CAME OPP Series Installation, Operation And Maintenance Manual page 20

GENERAL PRECAUTIONS FOR INSTALLERS
Follow all of these instructions. Improper installation can cause serious bodily
Before continuing, also read the general precautions for users.
T
HIS PRODUCT MUST ONLY BE USED FOR ITS SPECIFICALLY INTENDED PURPOSE
C S.P.A.
AME IS NOT LIABLE FOR ANY DAMAGE CAUSED BY IMPROPER
'
MANUAL S PRODUCT IS DEFINED BY MACHINERY DIRECTIVE
Q -
UASI COMPLETED MACHINERY IS
, ,
BUT WHICH ALONE CANNOT ENSURE A CLEARLY DEFINED APPLICATION
DESTINED TO BE INCORPORATED OR ASSEMBLED TO OTHER MACHINERY OR OTHER PARTLY
OR APPARATUSES TO BUILD MACHINERY THAT IS REGULATED BY
MUST BE COMPLIANT WITH
G
IVEN THESE CONSIDERATIONS
,
EXPERT QUALIFIED STAFF
WHICH WOULD RESULT IN WARRANTY LOSS
MANUALS OF ALL THE OTHER DEVICES USED FOR YOUR AUTOMATION SYSTEM
RANGE SHOWN ON THE OPERATOR IS SUITABLE TO THE LOCATIONS WHERE IT WILL BE INSTALLED
,
CABLES INSTALLATION AND TESTING MUST FOLLOW STATE
• I -
F THE POWER SUPPLY CABLE IS DAMAGED
AUTHORIZED TECHNICAL ASSISTANCE CENTER
RING ALL PHASES OF THE INSTALLATION MAKE SURE YOU HAVE CUT OFF THE MAINS POWER SOURCE
TOR CANNOT BE USED WITH GATES FITTED WITH PEDESTRIAN DOORS
WHEN THE PEDESTRIAN DOOR IS IN SAFETY POSITION
'
THE GATE S MOVING AND FIXED PARTS DUE TO THE GATE
THAT THE GATE IS IN PROPER MECHANICAL CONDITION
:
SES IF ANY OF THESE CONDITIONS ARE NOT MET
. • M
TS AKE SURE THAT OPENING AND CLOSING LIMITERS ARE FITTED
ONTO A STURDY SURFACE THAT IS PROTECTED FROM ANY COLLISIONS
• I
ALREADY INSTALLED F THE OPERATOR IS INSTALLED LOWER THAN
,
ACCESS LEVEL FIT ANY PROTECTIONS AND SIGNS TO PREVENT HAZARDOUS SITUATIONS
TOR UPSIDE DOWN OR ONTO ELEMENTS THAT COULD YIELD TO ITS WEIGHT
TO THE FASTENING POINTS
LAWN WATERING DEVICES SPRAY THE OPERATOR WITH WATER FROM THE BOTTOM UP
BE INDICATED CLEARLY WITH PROPER SIGNAGE AFFIXED IN VISIBLE AREAS
. • S
END USERS UITABLY SECTION OFF AND DEMARCATE THE ENTIRE INSTALLATION SITE TO PREVENT UNAUTHORIZED
PERSONS FROM ENTERING THE AREA
,
DOOR PLATE THE GATE PLATE
MECHANICAL HAZARDS WHEN PEOPLE ARE LOITERING AROUND THE MACHINERY
AVOID CRUSHING OF FINGERS BETWEEN THE DRIVE SHAFT AND THE MECHANICAL STOPS
• T
GATE IS OPENING HE ELECTRICAL CABLES MUST RUN THROUGH THE CABLE GLANDS AND NOT TOUCH ANY PARTS
,
THAT MAY OVERHEAT SUCH AS THE MOTOR
DEVICE ALONG THE POWER SUPPLY THAT IS COMPLIANT WITH THE INSTALLATION RULES
OFF THE POWER SUPPLY ACCORDING TO CATEGORY
1.85
INSTALLED AT LEAST
REACHED FROM OUTSIDE THE GATE
THE MOVING GATES LEAVES
SWITCHES MUST BE ALSO AWAY FROM ANY MOVING PARTS
DEVICES MUST BE FITTED AT
T
O PASS THE COLLISION FORCE TEST USE A SUITABLE SENSITIVE SAFETY
. • B
NEEDED EFORE HANDING OVER TO USERS
M
UNIFORMED ACHINERY
SAFETY AND PROTECTION DEVICES
THAT DESCRIBES HOW TO USE THE MANUAL RELEASE MECHANISM
HAND OVER TO THE END USER
⚠
WARNING! Important safety instructions.
