page 134: Port Lounge
Please refer to Section Q for information regarding the D. Port Lounge care of the table. A port side lounge provides comfortable seating and includes a teak wooden table. The port lounge can quickly be converted to a berth. The table is mounted on an electric lift, which when lowered becomes a fill- in support.
Page 135: Interior Upholstery Care
Task lights provide additional lighting and are easily N - 3 INTERIOR UPHOLSTERY CARE installed in the light base of the port lounge counter- tops. These lights screw into the bases and the switch A. Cleaning Interior Fabric/Upholstery to activate the lights are located on the same switch panel as that of the port lounge table lift.
Page 136: Exterior Upholstery Care
Vinyl Finish Cleaner will not remove the 303. B. Interior Carpets NOTICE Four Winns Vista cruisers use a high quality interior ® DO NOT apply vinyl protectants such as grade carpeting. Interior carpeting should be cleaned Armorall .
Page 137 • Vinyl Finish Vinyl Cleaner 5. Tough Mildew Stains: ® (everyday cleaning & care, call 800-247-9901) Apply a mixture of one (1) teaspoon am monia, • 303 Aerospace Vinyl Protectant one-fourth (1/4) cup of hydrogen peroxide, and ® (for ordering information call 800-247-9901) three-fourths (3/4) cup of distilled water;...
Page 138 Regular vacuuming and occasional sham- manufacturer and is included with this man ual. pooing will help it stay attractive and serviceable. Four Winns offers a variety of optional weather covers D. Stain Removal Testing for protection of the boat and associated equipment.
Page 139: Replacement Upholstery
E. Stain Removal Procedures i t o Regular maintenance such as vacuuming, hosing or washing should be performed. Most stains and i t o mildew are easily removed from carpet made with Olefin fiber using common household cleaners. Refer to Table I. Olefin™ fiber is so resistant to chemi cal attack that Clorox™...
Page 140: Weather Covers
A canvas top with a curtain ® heavy rain can cause severe damage to the set is standard on the V458 models. This cover is material or top structure. Refer to O-7 - Winter de signed and intended to provide protection of the Storage in this manual for more infor mation.
Page 141: Canvas Installation
9) Clean canvas with warm water, mild soap and a soft brush. For the clear Isinglass pieces use a soft, clean cloth. Be certain to rinse cloth often to remove any dirt collected in the cloth that could scratch the clear vinyl. Upper Lower Track...
Page 142 Figure O6: Canvas Top Button-Release NOTICE Canvas should be snug. If overly taut or extremely tight, canvas could tear or pull at seams. To install the sides & aft curtains: 1) Valances, small areas of canvas curtain, are used Figure O4: Adjustable Bow Support Poles to attach the side curtains to the boat.
Page 143: Use Of Weather Covers And Carbon Monoxide
Figure O10: Carbon Monoxide Warning Label NOTICE It is recommended that you retain your canvas locator tags. In the event that replacement parts are needed, contact your Four Winns dealer. Weather Covers - Section O Owner’s Manual Page 141...
Page 144: Winter Storage
A winter storage cover is advisable. help prevent shrinkage. Many marine dealers offer shrink wrap enclosures for outdoor storage. See a Four Winns dealer for informa- 3. Chemicals cause decay if allowed to accumu late tion on the availability of winter storage covers or other for long periods of time.
Page 145: Fiberglass And Hull Information
This en sures a strong, rigid hull, permanently formed during the boating season. into a solid as sembly, free of distor tions. Four Winns utilizes fade-fighting gel coat in the Fiberglass cockpit liners and seat base are construct- exterior finish. It is specially formulat ed to resist fading ed similar to the hull.
Page 146 Make sure prod uct is formulated for gel coat surfaces. something. Also, consult a Four Winns dealer for their recom- mendations. Yellowing is gel coat which has a yellow cast and...
Page 147: Fiberglass Repairs
If this does not work, consult your Four Winns dealer for profes- 2. Use clean pads or cloths to apply a thin coat ing sional assistance.
Page 148: Osmotic Blistering
400 to 600 wet or dry sandpaper and follow with rubbing compound and wax. supplier handling fiber glass rein fo rced products. Contact your Four Winns dealer for assis tance. B. Gouges & Cracks 8. After ample drying time, sand the area using very Stress cracks and crazing are the appearance of fine wet/dry sandpaper.
Page 149: Anti-Fouling Paint
Four Winns recommends this prevent the possibility of reoccurrence of blisters. Your procedure as a preventive and effective means of Four Winns dealer or local ship store will have informa- controlling osmotic blistering. Most major antifouling tion on barrier coat prod ucts.
Page 150 This could lead to hull deformation and thus serious performance deficien cies. Four Winns offers an optional storage cradle built to properly fit your V458. Contact your Four Winns dealer for details. Figure P1: V458 Bottom Paint Line Location Exterior Equipment - Section P Owner’s Manual Page 148...
