Water Quality Requirements - Cleveland Floor Type Gas Convection Steamer 24CGA10.2 Parts Manual

A
GAS
1 3
1 ⁄ ˝ IPS line size, ⁄ ˝ (13mm) connection
4 4
NATURAL PROPANE
3 3
Piping ⁄ ˝ N.P.T. Piping ⁄ ˝ N.P.T.
4 4
Supply pressure Supply pressure
4.50˝ W.C. Min. 11.00˝ W.C. Min.
14.00˝ W.C. Max. 14.00˝ W.C. Max.
Manufacturer must be notified if unit will
be used above 2,000 feet
NOTES:
Cleveland Range reserves right of design improvement or modification, as warranted.
Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes.
Cleveland Range equipment is built to comply with applicable standards for manufacturers. Included among those approval agencies are UL/NSF#4 and CSA (AGA, CGA).
B
ELECTRIC
120V-1Phase, 60 Hz.
BTU 2 Blowers & Controls
72,000 each 150 watts each
Generator,
144,000 total
DE
COLD WATER CLEARANCE
C
35 psi minimum Right - 3", Left - 3", RIGHT = 3˝ operating,
Rear -3"
60 psi maximum 12˝ if adjoining wall or
(12" on control side if adjoining
LEFT = 3˝
wall or equipment is over 30"
high for service access)
One (E) 1/4" dia. REAR = 3˝
NPT for Generator Allow 6˝ space min.
Contact factory
for variances to from rear and sides
clearances.
One (D) 1/4" dia when located near
NPT for Condenser combustible walls
Each Compartment has
capacity for:
• Five, 12˝ x 20˝ x 2 1 ⁄ ˝ deep
2
Cafeteria Pans.
WATER QUALITY
REQUIREMENTS
The quality of water varies
greatly from region to region.
Steam equipment generators
must be drained daily and
chemically descaled periodically
to ensure proper operation. To
minimize service problems
caused by the accumulation of
minerals and chemicals in water
review the following quality
guidelines with a local water
treatment specialist. Inlet water
that is beyond these specified
guidelines should be treated to
achieve these acceptable limits.
Total Dissolved Solids less than
60 ppm, Alkalinity less than 20
ppm, Silica less than 13 ppm,
pH factor greater than 7.5,
Chlorine less than 30 ppm.
C
D
DRAINAGE
1
1 ⁄ ˝ dia.
2
Do not connect other
units to this drain
Drain must be vented
Do not use PVC pipe
(NOT TO SCALE)
IV
SECT. PAGE
Litho in U.S.A.
14
0402