Table Of Contents - Lopi Pioneer Bay Installation And Use Manual

4
Introduction
Introduction ......................................................1
Important Information .........................................1
Safety Precautions
Safety Precautions ............................................2
Specifications
Heating Specifications ........................................5
Dimensions.......................................................5
Electrical Specifications......................................5
Fuel.................................................................5
EPA Compliance ................................................5
Installation
Before you Begin ...............................................6
Packing List......................................................6
Installation Options ............................................6
Planning the Installation ......................................6
Minimum Fireplace Size .......................................6
Clearances .......................................................7
Mantel Requirements ..........................................7
Hearth Requirements ..........................................7
Facing Requirements ..........................................7
Placing the Insert...............................................7
Venting the Pellet Stove ......................................8
Maximum Venting Distance .............................8
Pellet Vent Type............................................8
Installing the Pellet Vent .................................8
Pellet Vent Termination...................................8
Mobile Home Requirements ..................................9
Outside Air .......................................................9
Setting the Restrictor..........................................10
When to Adjust the Restrictor ..........................10
How to Adjust the Restrictor ............................10
Surround Panel & Circuit Board Installation .............11
Installation into a Masonry Fireplace ......................12
Installation into a Factory Built (Metal) Fireplace.......13
Operation
Safety Notice ....................................................14
Location of Controls ...........................................14
Starting the Heater for the First Time ......................14
Curing the Paint ............................................14
Priming the Auger ..........................................14
Loading Pellets..................................................15
The Two Modes of Operation ................................15
Travis Industries

Table of Contents

4 0 2 0 2 0 4
Operation (continued)
Manual Mode.....................................................16
Auto Mode ........................................................17
Adjusting the Fan Speed......................................18
Start-Up Sequence.............................................18
"AUGER ON" Light..............................................18
"FAULT" Light ....................................................19
Power Outages..................................................19
Maintenance
Daily Maintenance (whenever using the heater)........20
Inspect the Burn ...........................................20
Make Sure Pellets are not Piling Up ...................20
Check Firepot for Clinkers ...............................21
Cleaning the Firepot .......................................21
Bi-Weekly Maintenance (or every 10 bags pellets) ....22
Clean the Heat Exchange Tubes.......................22
Vacuum Hopper ............................................22
Clean the Gold Door .......................................22
Opening the Door ..........................................23
Check Ashbox and Ashpan, Dispose.................24
Clean the Glass ............................................24
Sweep Ash Into Ashpan..................................25
Yearly Maintenance (or every two tons) ..................26
Clean the Exhaust Duct ..................................26
Clean the Exhaust Blower ...............................27
Clean the Vent ..............................................27
Check for Air Leaks - Door, Glass and Ashpan ....28
Replacement Parts ........................................29
Normal Operating Sounds
Normal Operating Sounds ....................................30
Safety Label
Safety Label .....................................................31
Warranty
Warranty ..........................................................32
Optional Equipment
Center Flue Adapter............................................33
Gold Grill ..........................................................33
Thermostat .......................................................34
Remote Thermostat ............................................35
Optional Log .....................................................35
Optional Gold Door .............................................35
Index
Index...............................................................36
9 3 5 0 8 0 5 1