SERVICE MANUAL CODE : 00Z XEA102USME ELECTRONIC CASH REGISTER XE-A102 MODEL SRV KEY : Not necessary PRINTER : M-31 (U and V version) CONTENTS CHAPTER 1. SPECIFICATIONS ......1 CHAPTER 2.
If the soldering iron tip is discolored black during soldering work, clean and file the tip with steel wool or a fine filer. CAUTIONS THERE IS A RISK OF EXPLOSION IF THE BATTERY IS REPLACED BY AN INCORRECT TYPE. PROPERLY DISPOSE OF USED BATTERIES ACCORDING TO THE INSTRUCTIONS. XE-A102 LEAD-FREE SOLDER – 2 –...
Page 5
3) Remove the OLD dry batteries (3 pieces). 4) The nobattery symbol "L" light up. 5) Insert the NEW dry batteries (3 pieces). 6) Confirm the low battery symbol "L" and nobattery symbol "L" is off. XE-A102 SPECIFICATIONS – 3 –...
Means connecting the AC power to the machine. (Specif- ically, plugging in the machine.) Note 3) In case a power failure occurs when the machine has no battery installed, the master reset operation is automati- cally performed after the power has been restored. XE-A102 OPTIONS – 4 –...
MODE SW, KEY MATRIX is follows. • CPU : uPD780023A (ROM 24KB, RAM 1024B) * Note: Although the XE-A102 has 30 keys, the keyboard circuit is • KEY BOARD : 30key including PF key actually 32 keys (+) the PF key.
Page 8
• Values obtained by AD conversion and averaging 3 No voltage Register value: 138 ( 2.7V) or less 2.7V - 3.0V) 3 Low voltage 139 - 154 ( more than 154 3 OK 7) DESTINATION DETECTION PORT U and V version XE-A102 HARDWARE DESCRIPTION – 6 –...
KEY OPERATION Completion print Error print - - - TEST PROCEDURE The drawer opens with the above key operation. Check that the drawer is open. Press any key to terminate the test. Completion print XE-A102 TEST FUNCTION – 8 –...
0155 or greater : Normal 0154 or smaller : Low battery display 0138 or smaller : No battery display and MRS is done when power on. To terminate the test, press any key. Completion print XE-A102 TEST FUNCTION – 9 –...
Therefore, the printer component parts are not supplied and no service document is issued. For troubleshooting of the printer, refer to the table below: * Printer life: 300 thousand lines (XE-A102: M-31) Ink roll life: 1 million characters Phenomena...
3. DISPLAY LAYOUT A side B side XE-A102 CIRCUIT DIAGRAM AND PWB LAYOUT – 13 –...
Page 16
COPYRIGHT 2005 BY SHARP CORPORATION All rights reserved. Printed in Japan. No part of this publication may be reproduced, stored in a retrieval system, or transmitted. In any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, without prior written permission of the publisher.