Page 1
® ® 3 3 8 V I S T A O W N E R S M A N U A L ® 0 9 0 - 2 8 6 0...
Page 3
– or if it does not meet your expectations at any time during your ownership experience – please contact your Four Winns Dealer or our customer service department. In the event they are unable to assist you, or if you do not receive the response you expect, I invite you to contact me directly.
Page 4
Table of Contents Table of Contents Owner’s Manual Page 1...
Page 10
Table of Contents Owner’s Manual Page 7...
Page 11
Table of Contents Owner’s Manual Page 8...
Page 12
Be sure to read the contents thoroughly. This manual will acquaint you with the use and maintenance of your new Four Winns boat. This manual also pro vides special information critical to the safety of the passengers, and longevity of the equipment. The infor- mation on the following page lists the graphics used to increase the visibility of these important messages.
Safety Messages The popularity of boating and other water sports has grown tremendously in the past few years. Because of this, safety is an important issue for everyone who shares our waterways. Remember that along with the freedom and exhilaration of boating comes the responsibility that you have for the safety of your passengers and the other boaters who share the water with you.
Page 14
We’d also like to remind you to be kind to our environment while you’re boating. Don’t throw garbage and other refuse overboard. Do your best to keep harmful compounds like gasoline, oil and antifreeze out of the water. Please see the notifications below: DISCHARGE OF OIL PROHIBITED THE FEDERAL WATER POLLUTION CONTROL ACT PROHIBITS THE DISCHARGE OF OIL OR OILY WASTE INTO OR UPON THE NAVIGABLE WATERS OF THE UNITED STATES, OR THE...
Many of these stickers and labels are not required by the US Coast Guard but are important to ensure the safe operation of your Four Winns boat. In addition, the Hull Identifica tion Number plate is permanently attached below the ®...
Page 16
YACHT CERTIFICATION & WARNING LABELS NMMA Yacht Certification Plate GASOLINE VAPORS CAN EXPLODE RESULTING IN INJURY OR DEATH. BEFORE STARTING ENGINE CHECK ENGINE BILGE COMPART- MENT FOR GASOLINE OR VAPORS, OPERATE BLOWER FOR FOUR MINUTES, AND VERIFY BLOWER OPERATION. Gasoline Vapors - Blower Warning Label RUN BLOWER WHEN VESSEL IS OPERATING BELOW CRUISING SPEED.
Page 17
Ensure slings are in proper location as indicated by the sling label location. Failure to do so may result in permanent hull structure damage and will invalidate the hull structure warranty. SLING No Ventilation - Do Not Store Fuel Warning Label Shore Power Inlet Warning Label Carbon Monoxide - Cabin Doors Warning Label Dockside Air Conditioning Inlet Label...
Page 18
Gasoline Vapor-Blower Warning Label Rotating Propeller - Helm Warning Label Rotating Propeller - Ladder Warning Label Leaking Fuel Warning Label CO Swim Platform and Ski Tow Warning Label Lounging Area Warning Label No Ventilation - Do Not Store Fuel Warning Label Transom/Side Door Warning Label CO-HELM WARNING LABEL CO-CABIN WARNING LABEL...
SAFETY EQUIPMENT ed. Books on this subject are also available from local libraries. Besides the equipment installed on the boat by Four Winns certain other equipment is re quired A - 6 LIGHTNING for passenger safety. A booklet listing the Federal equipment requirements is included in the owner’s...
NEVER allow an obviously intoxicat ed person to take the helm. 2. Check the gauges. Make sure the oil pres sure, water temperature, voltmeter, etc. are reading Have fun in your Four Winns boat, but also have ® normally.
Page 22
A - 9 ENGINE OPERATION AL B. Cold Engine Starting Procedures - Volvo Penta Engines w/Teleflex I-6000 PROCE DURES 1. Move the dual shift/throttle lever of the control NOTICE head to the neutral idle detent positions. When in Consult engine operator’s manual for the neutral idle detent position, pushing the “N”...
Page 23
2. For gasoline engines, turn key switch to START D. Shifting and Control Speed position and hold until engine starts. DO NOT hold in START position for more than ten seconds. NOTICE If engine does not start, let go momentarily, then If your boat is equipped with a non-OEM try again.
“Boating Skills & Seamanship Course,” and informa- D. Laws and Regulations tion can be obtained by calling 1 800-336-BOAT (2628) or by visiting their website at: www.boatus.com/ The US Coast Guard is the authority of the water- courseline. ways; they are there to help the boating public. State boating regulations are enforced by local authorities.
A - 14 DISCHARGE OF OIL The Federal Water Pollution Control Act prohibits the discharge of oil waste into or upon the navigable waters of the United States or the waters of the contiguous zone if such discharge causes a film or sheen upon or a discoloration of the surface of the water or causes a sludge or emulsion beneath the surface of the water.
Page 27
The placard also must note that State and local regulations may further restrict the disposal of garbage. Operators shall display one or more placards in a prominent location and in sufficient numbers so they can be observed and read by crew and passengers. These locations might include embarkation points, food service areas, galleys, garbage handling spaces and common deck spaces frequented by crew and...
Boating Safety B - 1 GENERAL The size of the PFD should be appropriate for the wearer. Body weight or chest size are common methods used to size PFDs. It is your responsibility to As the owner/operator of the boat, you are responsible ensure that you have the proper number and types of for assuring that all required safety equipment is PFDs on board and that your passengers know where...
