Table of Contents
Advertisement
Quick Links
Service
Electric Smoothtop
Downdraft Cooktop
This manual is to be used by qualified appliance
technicians only. Amana does not assume any
responsibility for property damage or personal
injury for improper service procedures done by
an unqualified person.
Models and manufacturing
numbers in this manual.
AKEF3070
P1131763N
ACC4370AB
PACC4370AB0
ACC4370AW
PACC4370AW0
RS2420004
Revision 1
July 2001
Advertisement
Table of Contents
Related Manuals for Amana AKEF3070
Summary of Contents for Amana AKEF3070
- Page 1 PACC4370AW0 Service Electric Smoothtop Downdraft Cooktop This manual is to be used by qualified appliance technicians only. Amana does not assume any responsibility for property damage or personal injury for improper service procedures done by an unqualified person. RS2420004 Revision 1...
- Page 2 CAUTION If performing service on your own product, you must assume responsibility for any personal injury or property damage which may result. Amana will not be responsible for any injury or property damage arising from improper service and/or service procedures.
-
Page 3: Table Of Contents
Terminal Block ........... 14 Model Identification and Ordering Blower Fan ............14 Replacement Parts..........5 Wiring Diagram and Schematic ........ 15 2000 Amana Cooking Products Nomenclature ..5 Appendix A Care and Cleaning Installation above an undercounter wall oven ..A-2 Caring for the Smoothtop ........6 Prepare Cooktop ..........A-2... -
Page 4: Important Safety Information
Important Safety Information 2. Never Leave Surface Units Unattended at High Precautions Heat Settings—Boilover causes smoking and • Do not cook food directly on cooktop surface, greasy spillovers that may ignite. always use cookware. 3. Glazed Cooking Utensils—Only certain types of •... -
Page 5: Introduction
Amana service technicians to install and ® service Amana cooktops. However, some parts need further explanation. Amana maintains a toll-free technical support line to answer questions from authorized service technicians. The number is 1-800-AMANA99. 2000 Amana Cooking Products Nomenclature... -
Page 6: Care And Cleaning
Care and Cleaning Suggested Cleaning Part Materials General Directions and Recommendations Pull off knobs. Wash gently but do not soak. Dry and return controls to cooktop, Control knobs Mild soap and water making sure to match flat area on the knob to the flat area on shaft. Clean cooktop trim with damp cloth and soapy water. -
Page 7: Operation
Daily care is quick, easy and can radiate heat through the cooktop. The controls have prevent damage. To purchase Amana recommended infinite settings between LO and HI for fine temperature cleaning products, contact our Consumer Affairs control. -
Page 8: Testing Procedures
Testing Procedures WARNING To avoid electrical shock, personal injury, or death: disconnect power supply before servicing, unless testing requires it. 4. Remove wiring from switch. Power Supply 5. Set ohmmeter on R x 1K scale. Check for continuity If no part of the cooktop operates or only part of it according to the following chart. -
Page 9: Surface Elements (Dual Infinite) Switch
Testing Procedures WARNING To avoid electrical shock, personal injury, or death: disconnect power supply before servicing, unless testing requires it. If the infinite switch contacts are good and the element Surface Elements (Dual Infinite) Switch does not heat, check for voltage at the heating element The surface units and controls offer infinite heat settings. -
Page 10: Fan Motor
Testing Procedures WARNING To avoid electrical shock, personal injury, or death: disconnect power supply before servicing, unless testing requires it. Fan Motor Capacitor 1. Locate junction box on bottom of burner box in rear 1. Remove wire terminals from capacitor terminals. right corner. - Page 11 Testing Procedures WARNING To avoid electrical shock, personal injury, or death: disconnect power supply before servicing, unless testing requires it. Problems Ribbon Element Switch burns out immediately after Improper wiring installation Hot Wired to Neutral terminal. Warranty is installation. VOID.(SEE Installation Instructions.) NOTE: Possible damage to glass.
-
Page 12: Disassembly Procedures
Disassembly Procedures WARNING To avoid electrical shock, personal injury, or death: disconnect power supply before servicing, unless testing requires it. Infinite Switch 1. Disconnect power supply to cooktop. WARNING 2. Disconnect ductwork from downdraft vent system. To avoid risk of property damage, remove cooktop 3. -
Page 13: Capacitor
Disassembly Procedures WARNING To avoid electrical shock, personal injury, or death: disconnect power supply before servicing, unless testing requires it. Capacitor Blower Fan 1. Disconnect power supply to cooktop. 1. Disconnect power supply to cooktop. 2. Remove screw securing capacitor bracket to blower 2. -
Page 14: Wiring Diagram And Schematic
Wiring Diagram and Schematic WARNING To avoid risk of electrical shock, personal injury, or death: disconnect power to oven before servicing, unless testing requires it. RS2420004 Rev. 1... - Page 15 Appendix A A–1 RS2420004 Rev. 0...
