JLG T350 Troubleshooting Manual page 9

INTRODUCTION
9
Accessory Fault .............................................................................................................................................................................2-41
CANBUS Failure - Accessory Module Communications Lost .....................................................................................................2-42
CANBUS Failure - Drive Module .................................................................................................................................................2-43
CANBUS Failure - Platform Module ............................................................................................................................................2-44
CANBUS Failure - Power Module ................................................................................................................................................2-45
Chassis Tilt Sensor Gain Not Calibrated .......................................................................................................................................2-45
Chassis Tilt Sensor Gain Out Of Range ........................................................................................................................................2-45
Chassis Tilt Sensor Not Calibrated ................................................................................................................................................2-46
Choke Hold Solenoid Open Circuit ...............................................................................................................................................2-47
Choke Hold Solenoid Short To Battery .........................................................................................................................................2-47
Choke Hold Solenoid Short To Ground ........................................................................................................................................2-48
Choke Pull Relay Open Circuit .....................................................................................................................................................2-48
Choke Pull Relay Short To Battery ...............................................................................................................................................2-49
Choke Pull Relay Short To Ground ...............................................................................................................................................2-49
Drive Enable Solenoid Short To Battery .......................................................................................................................................2-51
Drive Enable Solenoid Short To Ground Or Open Circuit ...........................................................................................................2-52
Drive Left Forward Solenoid Open Circuit ...................................................................................................................................2-52
Drive Left Forward Solenoid Short To Battery .............................................................................................................................2-53
Drive Left Forward Solenoid Short To Ground ............................................................................................................................2-53
Drive Left Reverse Solenoid Open Circuit ...................................................................................................................................2-54
Drive Left Reverse Solenoid Short To Battery .............................................................................................................................2-54
Drive Left Reverse Solenoid Short To Ground .............................................................................................................................2-55
Drive Right Forward Solenoid Open Circuit .................................................................................................................................2-56
Drive Right Forward Solenoid Short To Battery ..........................................................................................................................2-56
Drive Right Forward Solenoid Short To Ground ..........................................................................................................................2-57
Drive Right Reverse Solenoid Open Circuit .................................................................................................................................2-57
Drive Right Reverse Solenoid Short To Battery ...........................................................................................................................2-58
Drive Right Reverse Solenoid Short To Ground ...........................................................................................................................2-58
Dump Solenoid Open Circuit ........................................................................................................................................................2-59
Dump Solenoid Short To Battery ..................................................................................................................................................2-59
Dump Solenoid Short To Ground ..................................................................................................................................................2-60
EEPROM Failure - Check All Settings .........................................................................................................................................2-60
Extend O/R Solenoid Open Circuit ...............................................................................................................................................2-61
Extend O/R Solenoid Short To Battery .........................................................................................................................................2-61
Extend O/R Solenoid Short To Ground .........................................................................................................................................2-62
Front-Left O/R Solenoid Open Circuit ..........................................................................................................................................2-62
Front-Left O/R Solenoid Short To Battery ....................................................................................................................................2-63
Front-Left O/R Solenoid Short To Ground ...................................................................................................................................2-63
Front-Right O/R Solenoid Open Circuit ........................................................................................................................................2-64
Front-Right O/R Solenoid Short To Battery .................................................................................................................................2-64
Front-Right O/R Solenoid Short To Ground .................................................................................................................................2-65
Function Problem - Jib Up And Down Both Selected ..................................................................................................................2-69
Function Problem - Level Up And Down Both Selected ..............................................................................................................2-70
Function Problem - Lift Up And Down Both Selected .................................................................................................................2-72
Function Problem - Outrigger Set And Stow Both Selected .........................................................................................................2-73
Function Problem - Rotary Selector Switch ..................................................................................................................................2-74
Function Problem - Swing Left And Right Both Selected ............................................................................................................2-75
Function Problem - Telescope In And Out Both Selected ............................................................................................................2-77
Functions Locked Out - Constant Data Version Improper ............................................................................................................2-78
Functions Locked Out - Platform Module Software Version Improper ........................................................................................2-78
Functions Locked Out - Power Module Software Version Improper ...........................................................................................2-79
Ground Alarm Short To Battery ....................................................................................................................................................2-79
Ground Alarm Short To Ground ...................................................................................................................................................2-79
Ground Module Failure Ref Voltage Out Of Range .....................................................................................................................2-80
Ground Module Failure Vlow Fet Failure .....................................................................................................................................2-80
Hourmeter Short To Battery ..........................................................................................................................................................2-80
Jib Down Solenoid Open Circuit ...................................................................................................................................................2-80
3121203 T350 T500J A-9