3. Teach children how to put a PFD on and allow them to try it in the water. That way, they know what the PFD is for and how it works. They will feel more comfortable with it if they suddenly find themselves in the water.
Page 30
(daytime); or three red flares of hand held, An automatic FE241 agent fire extinguisher system is meteor, or parachute type (daytime/nighttime). standard on the 338 Vista models. The equipment ® utilized has been so chosen, and located, to provide...
J. Additional Recommended Equipment periods of time at idle speed, and be sensitive to weather conditions that may prevent CO Four Winns recommends that you acquire additional from dissipating into the air. Do not stand or equipment for safe, enjoyable cruising. This list,...
Page 32
A. Properties and Characteristics of Carbon Certain health related problems and age will increase Monoxide the effects of CO. People who smoke or are exposed to high concentrations of cigarette smoke, consume 1. Carbon Monoxide is a colorless, odorless and alcohol or have lung disorders or heart problems, are tasteless gas.
Page 33
4. Administer oxygen if available. The following are examples of possible 5. Contact medical help. If the victim is not breathing, situations where carbon monoxide can perform rescue breathing or approved cardiopul- accumulate within your boat while docked, monary resuscitation (CPR), as appropriate, until anchored, or underway.
J. The Effect of Boats Moored Alongside A boat operator should be aware that carbon monox- ide is emitted from any boat’s exhaust. The operation, mooring, and anchoring in an area containing other boats may be in an atmosphere containing CO not of the operator’s making.
Figure B15: Exhaust Gas Accumulation - Dangerous Activity N. Cabin Appliances Figure B13: Operating at Slow Speed Boats having fuel burning appliances in accommo- with Following Wind dation areas should be provided with adequate ventilation and the appliance should be maintained 6.
Page 36
Gasoline powered portable generators are available specifica tions. in the marine market place and are not an option available through Four Winns. Portable generators c. Exhaust Back-Pressure - Certain alter ati ons will produce CO. These sets discharge their exhaust...
Page 37
AA. Carbon Monoxide Detection Systems 6. Checking hangers and other supports Four Winns has included two CO detectors as a 7. Ensuring blower/fan is operational standard feature. One of the CO detectors is located in the forward V-berth and the other is located in 8.
• Observe all safety signs and warnings both A CO detector is not a gas/fuel vapor detector. inside the boat and in the immediate boating Gas/fuel vapor detectors do not monitor the area. buildup of carbon monoxide in an enclosed area.
Page 39
D. Propeller F. Operation By Minors Minors should always be supervised by an adult whenever operating a boat. Many states have laws Personal Injury! regarding the minimum age and licensing require- Do not allow anyone near a propeller, even ments of minors. Be sure to check local laws or when the engine is off.
Fasten the anchor line around the bow eye or deck Your Four Winns dealer can tell you which anchor cleat. Anchor flukes should dig in and catch. Watch for will work best for your boat.
Page 41
on board to observe the person in the water so the 9. Do not allow anyone near the propeller(s), even driver can concentrate on operating the boat. when the engine is off. Propeller blades are sharp and can continue to turn even after the engine is A.
Page 42
7. Give immediate attention to a person who has 10. Do not water ski between sunset and sunrise. fallen. He or she is vulnerable in the water alone It is illegal in most states. and may not be seen by other boaters. For more information about waterskiing, wakeboard- 8.
Basic Seamanship C - 1 GENERAL Basic rules of seamanship, general information about navigational aids, and sources for additional reading and boater education are presented in this portion of your owner’s manual. A. Boating Regulations The US Coast Guard is the authority of the waterways. State boating regulations are enforced by local authori- ties.
6. Night Running Boats operating between sunset and sunrise (hours vary by state), or in conditions of reduced visibility, must use navigational lights. Nighttime operation, especially during bad weather or fog, can be danger- ous. All “Rules of the Road” apply at night, but it is best to slow down and stay clear of all boats regard- less of who has right-of-way.
blasts) if intent is not clear. A short blast is one or two buoys have a cone shaped top with their points seconds long. A long blast is 4 to 6 seconds long. The cut off. Do not pass too close to a buoy. You may Navigational Aids Chart at the end of this section lists foul the propeller in its chain.
C - 3 RECOMMENDED READING seconds, or in groups such as two flashes and a pause. There are a number of flashing patterns, which help you identify the light at night. To identify a light, We recommend that you read the boating literature note its color and pattern or timing of flashes, and published by your state boating agency and the US compare it to your chart to find its location.
1 800 368-5647 The Service Information Sheet allows you to Skippers Course record all the pertinent information regarding your GPO Superintendent of Documents Four Winns boat. This sheet will be extremely ® Washington, DC 20012 helpful when ordering additional/optional parts for 202 512-1800 your boat or when having service work done.
Edge™ card within this time frame please contact The Four Winns Winning Edge™ Owner Protection your Four Winns selling dealer for resolution. If Plan provides the new Four Winns purchaser with one upon receipt of the card you discover a discrepancy, of the most comprehensive corporate commitments please notify Four Winns at 231 775-1343.
Four Winns® boat. A copy of this form is included in and makes a concerted effort to maintain compo- the owner’s packet. Using this form, you may want nents specifically to fill replacement part needs.
D - 12 WINNGEAR Along with boating, comes responsibility. Responsibility for safety, boating laws, and the environment. Please Show your colors! Four Winns offers a complete think about the future of our waterways, oceans and line of sports clothing designed to complement your marine life while you’re out enjoying them and take all...