Page 151: Woodwork And Composites
To clean star board, use a solvent-free, nonabrasive cleaner such as hand dish washing soap and water. Much of the V458 interior components such as the Read the la bel before using any clean ing product. shelving, closets, closet door and drawer fronts consist of a high pressure laminate material.
Page 152: Solid Surface Material
Figure Q5: Galley Countertop Figure Q4: Port Lounge Table Before teak can be given any coating, it must be completely clean. Follow the manufacturer’s directions with regard to cleaning. Once cleaning has been accomplished there are finishes that may be applied such as teak oil (traditional), sealers, or varnishing.
Page 153 Figure Q10: Companionway Door To clean acrylic plastic: 1) Rinse with plenty of water to wash off as much dirt as possible. 2) Using your bare hand, along with plenty of water, feel and remove any dried on dirt or mud. Do not use fingernails to scrape as this could scratch the plexiglass.
Page 154 Q - 8 FLEXITEEK An available option is a flexiteek cockpit and/or swim platform. Flexiteek is made up of a composite PVC based material with a surprising similarity and look to that of real teak. Flexiteek can be cleaned with mild dishwashing detergent.
Page 155: General Maintenance
General Maintenance R - 1 WINTERIZATION a high pressure washer. See engine manual for special concerns. A. Prior to Lifting for Winter Lay-up 3. Lower boat onto cradle properly. Be sure boat is 1. Pump out the head (dockside discharge), and gray adequately support ed.
Page 156 10. Clean the boat interior thoroughly. Vacuum NOTICE carpets, and dry clean drapes and upholstery Boats stored outside in areas with heavy snow jackets as necessary. accumulation are more susceptible to damage, and should be inspected regularly during the 11. Wash exterior fiber glass components, wax lightly. winter months.
Page 157: General Maintenance Schedule
R - 3 GENERAL MAINTENANCE SCHEDULE SEASONALLY SEASONALLY AT LAUNCH 25 HOUR OR EVERY 12 OR EVERY 6 SERVICE AND FIRST CHECK EACH MONTHS OR MONTHS OR OPERATION* SEASON* EVERY 200 EVERY 100 HOURS* HOURS* Refer to Section E Engine and Instrumentation As Recommended by the Manufacturer Engine Maintenance lnspect Exhaust System Hoses and Connections...
Page 158 SEASONALLY SEASONALLY AT LAUNCH 25 HOUR OR EVERY 12 OR EVERY 6 SERVICE AND FIRST CHECK EACH MONTHS OR MONTHS OR OPERATION* SEASON* EVERY 200 EVERY 100 HOURS* HOURS* Refer to Section J Water Systems lnspect All Water Systems Fresh, Gray & Waste Holding Tank Inspections Drain &...
Page 159 SEASONALLY SEASONALLY AT LAUNCH 25 HOUR OR EVERY 12 OR EVERY 6 SERVICE AND FIRST CHECK EACH MONTHS OR MONTHS OR OPERATION* SEASON* EVERY 200 EVERY 100 HOURS* HOURS* Refer to Section N Upholstery Clean Upholstery Clean Carpet Spray Upholstery with Lysol Check Seat Hinges and Mounting Hardware Refer to Section O Weather Covers...
Page 160: Pre-Launch And Underway
Pre-Launch and Underway S - 1 LAUNCH AND CRUISE CHECKLIST Get a current weather report. If the weather will not be favorable, postpone your trip. If your boat has been out of the water, check to see that all bilge water has drained out. Install hull drain plugs.
Page 161: Pumping Fuel
4. Stand away from the fuel tank vent and gas fill during fueling. Splash back may occur and can be an eye irritant and/or a fire hazard. The fuel system components used by Four Winns will ® withstand up to 10% alcohol content in the gasoline.
Page 162: Loading Passengers And Gear
S - 3 LOADING PASSENGERS AND GEAR A. Preliminary Checks 1. Secure boat to the dock before attempting to start When loading your boat, remember to distribute the engine. The boat should be kept secure until the load evenly. Keep the load low and do not overload. engine is running and warmed up.
Page 163 5. Check for audible warnings, information messages A. Leaving the Dock or alarms on EVC system displays. You are ready to leave the dock after the engine has warmed up. Check all EVC displays for appropriate 6. Activate the control position by pressing the EVC readings before casting off.
Page 164: Trimming Your Boat
Remember that all boats steer by the stern (the feeling S - 7 TRIMMING YOUR BOAT is much like steering your automobile in reverse). This means that the stern of your boat will swing in the Trim tabs are used to add lift to the boat’s stern, direction opposite to your turn.
Page 165: Navigation Lights
S - 8 NAVIGATION LIGHTS Trim your boat to compensate for seas, winds, or un- even loads. Although night activities are limited, cruising at night can be very pleasurable. It can also be dangerous if Head Seas Trim drives in more than you don’t pay close attention to water levels and usual.
Page 166: Running Aground
The present and forecasted weather conditions are of • Station a person forward on the boat as a primary consideration, but a threat of possible storms lookout. should always be a concern. Observance of the following information will help in your safety afloat if •...
