Exmark TURF RANGER TR23KC Operator's Manual page 27

For Exmark Mower Parts Call 606-678-9623 or 606-561-4983
6.1.12 Inspect Belt Wear:
6.1.13 Lubricate grease fittings.
IMPORTANT: Make sure the negative battery cables are disconnected
and the battery charger used for charging the battery has an output of 16
volts and 7 amps or less to avoid damaging the battery (see chart below for
recommended charger settings).
Voltage Percent
Reading Charge
12.6 or greater 100%
12.4 – 12.6 75 – 100%
12.2 – 12.4 50 – 75%
12.0 – 12.2 25 – 50%
11.7 – 12.0 0 – 25%
11.7 or less 0%
For Serial Nos. 251,999 and Lower:
Check battery electrolyte level:
Service Interval: 40 hrs.
a) Stop engine and remove ignition key.
b) Remove battery cover.
c) Remove vent caps from battery. If needed, fill with water (distilled is
recommended) to bottom of vent wells and replace vent caps.
d) See Section 3.8 (Assembly) for servicing a new battery.
Service Interval: 40 hrs.
a) Stop engine and remove ignition key.
b) Remove the three cutter deck belt shields to check mower primary and
secondary belt condition.
c) Look under engine deck to check the transmission drive belt condition.
d) Check all idler arms to be sure they pivot freely.
Note: Be sure to check idler on transmission drive belt. Disassemble, clean and
grease pivot bushing if necessary.
a) Stop engine and remove ignition key.
b) Lubricate fittings with one to two pumps SAE No. 2 multi-purpose gun grease.
Refer to the following chart for fitting locations and lubrication schedule.
FITTING
LOCATIONS
1. Front Caster Wheel Bearings
2. Front Caster Spindles
3. Drive Wheel Bearings
4. Engine Deck Pivots
5. Steering Column
6. Idler Pivots, Mower Deck
7. Rear Caster Wheel Bearings
www.mymowerparts.com
Maximum
Charger Settings
16 volts/7 amps
16 volts/7 amps
16 volts/7 amps
14.4 volts/4 amps
14.4 volts/4 amps
14.4 volts/2 amps
LUBRICATION CHART
INITIAL
PUMPS
12
2
1
1
1
1
1
- 22 -
Charging Interval
No Charging Required
30 Minutes
1 Hour
2 Hours
3 Hours
6 Hours or More
NO of SERVICE
PLACES INTERVAL
2 Daily
2 Daily
2 Monthly
2 Weekly
1 Weekly
2 Weekly
1 Monthly