Maintenance; Maintenance Safety Precautions; Suggested Maintenance Procedures - Invacare Tracer SX5 Owner's Operator And Maintenance Manual

Maintenance

Maintenance Safety Precautions

After any adjustments, repair or service and before use, make sure all attaching
hardware is tightened securely. Otherwise injury or damage may result.
DO NOT overtighten hardware attaching to the frame. This could cause damage to
the frame tubing.

Suggested Maintenance Procedures

1. Before using your wheelchair, make sure all nuts and bolts are tight. Check all parts
for damage or wear and replace. Check all parts for proper adjustment.
As with any vehicle, the rear wheels, casters and tires should be checked periodi-
cally for cracks and wear, and should be replaced if damaged.
2. The rear wheels, casters and tires should be checked periodically for cracks and wear,
and should be replaced by a qualified technician if damaged.
NOTE: Tire wear is excessive if:
• Pneumatic Tires - there is missing tread or the tires are bald.
• Urethane Tires - there are cuts, surface defects or the tires are loose on the rims.
• Rubber Tires - 30% or more of the tire has worn away.
NOTE: Invacare recommends that tires and casters be replaced every five years.
3. Periodically adjust wheel locks in correlation to tire wear. Refer to Adjusting
Patient-Operated Wheel Locks on page 48.
4. Periodically check handrims to ensure they are secured to the rear wheels. If loose,
have them tightened by a qualified technician.
5. Periodically check caster wheel bearings to make sure they are clean and free from
moisture. Use a Teflon™ lubricant if necessary.
When cleaning rear cane or hand grip areas use only a clean towel lightly dampened
with cool water. Verify that grips are dry prior to use. Use of soap or ammonia
based cleaning solutions will result in the hand grips sliding off the cane assembly.
Failure to observe this warning may result in injury to the user or bystanders.
6. Hand grips should be checked monthly for wear/looseness/deterioration. Clean if
desired. Replace if looseness or deterioration is found.
7. Check upholstery for sagging, rips or tears.
Part No. 1110550
SECTION 3—SAFETY INSPECTION/TROUBLESHOOTING
WARNING
CAUTION
CAUTION
WARNING
29 ®
Tracer SX5