Windsor Chariot 2 iVac 24 ATV CV2410125760 Operating Instructions Manual page 40

Maintenance
Troubleshooting
PROBLEM
Vacuum motor does not run, or
runs slowly
Vacuum and brush do not turn on Circuit breaker tripped
Poor vacuum performance
Brush motors do not run, or runs
slowly
Deck won't go down
Side broom not running
Brush door won't close
40
CAUSE
Faulty vacuum circuit or switch
Worn vacuum motor brushes
Vacuum circuit breaker tripped
Full bag or clog in system (bag full light
on)
Debris caught in system
Low battery charge
Lid is not closed correctly
Faulty gaskets
Accessory hose is not sealed shut.
Bag or debris tray are full
Vacuum diverter valve not actuating
Circuit breaker tripped
Low battery charge
Faulty brush circuit or motor
Bag full light on
Worn brush motor brushes
Actuator circuit breaker tripped
Fuse is blown
Cylindrical brushes not installed
correctly.
86349370 Chariot iVac 24
SOLUTION
Check wires & connections
Replace brushes, check commutator
Reset circuit breaker
Reset
Replace bag, empty debris tray, check
for and remove clogs
Remove debris
Charge batteries
Close and latch lid correctly
inspect and replace gaskets
assure hose is tight in hose holder
Empty tray, replace bag
Check for debris
Check electrical connections
Check timer circuit board
Reset circuit beaker
Charge battery
Check wires, connections and motor
Replace bag, empty debris tray or
remove clog.
Replace brushes, check commutator
Reset actuator circuit breaker
Clear foreign objects from broom that
inhibit free motion, replace fuse.
Align brushes to drive shaft assem-
blies, close door.