Page 51
Warranty and Service - Section D Owner’s Manual Page 48...
NAME / ADDRESS CHANGE FORM Name & Address: ___________________________________________________ Please print clearly. ___________________________________________________ ___________________________________________________ ___________________________________________________ Telephone & E-Mail Address: ___________________________________________________ Hull Identification Number: ___________________________________________________ Boat Model: ___________________________________________________ NOTE: For warranty transfer please use Date of Purchase: ___________________ the Warranty Transfer Request Form also included in this manual NAME / ADDRESS CHANGE FORM Name &...
Page 53
Warranty and Service - Section D Owner’s Manual Page 50...
(5) years of the original retail sale. The transfer fee must be paid within fifteen (15) days of purchase of the used boat by check, money order or cashier’s check payable to Four Winns. We will notify the appropriate engine manufacturer of the boat warranty transfer.
Page 55
Warranty and Service - Section D Owner’s Manual Page 52...
Persons overcome by carbon monoxide may Four Winns does not manufacture engines or drives. exhibit the following symptoms: Because of the technical nature of the engine and drive systems, all manufac turers of these items a.
CO Fatal carbon monoxide poison ing can occur. intoxication. See your Four Winns dealer for assistance in diagnosing the cause for the alarm. 6. If possible, ventilate your cabin while under way.
Page 58
It should be noted the 338 Vista ® Changing either diameter or pitch will have an effect models include stainless steel propellers.
See your Four Winns dealer A. Raw Water Cooling for availability. Most of the 338 Vista® stern drive engines utilize a raw water cooling system. This cooling system is a seawater system. Seawater (raw) water is taken in...
Some boating areas require that additional water intake filters be installed. Refer ence Section P-3 - Equipment Installation, in this manual for installa tion instruc tions and consult your Four Winns dealer regard ing any special equip ment that may be re- quired.
Pressing the upper port trim tab switch will cause the NOTICE starboard trim tab to move downward and will force DO NOT operate the engine with the stern the port bow downward. drive tilted up. Severe damage to the engine drive system can result.
Steer ing and handling difficulties can result from im proper trim tab usage, espe cially in a following sea. ® Figure E5: 338 Vista Helm Station If unsure of proper trim tab positioning, raise the trim tabs to the full-up position.
Page 63
B. Speedometer possible seizure. Have the en gine ser viced immediately upon a reduced oil pressure A speedometer is not be available on the 338 Vista ® indication. models. With the optional GPS/Navigational package the ability to monitor your speed becomes available.
K. Alarm System damage. Refer to Section I - Fuel System for additional information. The 338 Vista® models have an engine alarm system installed. This is an audible alarm that is mounted in G. Power Trim Gauge the helm area; it is actuated by engine water tempera- ture and engine oil pressure senders.
Page 65
(Representative View - Models & Equipment May Vary) 4. Compass 1. Ship to Shore VHF Radio A compass is standard on the 338 Vista models. ® A VHF radio is optional equipment offered with the See Figure E9. The compass can provide directional selection of the navigation package option.
Page 66
The ignition switches and all instru- ments, controls, etc. should be protected from the weath er when not in use. Four Winns offers appropri- ate weather covers for each mod el. Excessive expo- sure can lead to gauge and igni tion switch difficul ties.
Do not exceed The throttle shift control used is determined by the 2000 RPM in NEUTRAL. type of engines that are installed the 338 Vista . The ® 338 Vista either is equipped with a digital throttle/shift ®...
When the engines are in proper syn chronization, the throttle levers may not neces sarily be in the same position. Any time the boat is operated, be aware of changes in shift system operation. A sudden B. Shifting and Control Speed increase in shift effort of the shifter levers, or other abnormal operation, indicates a possible 1.
Page 69
Periodic inspections of the controls, actuators, cables, and all connections should be made. Signs of loose- ness, rust, corrosion, wear, cable jacket cracks or other deterioration require immediate system servic- ing. Replace all damaged components. Replace- ments of damaged components should be completed by authorized service technicians.
If adjustment becomes necessary, A load is placed on the steering system by the propel- see your Four Winns dealer. ler torque, and/or water flowing past the outdrives. The steering system is designed to normalize the...
DUAL ENGINE - TRIPLE BATTERY H - 1 GENERAL SYS TEM All electrical equipment on the Four Winns 338 Vista ® models operates on 12 volts DC or 120 volts (220 volts Two battery selector switches are installed on dual en- on 50 Hertz models) AC electrical power.
Page 73
position for normal boat operation. This position allows Battery Selector Switch - Dual maximum use of 12 volt equipment on the boat. The battery selector switch positions for the dual battery selector switch is as follows: Emergency Start Procedures: If one of the designated engine batteries fails to start “OFF”...
BATTERY CHARGER may be wired to a circuit breaker in the AC/DC cabin panel. For additional information on adding accesso- The battery charger is standard on the 338 Vista ® ries, refer to Section H-5B. models and is located in engine compartment. The...
Page 75
B. Installation of Additional 12 Volt Equip ment Gasoline vapors can explode resulting in injury Accessories may be added to the boat by wiring or death. Before starting the engine, check directly to the cabin panel. Non-factory in stalled 12 engine compartment bilge for gasoline or volt accessory equipment can be con nected to the vapors.
12 volt cabin AC/DC panel. The MAIN dockside inlets are located in the aft transom systems locker. The 338 Vista models have ® Sump Pump - A sump pump is used to dis charge MAIN circuit breakers for either the generator or shore water from the shower and sink drains overboard.
