Pushing Or Towing The Machine; Jacking Points; Transporting The Machine - Toro Groundsmaster 4500-D Operator's Manual

•
Perform a recovery-regeneration whenever
there is a loss of engine power and a parked
regeneration cannot effectively clean the DPF of
soot.
•
A recovery regeneration requires up to 4 hours
to complete.
•
You need a distributor technician to perform the
recovery regeneration process; contact your
Authorized Toro Distributor.
Pushing or Towing the
Machine
Important:
Do not push or tow the machine
faster than 3 to 4.8 km/h (2 to 3 MPH) or internal
transmission damage may occur. The bypass
valve must be open whenever the machine is
pushed or towed.
Important:
If the machine must be pushed or
towed in reverse, the check valve in the four-wheel
drive manifold must also be bypassed. To bypass
the check valve, connect a hose assembly (Hose
Part Number 95-8843, Coupler Fitting Part Number
95-0985 [Qty. 2], and Hydraulic Fitting Part
Number 340-77 [Qty. 2]) to the reverse traction
pressure test port, located on the hydrostat, and
on the port located in-between ports M8 and P2
on the rear traction manifold which is located to
the inside of the front rear tire.
1. Open the hood and locate the bypass valves
(Figure 44) on the top of pump, behind the
battery/storage boxes.
2. Rotate each valve 3 turns counter-clockwise
to open and allow oil to bypass internally. Do
not open more than 3 turns. Because fluid is
bypassed, the machine can be slowly moved
without damaging the transmission.
1. Bypass valve (2)
3. Close the bypass valves before starting the
engine. Torque to 70 N-m (52 ft-lb) to close the
valve.

Jacking Points

•
Front—frame, on the inside of each drive tire.
•
Rear—center of the axle.

Transporting the Machine

Use a heavy-duty trailer or truck to transport the
machine. Ensure that the trailer or truck has all
necessary brakes, lighting, and marking as required
by law. Please carefully read all the safety instructions.
Knowing this information could help you, your family,
pets, or bystanders avoid injury.
WARNING
Driving on the street or roadway without turn
signals, lights, reflective markings, or a slow
moving vehicle emblem is dangerous and can
lead to accidents causing personal injury.
Do not drive machine on a public street or
roadway.
To transport the machine:
1. If using a trailer, connect it to the towing vehicle
and connect the safety chains.
2. If applicable, connect the trailer brakes.
3. Load the machine onto the trailer or truck.
41
Figure 44
g020510