Table Of Contents; Specifications - Aprilaire E080 Installation & Owner's Manual

SPECIFICATIONS                                                     2
SAFETY INSTRUCTIONS                                              3
WHOLE HOME DEHUMIDIFICATION                                  3
OPERATING THE DEHUMIDIFIER                                     4
Energy Savings Tips                                              4
MAINTENANCE                                                       5
Cleaning the Filter                                               5
Cleaning the Drain                                               5
PREPARING THE UNIT FOR INSTALLATION                           6
Repositioning the User Interface for the Application           7
Installing the Duct Collars                                       7
INSTALLING THE DEHUMIDIFIER                                     8
Dehumidifier Location                                           8
Leveling and Raising the Dehumidifier                          8
Installing a Condensate Pan Under the Dehumidifier         8
Installing the Drain                                               9
INSTALLING DUCTWORK                                            9
Ducting the Dehumidifier Inlet and Outlet
to the HVAC System                                             10
Ducting the Dehumidifier Outlet to the HVAC System
with Dedicated Dehumidifier Inlet Register                     11
WIRING                                                             12
Wiring to the HVAC System                                     12
Wiring to External or Remote Controls                         13
Wiring to a Float Switch                                         13
Unit Weight
Capacity
80°F, 60% RH Conditions
Power
115 VAC, Single Phase, 60 Hz
Dehumidifier Inlet Air Conditions
Filter
Airflow
NOTE: Rated capacity and current draw measured at 80°F/60% RH inlet conditions at 00 external static pressure
2

TABLE OF CONTENTS

VENTILATION                                                        14
ZONING THE DEHUMIDIFIER                                        15
Required Components                                         15
INSTALLER SETUP                                                   16
Setting Up Remote Control -
Crawl Space/Sealed Attic                                      17
Setting up Ventilation                                           17
Setting up Zoning                                               17
Setting up External Control                                     17
Enabling DEH w/AC                                              17
Applying an RH Offset                                          17
INSTALLER TEST MODE                                              18
Dehumidification Only                                          18
Zoning and/or Ventilation                                      18
STARTING UP THE UNIT AND SEQUENCE OF OPERATION          19
Using the Dehumidifier Control Only                           19
Using a Model 76 as a Remote Control                        19
Using an External Control                                       19
Two-Zone Operation                                            19
TROUBLESHOOTING                                               20
SERVICE PARTS                                                     23
LIMITED WARRANTY                                                24
Warranty Registration                                          24

SPECIFICATIONS

Model E080 and E080H
63 lbs
80 pints per day @ 185 CFM
51 A operating current
Dehumidification: 50°F-104°F, 40°F dew point minimum
Ventilation: 40°F-140°F, 0% RH-99% RH (non-condensing)
External Static
Pressure ("w.c.) Airflow (CFM)
00
02
04
Installation not advised
Model E100, E100C, and E100H
100 pints per day @ 280 CFM
69 A operating current
MERV 8, washable
External Static
Pressure ("w.c.)
185 00
135 02
85 04
06
64 lbs
Airflow (CFM)
280
245
210
175