Some marinas are not equipped with approved twistlock-type receptacles. An adaptor is available from Four Winns which converts the twist-lock shore B. 120 Volt AC Equipment plug to a three-wire grounded household type plug. Use only an approved adaptor when an adaptor is All 12 volt equipment is isolated from the 120 volt AC necessary.
Page 78
Cockpit Icemaker or Refrigerator - The cockpit to the inlet. DO NOT activate the shore power switch icemaker is standard on the 338 Vista models. A ® in the cabin when the reverse polarity light is on.
Page 79
H - 9 GENERATOR at idle speed. Check the bilge blower output before each use. A generator is optional on the 338 Vista models. It ® provides 120 Volt (220V) AC power when the boat is away from the dock. The gener ator can be operated while running at or below cruising speed.
H - 10 ELECTRICAL SYSTEM MAINTENANCE Disconnect the battery before working on A. Battery Maintenance electrical or ignition system to prevent electrical shock and accidental ignition. Be sure to keep the batteries charged. Also, keep the batteries clean, especially the terminals and con nection lugs.
Con sult an experi enced marine electrician or contact your Four Winns dealer for assistance. The use of some shore power battery chargers, while the boat is in the water and the battery is connected to the system, can cause stray current corrosion.
Page 82
FIGURE H4: 338V GENERATOR OPTION (1 0F 4) Electrical Systems - Section H Owner’s Manual Page 79...
Page 83
FIGURE H5: 338V GENERATOR OPTION (2 0F 4) Electrical Systems - Section H Owner’s Manual Page 80...
Page 84
FIGURE H6: 338V GENERATOR OPTION (3 0F 4) Electrical Systems - Section H Owner’s Manual Page 81...
An entry on the Four Winns to their respective engine. See Figure I1. The capacity Pre- Delivery Inspection Form portion of the Warranty of the fuel tank(s) may be found on our website at Registration Card will attest to the deal er’s perfor-...
O-ring’s longevity. C. Fuel Vents On the 338 Vista® separate thru-hull fuel vents are installed. See Figure I3. While the tank is being filled, the air displaced by the fuel es capes through the vent overboard.
H. Gas Vapor Detector angle of the fuel in the tank as shown in Figure I6. A gas vapor detector is available on the 338 Vista® models. The gas vapor detector will moni tor the engine compartment and notify the operator of an accumula tion of gasoline vapo rs.
Always personally inspect the engine compart- To conform to Federal Air Quality Stan dards, the petro leum industry reduced the amount of ment and sniff for fuel vapors before starting the engine. Remember, a gas vapor detector is tetraeth yl lead in gasoline. Alcohol is being a mechan i cal de vice.
blower for four (4) minutes. Then, prior to starting the engine(s), check the bilge area for the scent of gasoline fumes; DO NOT start the engines if the odor of gasoline is detected. 3. Frequently inspect the fuel system fittings. Inspect the fuel tank, pump and filter for signs of leaks or corrosion.
Page 91
NOTE: GENERATOR OPTION HAS SEPARATE FUEL PICK-UP. Figure I8: Fuel Valve System Fuel Systems - Section I Owner’s Manual Page 88...
™ Four Winns website at www.fourwinns.com. Tank bleach (5% sodium hypochlorite solu tion). This monitoring systems are standard on the 338 Vista ® is recommended for each 15 gallons of tank model. These indicators are located in the head for capacity.
All drains are equipped with traps, and the water will tank is to remain empty for an extend ed period of drain slowly. If the system is not operat ing properly, time. have it checked by your authorized Four Winns dealer. C. Water Heating Systems J - 2...
SHORE WATER CONNECTION become exces sively wet. Thor oughly dry these areas after showering. Shore water connection is standard on the 338 Vista ® models. This feature allows the direct con nection of a city or shoreside water supply to the boat’s water...
TRANSOM SHOWER water and impurities from accumulating in the system over time. A transom shower with a choice of hot/cold water is standard on the 338 Vista models. The shower unit is ® The VacuFlush toilet operates in a different way from ®...
Page 96
This thru-hull valve (seacock) must be closed to prevent water from B. Head With Overboard Discharge being forced back into the system. This option is available on the 338 Vista models. The ® head toilet operations are the same as the systems described earlier.
4. Remove the pump out con nection from the deck NOTICE plate. Add at least 5 gallons of clean water to the Discharging waste overboard is illegal in most hold ing tank on most models through the waste US waters today. Discharge is limited to deck fitting using a dockside water hose.
Page 98
To winterize: NOTICE Fail ure to keep the water tank vent fit tings 1. Turn on the water pump and drain the water tank clean will cause ex ces sive pres sure build up by opening a fau cet (the pump will run faster when with in the tank dur ing fill ing.
Page 99
However, to prevent possible damage to components in your boat, Four Winns recom mends having the boat win terized by your Four Winns deal er. Water and Waste Systems - Section J Owner’s Manual Page 96...
Page 100
FIGURE J8: 338 VISTA FRESH WATER SYSTEM (1 OF 8) ® Water and Waste Systems - Section J Owner’s Manual Page 97...
Page 101
FIGURE J9: 338 VISTA FRESH WATER SYSTEM (2 OF 8) ® Water and Waste Systems - Section J Owner’s Manual Page 98...
