Service Air Filter; Check / Add / Change Engine Oil - Ferris IS2000Z Diesel Operator's Manual

Regular Maintenance

SERVICE AIR FILTER

Removal of air filter elements:
1. Unfasten the two retaining clamps and remove the
cover (A, Figure 22) from the air cleaner housing
(D).
2. Remove the primary element (B) and the
secondary element (C) from the air cleaner
housing by pulling them out.
Cleaning and changing of air filter elements:
1. Replace the element(s) if damaged, excessively
dirty or oily, or every 200 hrs.
2. To Clean Elements: Blow air through the
elements from the inside using 42-71 psi (2,89-
4,90 bar) compressed air to remove dust and
debris. Use the lowest possible air pressure to
clean the element without damaging it.
3. Clean all components of the air cleaner housing,
cover, and passages. Cover the intake port with a
cloth while cleaning to prevent foreign objects
from falling into intake manifold.
Reassembly of air filter:
1. Install the elements into the air cleaner housing,
and reassemble the air cleaner housing and cover.
Fasten the retaining clamps.
CHECK / ADD / CHANGE ENGINE
OIL AND FILTER
Refer to rear cover for oil capacity.
To check the engine oil level:
1. Park machine on a flat, level surface.
2. Tip the seat forward and loosen the thumb bolts
(A, Figure 23) that secure the engine access
panel (B). Remove the engine access panel.
3. Remove dipstick (B, Figure 24) and wipe with
clean cloth.
4. Fully reinsert dipstick. The oil level should be
between the upper and the lower lines on the
dipstick.
To add the engine oil (Refer to Figure 25 for oil
specifications and rear cover of this manual for
oil capacity):
1. Park machine on a flat, level surface.
2. Remove dipstick, add oil at filler tube (B, Figure
24).
3. Wait three minutes and check oil level.
4. Add more oil if necessary.
5. Replace dipstick and hand tighten. Over-
tightening may damage the dipstick.
30
Figure 22. Air Cleaner Assembly
A. Cover
B. Primary Element
C. Secondary Element
D. Housing
A
Figure 23. Remove Engine Access Panel
A. Thumb Bolt
B. Engine Access Panel
Figure 24. Oil Dipstick and Filter
A. Drain Plug
B. Dipstick and Filler Tube
C. Oil Filter
A
B
C
D
B
C
B
A
www.ferrisindustries.com