Table Of Contents - Heat & Glo TRUE-36G-IFT Installation Manual

Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
Note: The term "recommend" or "recommended" does not indicate a requirement. It is a best practice suggested by
Hearth & Home Technologies
Installation Standard Work Checklist . . . . . . . . . . . . . . . . . . . . 3
1 Product Speci昀椀c and Important Safety Information
A. Appliance Certi昀椀cation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
B. Glass Speci昀椀cations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
C. BTU Speci昀椀cations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 4
E. Non-Combustible Materials Speci昀椀cation. . . . . . . . . . . . . . 4
F. Combustible Materials Speci昀椀cation . . . . . . . . . . . . . . . . . 4
G. Electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
H. California . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
I. Requirements for the Commonwealth of Massachusetts . . 5
2 Getting Started
A. Design and Installation Considerations . . . . . . . . . . . . . . . 6
B. Good Faith Wall Surface . . . . . . . . . . . . . . . . . . . . . . . . . . 6
C. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . . 6
D. Inspect Appliance and Components . . . . . . . . . . . . . . . . . . 7
3 Framing and Clearances
A. Appliance/Decorative Front Dimension Diagrams . . . . . . . 8
B. Clearances to Combustibles . . . . . . . . . . . . . . . . . . . . . . 13
C. Constructing the Appliance Chase . . . . . . . . . . . . . . . . . . 17
D. Hearth Extension . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
E. Floor Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
4 Termination Location and Vent Information
A. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 19
B. Chimney Diagram. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
C. Approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
D. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
E. Measuring Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
F. Vent Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
G. Power Vent Information . . . . . . . . . . . . . . . . . . . . . . . . . . 30
5 Vent Clearances and Framing
A. Pipe Clearances to Combustibles . . . . . . . . . . . . . . . . . . 31
B. Wall Penetration Framing/Firestops . . . . . . . . . . . . . . . . . 31
C. Ceiling Firestop/Floor Penetration Framing . . . . . . . . . . . 32
D. Install Attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 32
E. Prepare for Heat Management . . . . . . . . . . . . . . . . . . . . . 33
6 Appliance Preparation
A. Vent Collar Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . 34
B. Securing and Leveling the Appliance . . . . . . . . . . . . . . . . 35
C. Installing Non-Combustible Facing Material . . . . . . . . . . 36
2 Heat & Glo • TRUE-36-IFT, TRUE-42-IFT, TRUE-50-IFT Installation Manual • 2461-980 Rev. Y • 6/23
® .

Table of Contents

7 Venting and Chimneys
A. Assemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 37
B. Secure the Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 38
C. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 38
D. Vertical Termination Requirements . . . . . . . . . . . . . . . . . . 39
E. Horizontal Termination Requirements . . . . . . . . . . . . . . . 40
8 Electrical Information
A. General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
B. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
9 Gas Information
A. Fuel Conversion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
B. Gas Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
C. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . 44
E. Air Shutter Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
10 Finishing
A. Facing Material . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
B. Finishing Templates . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
C. Mantel and Wall Projections . . . . . . . . . . . . . . . . . . . . . . . 49
D. Decorative Front Dimensions for Finishing . . . . . . . . . . . 51
11 Appliance Setup
A. Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
B. Remove the Shipping Materials . . . . . . . . . . . . . . . . . . . . 54
C. Clean the Appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
D. Install Glass Refractory
(TRUE-36G-IFT/TRUE-42G-IFT Only) . . . . . . . . . . . . . . . 55
E. Install Teco-Sil and Mystic Embers . . . . . . . . . . . . . . . . . 58
F. Glowing Ember Placement . . . . . . . . . . . . . . . . . . . . . . . . 59
G. LED's . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
H. Install the Log Assembly . . . . . . . . . . . . . . . . . . . . . . . . . 60
I. IntelliFire Touch Control System Setup . . . . . . . . . . . . . 68
®
J. Install Decorative Front . . . . . . . . . . . . . . . . . . . . . . . . . . 68
12 Reference Materials
A. Vent Components Diagrams . . . . . . . . . . . . . . . . . . . . . . 69
B. Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
 = Contains updated information.