Page 102
FIGURE J10: 338 VISTA FRESH WATER SYSTEM (3 OF 8) ® Water and Waste Systems - Section J Owner’s Manual Page 99...
Page 103
FIGURE J11: 338 VISTA FRESH WATER SYSTEM (4 OF 8) ® Water and Waste Systems - Section J Owner’s Manual Page 100...
Page 104
FIGURE J12: 338 VISTA FRESH WATER SYSTEM (5 OF 8) ® Water and Waste Systems - Section J Owner’s Manual Page 101...
Page 105
FIGURE J13: 338 VISTA FRESH WATER SYSTEM (6 OF 8) ® Water and Waste Systems - Section J Owner’s Manual Page 102...
Page 106
FIGURE J15: 338 VISTA FRESH WATER SYSTEM (7 OF 8) ® Water and Waste Systems - Section J Owner’s Manual Page 103...
Page 107
FIGURE J16: 338 VISTA FRESH WATER SYSTEM (8 OF 8) ® Water and Waste Systems - Section J Owner’s Manual Page 104...
Page 108
FIGURE J17: 338 VISTA HEAD HARDWARE (1 OF 4) ® Water and Waste Systems - Section J Owner’s Manual Page 105...
Page 109
FIGURE J18: 338 VISTA HEAD HARDWARE (2 OF 4) ® Water and Waste Systems - Section J Owner’s Manual Page 106...
Page 110
FIGURE J19: 338 VISTA HEAD HARDWARE (3 OF 4) ® Water and Waste Systems - Section J Owner’s Manual Page 107...
Page 111
FIGURE J20: 338 VISTA HEAD HARDWARE (4 OF 4) ® Water and Waste Systems - Section J Owner’s Manual Page 108...
Page 112
FIGURE J21: 338 VISTA WASTE SYSTEM (1 OF 6) ® Water and Waste Systems - Section J Owner’s Manual Page 109...
Page 113
FIGURE J22: 338 VISTA WASTE SYSTEM (2 OF 6) ® Water and Waste Systems - Section J Owner’s Manual Page 110...
Page 114
FIGURE J23: 338 VISTA WASTE SYSTEM (3 OF 6) ® Water and Waste Systems - Section J Owner’s Manual Page 111...
Page 115
FIGURE J24: 338 VISTA WASTE SYSTEM (4 OF 6) ® Water and Waste Systems - Section J Owner’s Manual Page 112...
Page 116
FIGURE J25: 338 VISTA WASTE SYSTEM (5 OF 6) ® Water and Waste Systems - Section J Owner’s Manual Page 113...
Page 117
FIGURE J26: 338 VISTA WASTE SYSTEM (6 OF 6) ® Water and Waste Systems - Section J Owner’s Manual Page 114...
Page 118
FIGURE J27: 338 VISTA GRAY WATER SYSTEM OPTION (1 OF 5) ® Water and Waste Systems - Section J Owner’s Manual Page 115...
Page 119
FIGURE J28: 338 VISTA GRAY WATER SYSTEM OPTION (2 OF 5) ® Water and Waste Systems - Section J Owner’s Manual Page 116...
Page 120
FIGURE J29: 338 VISTA GRAY WATER SYSTEM OPTION (3 OF 5) ® Water and Waste Systems - Section J Owner’s Manual Page 117...
Page 121
FIGURE J30: 338 VISTA GRAY WATER SYSTEM OPTION (4 OF 5) ® Water and Waste Systems - Section J Owner’s Manual Page 118...
Page 122
FIGURE J31: 338 VISTA GRAY WATER SYSTEM OPTION (5 OF 5) ® Water and Waste Systems - Section J Owner’s Manual Page 119...
Page 123
FIGURE J32: 338 VISTA OVERBOARD DISCHARGE SYSTEM OPTION (1 OF 2) ® Water and Waste Systems - Section J Owner’s Manual Page 120...
Page 124
FIGURE J33: 338 VISTA OVERBOARD DISCHARGE SYSTEM OPTION (2 OF 2) ® *Not Shown Water and Waste Systems - Section J Owner’s Manual Page 121...
C. Engine Ventilation System Mainte nance VENTILATION Periodic inspection and cleaning of the ventilation ducts is necessary to ensure adequate air circula tion. All Four Winns Vista models are equipped with ® A buildup of leaves, twigs, or other debris can severe- engine compartment ventilation.
C. Sump steering wheel. A sump box is installed in the floor, just forward of the aft cabin. See the 338 Vista locator drawing at the ® B. Bilge Pumps back of this manual. It is equipped with an automatic...
D. Bilge Compartment Drainage Certain bulkhead areas of Four Winns boats are ® sealed in accordance with US Coast Guard regula- tions effective at the date of manufacture. Drainage is provided and water can be removed with the bilge pump.
B. Microwave Oven draw can severely drain a battery through extended use. A microwave oven is standard on the 338 Vista ® models. The circuit breaker on the 120 Volt AC On certain models a magnetic strip is used inside the cabin electrical panel must be activated and the boat seal of the refrigerators.
Section J- 7 on Water System Mainte nance in this manual. A. Stereo System Four Winns offers a AM/FM/CD stereo, an amplifier, tweeters, and a subwoofer as standard equipment Thoroughly flush the water supply lines and...
B. TV and DVD Player ence. See your Four Winns dealer for details and availability. A flat screen TV and DVD player with remote is standard on the 338 Vista models.
