Thank you for purchasing a Kärcher North America product. Warranty registration is quick and easy. Your registration will allow us to serve you better over the lifetime of the product. To register your product go to: http://warranty.karcherna.com/ For customer assistance: 1-800-444-7654 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
NOTE: The manual part number is located on the Address: lower right corner of the front cover. Phone Number: Sales Representative: The model and serial number of your machine is located on the back of the machine. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
Do not use on surfaces having a gradient of over 10% (6 degrees). Do not use without dust bag/or filter in place. READ AND SAVE THESE INSTRUCTIONS 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
Page 7
N'employez pas sur des surfaces ayant un gradient de plus de 10% (6 degrés). Ne pas utiliser l’appareil si le filtre ou le sac à poussière n’est pas en place. CONSERVER CES INSTRUCTIONS 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
Always wear eye protection and protective clothing when working on or near batteries. Avoid skin contact with the acid contained in the batteries. Never allow metal to lie across battery tops. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
Page 9
Éviter tout contact de la peau avec l'acide contenu dans les batteries. Ne jamais placer d'objets métalliques sur le dessus des batteries. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
Page 11
Des enfants devraient être dirigés pour s'assurer qu'ils ne jouent pas avec l'appareil. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
The debris tray captures the dirt off the floor as the machine moves forward. The vacuum motor provides suction to draw the fine dirt into the vacuum bag, and the debris tray stores large debris. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
Controls the direction of travel of the vehicle. The lit arrow on the switch indicates direction of travel. To travel forward, press the top of the switch. To travel in reverse, press the bottom of the switch. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
Page 16
The horn is activated by pressing the horn button. 6. Steering Wheel The steering wheel turns the front wheel causing the machine to change direction. 7. Function Mode Switch 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
Page 17
The vacuum will draw the dirt and debris into the debris tray and the vacuum bag. The brushes, side broom, and vacuum will operate at reduced power. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
Page 18
If vacuum operating conditions are good, light is green. If vacuum operating conditions are poor, light flashes red for 1 minute, then turns solid red and vacuum opera- tions are stopped. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
“ON” position. 3. Press the Drive Reset Directional Control Switch to set the intended direction for travel. 4. Press lightly on the throttle pedal with right foot. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
4. Rotate the Function Control Switch to one of the four vacuum settings. Vacuum motor will turn on within a few seconds. 5. Depress the throttle pedal to drive machine and turn on brushes and side broom. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
2. Secure with debris tray spring clip. SPRING CLIP 5. Remove vacuum bag from vacuum box and dispose of properly. 6. Clean vacuum box and remove any debris. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
Les batteries émettent du gaz hydrogène. Une explosion ou un incendie peut en résulter. Maintenez les étincelles et les flammes nues à l’écart. Gardez les carters ouverts lors du charge- ment. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
80°F (27°C): Add (+) to the specific gravity reading 0.004 (4 points), for each 10°F (6°C) above 80° (27°C). Subtract (-) from the specific reading 0.004 (4 points), for each 10°F (6°C) below 80°F (27°C). 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
AC wall outlet, then discon- 10. (Wet Cell Only) Slide in and latch the battery try. nect the charger from the batteries. 11. Turn on the breaker, and close the rear cover. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
Fixez le dispositif de levage de batterie approprié et levez les batteries de la machine. Les batteries constituent un danger potentiel pour l'environne- ment. Consultez le fournisseur de votre batterie pour connaître les méthodes d'élimination sûres. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
3. Change switches to correct battery type. DIP DIP DIP DIP DIP DIP DIP OFF ON ON OFF ON ON OFF LEAD ACID ON OFF OFF OFF ON ON OFF DISCOVER AGM 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
If installed incorrectly this may cause excessive noise the ends are vertical. 3. Lower the brush door and ensure both spring clips engage. BELT TENSIONER BELT SPRING CLIP COVER SPRING CLIP VERTICAL INDICATOR LINE 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
5. Remove (6) motor mount bracket face screws. 6. Remove mounting brackets from motor. 7. Remove coupler hub (1 set screw) from old motor for reuse. 8. Reverse process to reassemble with new motor. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
NOTE: Failure to ensure all brushes are released will result in motor failure. 8. Reinstall end caps and realign to scribe marks on motor barrel. Reinstall the two bolts, maintaining alignment between motor barrel and cap. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
Interrupts the flow of power from batteries in the event of an electrical overload. When the circuit breaker is tripped, it can be reset by pressing the toggle switch. If the circuit breaker continues to trip, the cause of the electrical overload must be corrected. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
1. Pull lever away from brake housing. 2. Insert material to hold brake lever away from brake housing. Do not operate machine with brake disengaged. N'actionnez pas la machine avec le frein désen- gagé. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
Check for and remove debris Low battery charge Charge battery Worn brush motor brushes Replace brushes, check commutator Check wires, connections and motor, Faulty brush circuit or motor replace or tighten as necessary. 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
Page 40
Debris tray needs to be emptied Excessive amounts of large or heavy Remove debris tray insert too frequently material on floor. New carpet Remove debris tray insert 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...
HIGH BATTERY VOLTAGE HAVE TECHNICIAN CHECK BATTERY CONDITION. MACHINES WITH KÄRCHER FLEET SUPPORT, CALL FOR SERVICE. MACHINE IS NOT REPORTING TO KÄRCHER FLEET MACHINES WITHOUT KÄRCHER FLEET SUPPORT, NO ACTION REQUIRED 8.641-374.0 Operators Manual - Chariot 3 - CV 86/1 RS Bp...