Page 167: Reacting To Emergencies
D. Warning Markers C. Capsizing Wear PFDs or have them readily available at all times. It is a good idea to find out about hazardous areas and If your boat capsizes, and others were on board, how they are marked by asking your local authorities. locate them and guide them to the safety of the hull.
Page 168: Medical Emergency
4. If the bow of the other boat penetrated your boat’s • Extinguish smoking materials carefully. hull, prepare to block the opening once the boats • Use special care with flame or high temperatures are separated. around urethane foam. 5. Shore up the hole with a spare PFD or bunk cushion from your boat.
Page 169: Steering Failure
he alarm and take the recommended measures J. Steering Failure referred to in “Fault Register” chapter of the engine manual. It may be advisable to shut down the engines Note: Refer to your engine manual for specific on both sides and try to restart them again. If error information regarding steering failure.
Page 170 The size (diameter) of your line depends on the size and weight of your boat. The following is an approximate guide. See your Four Winns dealer for recommendations. Line Diameter Boats under 20 feet = 3/8”...
Page 171 Figure S3: Mooring Lines Pre-Launch and Underway - Section S Owner’s Manual Page 169...
Page 172 Glossary ABAFT - Toward the rear of a boat. BILGE - The lowest interior area of a hull, used to collect water that has entered. ABEAM - At right angles to the keel of the boat. BILGE PUMP - A pump intended for removal of spray, ABOARD - On the boat.
Page 173 CAPSTAN - A machine that moves a cylindrical DEAD RECKONING - A plot of courses steered and device on a shaft for the purpose of hauling up an distances traveled through the water. anchor. DECK - A permanent covering over a compart ment, CAST OFF - To let go.
Page 174 EVEN KEEL - To be floating evenly without listing to FREEBOARD - The minimum vertical distance from the surface of the water to the gunwale. either side. FREQUENCY - The number of crests passing a fixed EXHAUST SYSTEM - The means by which the hot engine (or generator) exhaust gases are moved from point at a given time.
Page 175 HARDTOP - A permanent cover over the cabin or ISOTHERMS - Isotherms are lines that are similar to cockpit. Isobars except that Isotherms connect all the points that are of equal temperature. HAWSER - A heavy rope or cable used for moor ing or towing.
Page 176 MODEL DESIGNATOR - Model identifier or model POINT - One of 32 points of the compass that is equal name. to 11-1/4 degrees. MOORING - An arrangement for securing a boat PORT - 1. Looking forward, the left side of a boat, to a mooring buoy or pier.
Page 177 SHACKLE - A “U” shaped connector with a pin STRUT - A propeller shaft support that is below or bolt across the open end. the hull. SHAFT - The long, round member that connects SUMP - A pit or well into which water is drained. the engine or transmission to the propeller.
Page 178 WATER LINE - The line of the water on the hull when the vessel is afloat. WATCH - A 4 hour duty period while at sea. WAVES - Waves are periodic disturbances of the sea’s surface, caused by wind, seaquakes, and the gravitational pull of the moon and the sun.
Page 179: Float Plan
Coast Guard, or other rescue organization, should you not return as scheduled. DO NOT file this plan with the Coast Guard. Name ________________________________________________ Telephone ______________________________ Description of Boat __________________________ Type _________ Color ____________ Trim ____________ Registration Number ___________________________________________________________________________ Length ___________________ Name __________________________ Make ____________________________ Four Winns ® Hull Identification Number ___________________________________________________ Other Information _____________________________________________________________________________ Persons Aboard: Name Address...
Page 180: Fuel Log
Fuel Log Fuel Log Owner’s Manual Page 178...
Page 181 Fuel Log Fuel Log Owner’s Manual Page 179...
Page 182 Fuel Log Fuel Log Owner’s Manual Page 180...
Page 183: Service Log
Service Log Service Log Owner’s Manual Page 181...
Page 184 Service Log Service Log Owner’s Manual Page 182...
Page 185 Service Log Service Log Owner’s Manual Page 183...
Page 186: Service Information
Service Information & Service Information Owner’s Manual Page 184...
Page 187 V458 Locator Drawing Note: Representative Locations Only - availability and locations of equipment may vary depending on optional equipment installed. Locations and availability is subject to change without notice. Locator Drawing Owner’s Manual Page 185...
Page 189 www.fourwinns.com...

Four winns V458 Owner's Manual

Quick Links

Related Manuals for Four winns V458

Summary of Contents for Four winns V458

Table of Contents