Page 131
The air conditioner is located behind the companion- way cabinet, underneath the port AC cabinet. Air Air conditioners utilized in Four Winns Vista models ®...
Page 132
FIGURE L8: 338 VISTA AIR CONDITIONING SYSTEM (1 of 10) ® Interior Equipment - Section L Owner’s Manual Page 129...
Page 133
FIGURE L9: 338 VISTA AIR CONDITIONING SYSTEM (2 of 10) ® Interior Equipment - Section L Owner’s Manual Page 130...
Page 134
FIGURE L10: 338 VISTA AIR CONDITIONING SYSTEM (3 of 10) ® Interior Equipment - Section L Owner’s Manual Page 131...
Page 135
FIGURE L11: 338 VISTA AIR CONDITIONING SYSTEM (4 of 10) ® Interior Equipment - Section L Owner’s Manual Page 132...
Page 136
FIGURE L12: 338 VISTA AIR CONDITIONING SYSTEM (5 of 10) ® Interior Equipment - Section L Owner’s Manual Page 133...
Page 137
FIGURE L13: 338 VISTA AIR CONDITIONING SYSTEM (6 of 10) ® Interior Equipment - Section L Owner’s Manual Page 134...
Page 138
FIGURE L14: 338 VISTA AIR CONDITIONING SYSTEM (7 of 10) ® Interior Equipment - Section L Owner’s Manual Page 135...
Page 139
FIGURE L15: 338 VISTA AIR CONDITIONING SYSTEM (8 of 10) ® Interior Equipment - Section L Owner’s Manual Page 136...
Page 140
FIGURE L16: 338 VISTA AIR CONDITIONING SYSTEM (9 of 10) ® Interior Equipment - Section L Owner’s Manual Page 137...
Page 141
FIGURE L17: 338 VISTA AIR CONDITIONING SYSTEM (10 of 10) ® Interior Equipment - Section L Owner’s Manual Page 138...
Their purpose is for securing the vessel to a dock, pier, mooring, or anchor. Four Winns does not recommend occupying the foredeck during bad weath er or on rough seas. DO NOT use walk-thru instead use deck...
M - 3 COMPAN IONWAY DOOR 3) Wash using a soft, grit free cloth or sponge and mild, nonabrasive soap or detergent. The 338 Vista models have a one-piece sliding ® com panionway door on a track. The companionway 4) Blot dry using a clean, damp chamois.
Plexiglass will scratch easily and must be handled with care. To clean, follow the instructions located in Sections Four Winns does not recommend occupying M-3 and Q-8. DO NOT use paper towels. They will the foredeck during bad weath er or on rough scratch the plexiglass.
M - 6 SWIM PLATFORM Four Winns provides an aft, integrated swim platform Latch on the 338 Vista® models. For better footing, a skid- resistant surface is provided. The ladder is angled with Deck Hatch wide step pads and deep reaching for ease of use and comfort.
338 Vista® model. The me chanical winch portion is Gas-assist lifts hold the locker door open for ease of mounted inside the anchor locker, at the bow. See use.
Page 147
Figure M13: Windlass platform necessary for installation of radar equipment. (Representative View - Models may vary). See Figure M15. Four Winns offers certain optional navigation packages that may include radar equip- Along with the windlass comes an anchor, rope and ment.
Page 148
Figure M17: Radar Arch in Resting/Travel Position To place the radar arch in the resting or travel posi- tion, Four Winns recommends two persons partici- pate. While one person holds the arch in position, the second person removes the port and starboard bolts that hold the arch in place.
Page 149
NOTICE Never operate or trailer your boat with the engine hatch in its open position. Doing so could result in damage to the engine hatch, hardware, and/or loss of cushions. To lower the engine hatch: 1. Press the lower (bottom) portion of the engine hatch switch located on the helm to lower the engine hatch to its closed position.
See Figures N1, N2, N3 and N4. Figure N4: Removable Backrest Storage A cherry dinette table is standard on 338 Vista ® models and is located in the main cabin. The table leg height is easily adjustable.
Page 151
B. V-berth or Forward Cabin NOTICE The private stateroom option can not be Four Winns provides a forward and aft mattress retrofitted to an already existing standard cabin for the v-berth/forward cabin area. An inner-spring layout. This option must be ordered and built mattress for the V-berth is also available.
Figure N12: Mid Cabin Storage & Access Lids Figure N14: Map Pockets To pre vent per son al inju ry, be sure the mid DO NOT sit on the backrest portion of any cab in fill-in supports are se cure be fore use. cockpit seat.
Figure N18: Port Lounge Figure N16: Under Seat Storage (Stern Seat) Additionally, an aft fill-in seat cushion is an available feature. This feature extends the cushion area of the stern seat for such things as sunbathing, napping or overnight sleeping. Refer to Figure N17. Figure N19: Under Seat Storage - Port Lounge Aft Fill-In Seat Cushion D.
To remove the cockpit table simply reverse the • Fast & Easy Glass Cleaner ™ procedure. (to locate the nearest distributor, call 800-537-8990) NOTICE • Tough Duty Cleaner ™ To prevent damage to cockpit table and/or (to locate the nearest distributor, cockpit interior ensure the cockpit table and call 800-537-8990) legs are properly stored.
Armorall . The manufacturer does not ® recommend this prod uct because it re moves Four Winns Vista cruisers use a high quality interior ® the oils present in vinyl that keeps vinyl soft. grade carpeting. Interior carpeting should be cleaned in the same manner as the carpeting in your home.
