Advertisement
Quick Links
SCION
Preparation
Part Number: PTS20-21050
Kit Contents
Item #
Quantity Reqd.
1
1
2
1
3
1
4
1
5
1
6
1
Hardware Bag Contents
Item #
Quantity Reqd.
1
2
2
2
3
8
4
1
5
1
Additional Items Required For Installation
Item #
Quantity Reqd.
1
Conflicts
SCION tC Cargo Net – PN: PT347-52051
Recommended Tools
Personal & Vehicle
Protection
Vehicle Protection
Part Protection
Special Tools
Arch Punch
Mallet
Screwdriver
Installation Tools
Nylon Panel Removal Tool
Socket/Ratchet
Socket Extension
Ratcheting Box End Wrench 13mm
Torque Wrench
Pliers
Issue: A
04/15/04
tC
Description
Vehicle Specific Enclosure
(VSE) Subwoofer
Wire Harness
Hardware Bag
Installation Instructions
Product Feature Placard
Service Care Card
Description
7" Wire Ties
4" Wire Ties
Philips Head Screws
Upper Mounting Hardware
Assembly
Lower Mounting Hardware
Assembly
Description
Notes
Seat/Floor Covers
Blankets
Notes
5/8" Hole Diameter
(McMaster PN: 3427A17)
Rubber Mallet
1.5" Long Narrow Blade
Flat Head (Craftsman PN:
41541 or equivalent)
Notes
e.g. Panel Pry Tool #1
Toyota SST # 00002-06001-
01
10mm, 12mm & 13mm
6 inch (optional)
3 lbf·ft , and 15 lbf·ft
1. Diagonal Cutters
2. Long Nose (optional)
Page 1 of 17 pages
2005 -
VSE SUBWOOFER (BAZOOKA
NOTE: Part number of this accessory may not be
the same as the part number shown.
Screwdriver
Electric Drill
Special Chemicals
Cleaner
General Applicability
ALL SCION tC
Recommended Sequence of Application
Item #
Accessory
1
Security / Audio / Satellite Tuner
2
Rear Cargo Mat / Cargo Liner
3
VSE Subwoofer
4
Door Sills
Vehicle Service Parts
Item #
Quantity Reqd.
1
Legend
STOP: Damage to the vehicle may occur. Do not
proceed until process has been complied with.
OPERATOR SAFETY: Use caution to avoid risk of
injury.
CAUTION: A process that must be carefully observed
in order to reduce the risk of damage to the
accessory/vehicle and to ensure a quality installation.
TOOLS & EQUIPMENT: Used in Figures calls out the
specific tools and equipment recommended for this
process.
REVISION MARK: This mark highlights a change in
installation with respect to previous issue.
VSE Subwoofer Specifications
Woofer Size
Voice Coil Size
Magnet Size
Frequency Response
Efficiency
Power Handling
Dimensions
Weight
Impedance
Magnetized Philips # 2
Philips # 2 Drill Bit
Notes
TM
3M
Prep Solvent–70 (if
required)
*Mandatory
(may be required for reassembly)
Description
10 Inch
1.5 Inch
34 oz
28Hz-100Hz +/-3dB
96 dB
150 watts (woofer)
745mm x 390mm x 370mm
22 lbs
Dual 2 Ohms
®
)
Advertisement
Related Manuals for Bazooka PTS20-21050
Summary of Contents for Bazooka PTS20-21050
- Page 1 3 lbf·ft , and 15 lbf·ft Pliers 1. Diagonal Cutters 2. Long Nose (optional) Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA NOTE: Part number of this accessory may not be the same as the part number shown. Screwdriver Electric Drill Special Chemicals Cleaner...
- Page 2 Fig. 2-1 Fig. 3-1 Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA 1. Pre-installation Precautions (a) Use Seat & Floor Protectors and Fender Covers/Blankets to avoid damage to surfaces. 2. Battery Disconnect (a) NOTE: Be sure to open the rear hatch, PRIOR to disconnecting the battery.
