WAGNER Model 9140 Owner's Manual page 6

This column contains instructions that will be repeated
throughout this manual.
P I
LUGGING N THE
1. Check that the ON/OFF
switch is in the OFF
position.
2. Plug the sprayer into a
heavy duty grounded
extension cord. Refer to
Important Electrical
Information, page 3).
P R
RESSURE ELIEF
WARNING
Be sure to follow the pressure relief procedure (page 6)
when shutting the unit off FOR ANY PURPOSE. This
procedure is used to relieve pressure from the spray hose.
1. Lock the spray gun off.
GX-06/07
2. Flip the ON/OFF switch to
the OFF (O) position.
3. Unlock the spray gun,
turn the PRIME/SPRAY
knob to PRIME, and
trigger spray gun into
paint bucket.
4. Lock the spray gun.
P S
AINT TRAINING
It is recommended that in order to avoid premature tip and gun
clogging you should strain your paint before spraying. Follow
manufacturer's recommendations.
English
B
EFORE YOU
S
PRAYER
P
ROCEDURE
GX-08/10
Customer Service: 800-880-0993
B
EGIN
C C
HOOSING THE ORRECT
Use the proper gun filter based on the tip size being used.
Part No. Tip Size Filter
Type
0154918 .011 Extrafine
0154675 .013 - .015 Fine
0154842 .017 - .023 Medium
B Y P
EFORE OU RIME THE
Before priming, squirt a teaspoon of separating oil (P/N
0154908 included with unit) into the indicated area. Light
household oil can be substituted if necessary. Do not put
more than a teaspoon into the lubricating area. Too much oil
will leak down into your paint.
I
F YOUR UNIT IS NEW
All units are performance-tested at the factory and are shipped
with test fluid in the fluid section to prevent corrosion during
shipment and storage.
• Whether you are going to spray latex or oil-based
paints, this fluid must be purged and thoroughly cleaned
out of the system (follow Purging and Priming the Pump
steps, page 7).
I
F YOUR UNIT HAS ALREADY BEEN USED
If the pump has already been used you will need to purge the
water or solvent used in cleanup and storage.
6 © 2003 Wagner Spray Tech - All rights reserved.
S G F
PRAY UN ILTER
Mesh Color of Qty.
Filter
Number
Body
180 mesh red 2 pack
0.084 mm
100 mesh yellow 2 pack
0.140 mm
50 mesh white
2 pack
0.315 mm
S
PRAYER
. . .
. . .