Page 156
General Stain Removal Guidelines 1. Basic Stains/Grease/Pencil/Dirt: Ivory (mild) Dishwashing Soap and water, ap- ™ plied with a medium-soft brush or Vinyl Finish Vi- nyl Cleaner using a soft clean cloth, then rinse ® with a soft clean cloth. 2. Tough Stains/Adhesive/Teak Oil/Rust: Tough Duty Cleaner™;...
Page 157
Regular vacuuming and occasional sham- manufacturer and is included with this man ual. pooing will help it stay attractive and serviceable. Four Winns offers a variety of optional weather covers D. Stain Removal Testing for protection of the boat and associated equipment.
E. Stain Removal Procedures i t o Regular maintenance such as vacuuming, hosing or washing should be performed. Most stains and i t o mildew are easily removed from carpet made with Olefin fiber using common household cleaners. Refer to Table I. Olefin™ fiber is so resistant to chemi cal attack that Clorox™...
A bimini top and camper ® heavy rain can cause severe damage to the is standard on the 338 Vista® models. Four Winns ® material or top structure. Refer to O-7 - Winter covers are de signed and intended to provide protec- Storage in this manual for more infor mation.
Page 160
O - 4 CAMPER 9) Clean canvas with warm water, mild soap and a soft brush. For the clear Isinglass pieces use a The camper is standard and provides cover/shade soft, clean cloth. Be certain to rinse cloth often for the aft portion of the cockpit area. It is designed to to remove any dirt collected in the cloth that could scratch the clear vinyl.
Page 161
The camper canvas has been designed and are intended to remain installed on the boat in rear support poles storage poles the upright “stored” position. Four Winns does (adjustable) not recommend the camper assembly be removed from the boat unless absolutely side mount necessary.
It is recommended that you retain your canvas locator tags. In the event that replacement 4) Snap the side curtains to the boat. parts are needed, contact your Four Winns dealer. 5) Smooth all velcro down. 6) Locate the aft curtain. See Figure O5.
Many marine dealers offer shrinkwrap enclosures for compounds the possibili ty of this occurring and inhibits outdoor storage. See a Four Winns dealer for informa- natural ventilation. For more information, refer to tion on the availability of winter storage covers or other Section B-2 - Carbon Monoxide in this manual.
Re-rinse. If leakage continues, apply a coat of silicone air drying water repellent, such as Figure O10: Canvas Care & Maintenance Tag Scotchguard™. See your Four Winns dealer for addition al informa tion on weather covers. Moisture, dirt, chemicals from industrial fallout, heat, ultraviolet rays and in some cases, salt water are factors which affect the longevity of acrylic covers.
This en sures a strong, rigid hull, permanently formed during the boating season. into a solid as sembly, free of distor tions. Four Winns utilizes fade-fighting gel coat in the Fiberglass cockpit liners and seat base are construct- exterior finish. It is specially formulat ed to resist fading ed similar to the hull.
Page 166
Make sure prod uct is formulated for gel coat surfaces. something. Also, consult a Four Winns dealer for their recom- mendations. Yellowing is gel coat which has a yellow cast and...
If this does 1. Avoid working in direct sunlight. This dries out the not work, consult your Four Winns dealer for profes- wax or compound, and can stain the surface. sional assistance.
2% MEK Peroxide which can be pur cha sed at a rubbing compound and wax. supplier handling fiber glass rein fo rced products. Contact your Four Winns dealer for assis tance. B. Gouges & Cracks 8. After ample drying time, sand the area using very Stress cracks and crazing are the appearance of fine wet/dry sandpaper.
Your is imperative. Due to the design complexi ties, Four Winns dealer or local ship store will have informa- Four Winns does not recommend trailers or storage tion on barrier coat prod ucts.
Page 170
Figure P1: 338 Vista ® Bottom Paint Line Location Exterior Equipment - Section P Owner’s Manual Page 167...
CHERRY soap and water. After washing, a light coat of wax may be applied as necessary. Al ways read the label Four Winns uses cherry wood trim throughout the 338 before using any product. See Figure Q2. Vista model interior. The wood is prepared with a ®...
Q - 6 SOLID SURFACE MATERIAL Solid surface material is utilized in the galley counter- top, refreshment center countertop and head sink countertop of the 338 Vista models. The solid surface ® gives these countertops a rich look and makes for an extremely strong yet lightweight top.
Q - 7 Acrylic Plastic - (Plexiglass) Q - 8 FLEXITEEK Acrylic plastic is utilized in the companionway doors, An available option is a flexiteek cockpit and/or swim transom doors, deck hatches, portlight windows, platform. Flexiteek is made up of a composite PVC sliding storage doors, electrical panel doors, cabinets based material with a surprising similarity and look to and cabin windows.
General Maintenance R - 1 WINTERIZATION 4. Be sure all the water is completely drained from the fresh water system. Disconnect all hoses, A. Prior to Lifting for Winter Lay-up check valves, etc. and blow all the water from the system using very low air pressure.
D-Con™ in a number of areas around the boat. Be NOTICE sure dishes are placed near the head and the The Four Winns installed flush out kit for Volvo engines, as rodents will destroy uphol stery, water Penta engines is identified by a transom deck ®...
Periodically check hoses for abrasions. NOTICE The Four Winns installed flush out kit for MerCruiser engines may be used with the ® boat in or out of the water and the engine ON.