- Page 3 Fig. 3-4 Fig. 3-5 Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA (d) Proceed to remove and secure the rear foam passenger side storage compartment. (1) Remove the two (2) plastic plugs and pull the block straight up. (Fig. 3-2)
- Page 4 Fig. 4-1 Fig. 4-2 Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA (i) Using a 10mm socket, remove the passenger rear D-Ring (Tie Down Hook) (discard) and Plastic Hook save the 10mm bolt for reuse. (j) Remove and save, the Philips head screw from the upper rear passenger panel &...
- Page 5 Fig. 4-6 Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA (d) Remove the radio unit, by removing the two (2) top 10mm nuts and two (2) bottom screws from the radio bracket. (Fig.4-3) (e) Open the glove compartment latch and press the outside edges of the glove compartment inwards, to remove.
- Page 6 Fig. 5-3 Fig. 5-4 Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA 5. Routing Wire Harness (a) Starting at the rear of the vehicle, route the pig tail end underneath the rear strut reinforcement access panel, and route towards rear passenger side taillight. (Fig.5-1) (b) Using the 12mm socket, remove the #3 Child Restraint bracket bolt, &...
- Page 7 REAR WASHER FRONT LOCK Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA (g) Attach wire harness with one (1) 4” wire tie at Fig. 5-5 the junction plug located underneath kick well. (Fig.5-5) (1) Using the diagonal cutter pliers, clip the...
- Page 8 Fig. 7-3 Fig. 7-4 Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA flat washer and lock nut using a 13mm ratcheting box end wrench or socket from behind the inner sheet metal panel. (Fig.7-2) (1) Make sure antenna wire harness runs underneath hardware assembly (Fig.7-2)
- Page 9 SCION Procedure Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA (e) Referencing Step 3. b, reassemble the rear Fig. 9-1 Cargo Floor panel & floor mat (if equipped). (f) Referencing Step 3. a, reassemble the rear Tonneau Cover. (g) Referencing Step 3. e, reassemble the rear bench seat.
- Page 10 SCION Procedure Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA 10. In Process Functional Test. (a) Reconnect the vehicle’s negative battery cable. (1) Position the negative terminal at an angle of 90˚ to the battery as shown. (2) Tighten the nut with 4.1 N-m (36 lbf-in) of torque.
- Page 11 SCION Procedure Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA 11. Reassemble Front Cabin Interior Components (a) Referencing Step 4. g - f., reassemble all panels into their original locations, making sure that all clips are securely fastened. (b) Referencing Step 4. e., reassemble glove compartment &...
- Page 12 SCION Procedure Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA 12. Resetting Vehicle Components (a) Reset the power windows. (1) Turn ignition key to ON position. (2) Push down the power window switches of each door, and lower the windows halfway.
- Page 13 SCION Procedure Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA 14. Clean Up (a) Clean up and remove any trash. (b) If required, wipe down all applicable interior surfaces with 3M remove fingerprints, etc (1) When cleaning with 3M (2) Always use a clean (lint free, scratch resistant) soft cloth (or wipe), and clean a small area at a time ( ~ 3 ft.
- Page 14 HVAC. SSP function. Lighter socket. Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA Check For: Radio display turns on & sound is heard CD player functions & Satellite Tuner stations are playing (if equipped) Reception of AM/FM stations VSE Subwoofer – Listen to VSE...
- Page 15 Low Sound Rattling Noises Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA Check For: 1. Is the green L.E.D. lit on the VSE Subwoofer? If not, check for 12 volts on pins of the VSE Subwoofer with the ignition on.
- Page 16 VSE Subwoofer produces sound on the right or the left, but not both. Issue: A 04/15/04 2005 - VSE SUBWOOFER (BAZOOKA Check For: Dimming Radio Lights could occur when the VSE Subwoofer is played at high volumes. Check to ensure that the main connector, antenna connector, and auxiliary connector have been correctly plugged back in.
- Page 17 12 Volt Battery Connection (B+) Right Front Speaker (-) Left Front Speaker (-) Chassis Ground (B-) Power Antenna Control (+) Power Antenna Control (-) Dimmer / Illumination Control (B+ variable) Page 17 of 17 pages VSE SUBWOOFER (BAZOOKA Subwoofer Connector Function Function Function ®...