Startup And Operation; Stocking; Load Limits - Hussmann RL2W Installation & Operation Manual

P/N 3053328_C

STARTUP AND OPERATION

See the merchandiser's Technical Data Sheet for
refrigerant settings and defrost require ments. Bring
merchandisers down to the operating temperatures
listed on the data sheet.
Excessive ambient conditions may cause
condensation and therefore sweating of doors.
Facility operators should monitor doors and
floor conditions to ensure safety of persons.

STOCKING

Product should NOT be placed in merchandisers until
all refrigeration controls have been adjusted and
merchandisers are at proper operating temperature.
All shelves and the lower deck are intended to display
product. Shelf height is adjustable in one inch
increments. Spacing of 10 inches is recommended
for most applications. Maximum load per shelf is
200 pounds.
Proper rotation of product during stocking is
necessary to prevent product loss. Always bring the
oldest product to the front and set the newest to the
back.
a
ir discharge and reTurn flues musT remain open
and free of obsTrucTion aT all Times
proper refrigeration and air curtain performance. Do
not allow product, packages, signs, etc. to block these
grilles. Do not use non-approved shelving, baskets,
display racks, or any accessory that could hamper air
curtain performance.
Do not prop doors open while stocking. And keep
the doors closed as much as possible to prevent coil
frosting and high merchandiser temperature.
Hussmann recommends
solid shelves for ice cream.
HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.

LOAD LIMITS

Shelf life of perishables will be short if load limit is
violated. a
beyond The load limiTs indicaTed
Various shelf depths are offered with Reach In cases.
The standard depth on all Reach-In cases is 22" (21"
on RFLNS and RFMNS cases). Some cases have been
designed to support larger shelves, but require design
modifications to support the extra shelf length. These
cases have a label near the serial plate that reads: This
case has been reinforced to support 26" shelves.
DO NOT INSTALL 26" SHELVES IN ANY REACH
IN CASE THAT DOES NOT HAVE THIS LABEL.
to provide
T no Time should merchandisers be sTocked
RL-SP
LIMITS
FAN
D
o not block honeycomb
Do not store items or flammable
materials atop the unit.
Do not walk on case.
.
RL-W
LOAD
COIL
Reach-In
4-3
.