Battery Maintenance - Polaris RANGER 2x4 Manual

5. Start engine and inspect for leaks.
CARBURETOR DRAINING
The carburetor float bowl should be drained
periodically to remove moisture or sediment from the
bowl, or before extended periods of storage.
NOTE: The bowl drain screw is located on the bottom
left side of the float bowl.
1. Turn fuel valve to the off position.
2. Place a clean container beneath the bowl drain
spigot or bowl drain hose.
3. Turn drain screw out two turns and allow fuel in
the float bowl and fuel line to drain completely.
4. Inspect the drained fuel for water or sediment.
5. Tighten drain screw.
6. Turn fuel valve to "ON".
7. Start machine and check for leaks.
NOTE: All tubes attached to the carburetor must be
check for pinching or blockage, as this will effect
engine performance.
Drain tube
attached
here
Drain Screw
Ill. 1
GENERAL INFORMATION

BATTERY MAINTENANCE

WARNING
Battery electrolyte is poisonous. It contains
sulfuric acid. Serious burns can result from
contact with skin, eyes or clothing. Anti-
dote:
External: Flush with water.
Internal: Drink large quantities of water or
milk. Follow with milk of magnesia, beaten
egg, or vegetable oil. Call physician im-
mediately.
Eyes: Flush with water for 15 minutes and
get prompt medical attention.
Batteries produce explosive gases. Keep
sparks, flame, cigarettes, etc. away. Venti-
late when charging or using in an enclosed
space. Always shield eyes when working
near batteries. KEEP OUT OF REACH OF
CHILDREN.
NOTE: New Batteries: Batteries must be fully
charged before use or battery life will be reduced
by 10-30% of full potential. Charge battery for 3- -5
hours at a current equivalent of 1/10 of the
battery's rated amp/hour capacity. Do not use the
alternator to charge a new battery. (Refer to Battery
Activation and Maintenance video PN 9917987)
The battery is located under the left rear fender.
Inspect the battery fluid level. When the electrolyte
nears the lower level, remove the battery and add
distilled water only to the upper level line. (Ill.1)
Maintain
between upper
and lower level
marks
Ill. 1
2.17