Troubleshooting Guide; Blown Fuse Or Circuit Breaker; Gate Does Not Open. Agitator Does Not Turn; Gate Does Not Open Or Is Sluggish. Agitator Turns - Cornelius Remcor TJ45-A Operator's Manual

Should your unit fail to operate properly, check that there is power to the unit and that the hopper contains ice. If
the unit still does not dispense, check the following chart under the appropriate symptoms to aid in locating the
defect.

BLOWN FUSE OR CIRCUIT BREAKER.

GATE DOES NOT OPEN. AGITATOR DOES NOT
TURN.
GATE DOES NOT OPEN OR IS SLUGGISH.
AGITATOR TURNS.

GATE OPENS. AGITATOR DOES NOT TURN.

ICE DISPENSES CONTINUOUSLY.

SLUSHY ICE. WATER IN HOPPER.

ICE SOLIDIFIED IN HOPPER, OR ICE AT REAR
CORNER ONLY.
NO ICE IN HOPPER
ICE PACKED IN HOPPER.

BEVERAGES DO NOT DISPENSE.

BEVERAGES TOO SWEET.

BEVERAGES NOT SWEET ENOUGH.

BEVERAGES NOT COLD (UNITS WITH BUILT-IN
COLD PLATE).
NOTE: contact your local syrup or beverage equipment distributor for additional information and trou-
bleshooting of beverage system.

TROUBLESHOOTING GUIDE

Trouble Probable Cause
A. Short circuit in wiring.
B. Defective gate solenoid.
C. Defective agitator motor.
A. No power.
B. Bent depressor plate (does not actuate
switch).
C. Defective dispensing switch.
A. Defective gate solenoid.
B. Weak gate spring.
C. Excessive pressure against gate slide.
A. Ice solidified in hopper.
B. Defective agitator motor.
C. Defective capacitor (TJ90 only).
A. Stuck or bent depressor plate (does not
release switch)
B. Defective dispensing switch.
C. Improper switch installation.
A. Blocked drain.
B. Unit no level.
A. Defective or improperly adjusted thermostat.
B. Defective agitation timer.
A. Icemaker malfunction.
A. Defective or improperly adjusted control (not
shutting off).
A. No 24 volt power to faucets.
B. No CO pressure.
2
A. Carbonator not working.
B. No CO pressure in carbonator.
2
C. Faucet brix requires adjusting.
A. Empty syrup tank.
B. Faucet brix requires adjusting.
A. Unit standing with no ice use - no ice in cold
plate cabinet.
7
90632