P -
ARTLY COMPLETED MACHINERY IS A SET THAT ALMOST CONSTITUTES A MACHINE
E 2006/42/CE
UROPEAN DIRECTIVE
,
ALL PROCEDURES STATED IN THIS MANUAL MUST BE EXCLUSIVELY PERFORMED BY
. • T
HE MANUFACTURER DECLINES ANY LIABILITY FOR USING NON
• K
EEP THIS MANUAL INSIDE THE TECHNICAL FOLDER ALONG WITH THE
,
IT MUST BE IMMEDIATELY REPLACED BY THE MANUFACTURER OR BY AN
,
OR IN ANY CASE
,
• D
O NOT INSTALL DOOR OR GATE LEAVES ON TILTED SURFACES
,
ESPECIALLY MINORS AND CHILDREN
,
WHEREVER NEEDED AND IN PLAIN SIGHT
,
TRANSFORMER
M FROM THE PERIMETER OF THE GATE
. • A
LL SWITCHES IN MAINTAINED ACTION MODE MUST BE POSITIONED SO THAT
,
THE TRANSIT AREAS AND VEHICLE THRU
, , 1.5
AT LEAST M FROM THE GROUND AND MUST NOT BE ACCESSIBLE TO THE PUBLIC
,
CHECK THAT THE SYSTEM IS COMPLIANT WITH THE
D . M
IRECTIVE AKE SURE THE SETTINGS ON THE OPERATOR ARE ALL SUITABLE AND THAT ANY
,
AND ALSO THE MANUAL RELEASE
,
ALL OPERATING MANUALS FOR THE PRODUCTS THAT MAKE UP THE FINAL MACHINERY
harm.
,
WRONGFUL AND UNREASONABLE USE
2006/42/CE
. P
D 2006/42/CE. T
IRECTIVE
AND CURRENT
- - -
OF THE ART PROCEDURES AS DICTATED BY REGULATIONS
,
BY QUALIFIED STAFF
,
UNLESS ITS OPERATION CAN BE ACTIVATED ONLY
. • M
AKE SURE THAT PEOPLE ARE NOT ENTRAPPED BETWEEN
' . B
S MOVEMENT EFORE INSTALLING THE OPERATOR
,
THAT IT IS PROPERLY BALANCED AND THAT IT PROPERLY CLO
DO NOT CONTINUE BEFORE HAVING MET ALL SAFETY REQUIREMEN
• M
• M
2.5
FROM THE GROUND OR FROM ANY OTHER
. A
. • A
. • U
, • S
AND SO ON
III
SURCHARGE CONDITIONS
'
S WORKING AREA
-
WAYS ARE COMPLETELY VISIBLE
• U
NLESS THE ACTION IS KEY OPERATED
-
EDGE
,
WORK PROPERLY
,
CLOSE TO THE MECHANISM
. A
NY OTHER USE IS DANGEROUS
" -
AS PARTLY COMPLETED MACHINERY
-
ARTLY COMPLETED MACHINERY IS ONLY
-
COMPLETED MACHINERY
HE FINAL INSTALLATION
E
UROPEAN REFERENCE STANDARDS
-
ORIGINAL PRODUCTS
. • C
HECK THAT THE TEMPERATURE
. • L
,
TO PREVENT ANY RISK
. • T
AKE SURE THE OPERATOR IS INSTALLED
AKE SURE THAT MECHANICAL STOPS ARE
. • D
O NOT FIT THE OPERA
. I ,
F NECESSARY ADD REINFORCEMENTS
• C
. • A
NY RESIDUAL RISKS MUST
LL OF WHICH MUST BE EXPLAINED TO
FFIX CAUTIONARY SIGNS
SE PROPER PROTECTIONS TO PREVENT
'
S RANGE OF ACTION
,
AVOID CRUSHING WHEN THE
ET UP A SUITABLE DUAL POLE CUT OFF
. I
T SHOULD COMPLETELY CUT
• A
LL OPENING CONTROLS MUST BE
,
OR WHERE THEY CANNOT BE
. I
NSTALL IT PROPERLY AND ADJUST AS
2006/42/CE
. • A
FFIX A PERMANENT TAG
. • M
.
. • T
HIS
".
,
.
;
AYING THE
• D -
U
-
HE OPERA
,
CHECK
-
-
-
HECK THAT NO
,
SUCH AS THE
,
FOR EXAMPLE
,
AND YET THE
,
THE CONTROL
. •
,
AKE SURE TO
.