R - 3 GENERAL MAINTENANCE SCHEDULE i l o e l l e l l l l u t t i e l t t f i c i r e t t e t t t l o o i t t l o o i t o i t...
Page 178
& & & & l i t & Air Conditioner t t i m (If Applicable) i l i e (If Applicable) * Or as Required General Maintenance - Section R Owner’s Manual Page 175...
Page 179
l l u l l u & & Clean Plexiglass Components * Or as Required General Maintenance - Section R Owner’s Manual Page 176...
Pre-Launch and Underway S - 1 LAUNCH AND CRUISE CHECKLIST Get a current weather report. If the weather will not be favorable, postpone your trip. If your boat has been out of the water, check to see that all bilge water has drained out. Install hull drain plugs.
4. Stand away from the fuel tank vent and gas fill during fueling. Splashback may occur and can be an eye irritant and/or a fire hazard. The fuel system components used by Four Winns will ® withstand up to 10% alcohol content in the gasoline.
S - 3 LOADING PASSENGERS AND GEAR A. Preliminary Checks 1. Secure boat to the dock before attempting to start When loading your boat, remember to distribute the engine. The boat should be kept secure until the load evenly. Keep the load low and do not overload. engine is running and warmed up.
Page 183
4. Once engine has warmed up, check water tem- perature gauge to ensure engine temperature stays To prevent personal injury, swim platform must within optimum range. If temperature reading is not be occupied and transom door must be abnormally high, stop engine immediately and closed while engines are running.
intentions to allow them time to make adjustments to and quartering seas. Trimming your boat properly their balance or positions. involves two separate procedures, trimming or tilting the lower unit (stern drives) and setting the trim tabs. Slowly pull back on throttles, glance back and see if a large following wave is approaching the transom.
ed while at dockside. Press both trim tab controls down The power unit should never be trimmed up to a until tabs reach their full up position. point where the propeller cavitates (or slips). A rapid increase in engine rpm’s is evidence of cavitation.
NOTE: It is illegal to use your spotlight as a headlight. • Turn radio ON. Dial in local weather station and Use it only temporarily to check the position of your monitor forecast. If your boat has a VHF radio, boat and the surrounding area.
• If there is any doubt in continuing boat movement, • Watch for swimmers. Swimming areas may not be marked. Steer clear from the area and always anchor. Listen for other fog signals while continuing remain alert. to sound the proper fog horn or bell for a boat at anchor.
D. Man Overboard F. Fire Most fires are caused by electrical problems or Think through and follow these procedures if someone careless fueling practices. A fire on board your boat is in your boat falls overboard. a serious emergency. You must work quickly to •...
• Disconnect electrical system from its power source drive unit in the engine compartment. Some boats before performing maintenance. have a push/pull cable while others will have hydraulic hose connections. With cable connections, check the • Replace breaker or fuse with same amperage attaching hardware and tighten it if necessary.
Page 190
If wind or current is moving toward the dock, move The mooring lines you will use most often are the bow parallel to the dock further out. Let the wind or current line, the stern line, and spring lines as shown on push you in.
Page 191
Glossary ABAFT - Toward the rear of a boat. BILGE - The lowest interior area of a hull, used to collect water that has entered. ABEAM - At right angles to the keel of the boat. BILGE PUMP - A pump intended for removal of spray, ABOARD - On the boat.
Page 192
CAPSTAN - A machine that moves a cylindrical DEAD RECKONING - A plot of courses steered and device on a shaft for the purpose of hauling up an distances traveled through the water. anchor. DECK - A permanent covering over a compart ment, CAST OFF - To let go.
Page 193
EVEN KEEL - To be floating evenly without listing to FREEBOARD - The minimum vertical distance from the surface of the water to the gunwale. either side. FREQUENCY - The number of crests passing a fixed EXHAUST SYSTEM - The means by which the hot engine (or generator) exhaust gases are moved from point at a given time.
Page 194
HARDTOP - A permanent cover over the cabin or ISOTHERMS - Isotherms are lines that are similar to cockpit. Isobars except that Isotherms connect all the points that are of equal temperature. HAWSER - A heavy rope or cable used for moor ing or towing.
Page 195
MODEL DESIGNATOR - Model identifier or model POINT - One of 32 points of the compass that is equal name. to 11-1/4 degrees. MOORING - An arrangement for securing a boat PORT - 1. Looking forward, the left side of a boat, to a mooring buoy or pier.
Page 196
SHACKLE - A “U” shaped connector with a pin STRUT - A propeller shaft support that is below or bolt across the open end. the hull. SHAFT - The long, round member that connects SUMP - A pit or well into which water is drained. the engine or transmission to the propeller.
Page 197
WATER LINE - The line of the water on the hull when the vessel is afloat. WATCH - A 4 hour duty period while at sea. WAVES - Waves are periodic disturbances of the sea’s surface, caused by wind, seaquakes, and the gravitational pull of the moon and the sun.
DO NOT file this plan with the Coast Guard. Name ________________________________________________ Telephone ______________________________ Description of Boat __________________________ Type _________ Color ____________ Trim ____________ Registration Number ___________________________________________________________________________ Length ___________________ Name __________________________ Make ____________________________ Four Winns ® Hull Identification Number ___________________________________________________ Other Information _____________________________________________________________________________ Persons Aboard: Name...
338 Vista Locator Drawing ® Note: Representative Location Only - availability and locations of equipment may vary depending on optional equipment installed. Locations and availability are subject to change without notice. Locator Drawing Owner’s Manual Page 203...