Page 1
All Traulsen units are placed on a permanent record file with the service department. In the event of any future questions you may have, please refer to the model and serial number found on the name tag affixed to the unit.
The serial tag is a permanently affixed sticker on which is recorded vital electrical and refrigeration data about your Traulsen product, as well as the model and serial number. This tag is located on the upper right interior side wall of all air curtain models.
Under no condition may a damaged unit be re- turned to Traulsen & Co. without first obtaining writ- ten permission (return authorization). III. INSTALLATION III.
IV. INTENDED USE (continued) IV. c - SUGGESTED PAN SIZING: Traulsen has designed this unit to operate with either 18” x 26” or 12” x 20” pans. Generally, 12” x 20” pans block air flow which leads to reduced unit per- formance.
This reduces the effectiveness of the overall operation of the unit. To prevent the build-up of ice on the coil, Traulsen has included an “On-Demand” defrost feature. To initiate an on-demand defrost, simply press the ON-DEMAND DEFROST button.
VIII. c - WARRANTY REGISTRATION: For your convenience, the warranties on your new Traulsen unit may be registered with us by one of two methods. Completing the enclosed warranty card (shipped with the unit), or by filling out the on-line warranty registration form located on the Technical Service page of our website (www.traulsen.com).
IX. TROUBLESHOOTING GUIDE PROBLEM 1. Condensing unit fails to start - no hum. 2. Condensing unit fails to start - hums but trips on overload protector. 3. Condensing unit starts, but fails to switch off of “start” winding. 4. Condensing unit starts and runs, but short cycles on overload protector.
IX. TROUBLESHOOTING GUIDE (cont’d) PROBLEM 6. Condensing unit operates for prolonged periods or continuously. 7. Start capacitor open or shorted or blown. 8. Run capacitor open, shorted or blown. 9. Relay defective or burned out. 10. Product zone temperature too high. 11.
(1) year from the date of original installation. Under this war- ranty, TRAULSEN & CO., INC. will repair or replace, at its option, including service and labor, all parts found to be defective and subject to this warranty. The compressor part is warranted for an additional four (4) years. During this period TRAULSEN &...