Pre-Season Preparation; Pre-Season Preparation Chart - BOMBARDIER Mirage Operator's Manual

PRE-SEASON PREPARATION
To simplify the pre-season preparation
we have drawn up a small chart. The
chart indicates servicing points to be
performed by you and your servicing
dealer. If these services are performed
as your vehicle will give
you many hours of fun and low cost
use.
IMPORTANT: Observe all Warnings
and Cautions mentioned throughout
this manual which are pertinent to the
item being checked. When component
conditions seem less than satisfactory,
replace with genuine Bombardier parts
or suitable equivalents.
PRE-SEASON PREPARATION CHART
TO BE PERFORMED BY DEALER
•
TO BE PERFORMED BY OWNER 0
Change spark plugs* 0
Check chaincase oil level 0
On vehicle equipped with fuel filter cartridge, replace cartridge
Check track tension and alignment
Lubricate suspension
0
Inspect drive belt and install
Check throttle cable for damage and free operation
Check steering alignment and ski runner condition 0
Inspect seals for possible cuts or leaks
0
Check electrical wiring (broken wire, damaged insulation)
Inspect condition of starting rope
0
Check tightness of all bolts, nuts and linkage
0
Refill injection oil tank
Refill gas tank
0
Inspect brake condition and operation
•
Set engine timing
•
Check pulleys, verify components and clean. Lubricate.
•
Adjust carburetorts)
•
Adjust oil injection pump
•
o
•
*NOTE: Before installing new spark plugs, it is suggested to burn the ex-
cess storage oil by starting the engine, using the old spark plugs .
CAUTION: Only perform this procedure in a well ventilated area.
35