-
Page 16: Installation Above An Undercounter Wall Oven
Keep instructions for future reference. Be sure manual stays with cooktop. Read entire instruction before beginning installation. Cooktop is designed to be installed over Amana wall ovens AOES3030 and AOCS3040. PREPARE Placing Cooktop on... -
Page 17: Attach Ductwork
• Do not use laundry wall caps. Wall cap must have minimum of 28 square inches free air Cooktop Front View space. Use Amana wall cap model CC30 or equivalent. A–3 RS2420004 Rev. 0... -
Page 18: Connect Power Supply
CONNECT POWER SUPPLY Junction Box Location Power supply enters cooktop in right rear corner. Junction box must be located within 30 inches of power supply entry point. " 30" Locate junction box within shaded area. Junction box must not interfere with vent system. 24"... -
Page 19: Important Safety Information
IMPORTANT SAFETY INFORMATION WARNING WARNING To avoid serious burns or other personal injury To avoid risk of electrical shock, personal injury, or caused by reaching over heated surface element, death, make sure cooktop has been properly avoid locating storage cabinets above surface grounded and always disconnect it from main power elements. -
Page 20: Installation Requirements
• Four-conductor junction box required in Canada and for most mobile home installations but can be used for residential. NOTE: A power cord must not be used. Questions? See Owner’s Manual or call Amana Consumer Affairs at 1-800-843-0304 RS2420004 Rev. 0 A–6... - Page 21 = 12 equivalent feet 3¼ x 10 inch wall cap 6 inch wall cap (Unrestricted) (Unrestricted) = 0 equivalent feet = 0 equivalent feet © 2000 Amana Appliances Part No. 36-31960001-0 Amana, Iowa 52204 Printed in U.S.A. 01/00 A–7 RS2420004 Rev. 0...
-
Page 22: Venting To The Side Of An Undercounter Wall Oven
Venting to the side of an undercounter wall oven. In addition to venting to the rear of the oven, the AKEF3070 downdraft cooktop can also be vented to the side of the oven. Use the dimensions provided on this page to vent the downdraft to the side of the undercounter wall oven. - Page 23 Appendix B B–1 RS2420004 Rev. 0...
-
Page 24: Installation Without An Undercounter Wall Oven
Surfaces for final cooktop countertop inlay kit can be purchased (3- wire or 4- wire) clearances and Ductwork from an Amana dealer. The following Location section prior to instructions are to install the cooktop with preparing countertop. the glasstop resting on the countertop. -
Page 25: Attach Ductwork
• Do not use laundry wall caps. Wall cap must 4" have minimum of 28 square inches free air " space. Use Amana wall cap model CC30 or equivalent. " Cooktop Front View B–3 RS2420004 Rev. 0... -
Page 26: Connect Power Supply
CONNECT POWER SUPPLY Junction Box Location Power supply enters cooktop in right rear corner. Junction box must be located within 30 inches of power supply entry point. " 30" Locate junction box within shaded area. Junction box must not interfere with vent system. 24"... -
Page 27: Important Safety Information
IMPORTANT SAFETY INFORMATION WARNING WARNING To avoid serious burns or other personal injury To avoid risk of electrical shock, personal injury, or caused by reaching over heated surface element, death, make sure cooktop has been properly avoid locating storage cabinets above surface grounded and always disconnect it from main power elements. -
Page 28: Installation Requirements
• Four-conductor junction box required in Canada and for most mobile home installations but can be used for residential. NOTE: A power cord must not be used. Questions? See Owner’s Manual or call Amana Consumer Affairs at 1-800-843-0304 RS2420004 Rev. 0 B–6... - Page 29 = 12 equivalent feet 3¼ x 10 inch wall cap 6 inch wall cap (Unrestricted) (Unrestricted) = 0 equivalent feet = 0 equivalent feet Part No. 36-31960101-0 © 2000 Amana Appliances Printed in U.S.A. 01/00 Amana, Iowa 52204 B–7 RS2420004 Rev. 0...