Henny Penny 500 Operator's Manual page 29

Volts Phase
240 Three
480 Three
480 Three
2 2 . . 1 1 4 4 E E l l e e c c t t r r i i c c a a l l R R e e q q u u i i r r e e m m e e n n t t ( ( G G a a s s M M o o d d e e l l s s ) )
The gas fryer requires 120-volt, single-phase, 60-Hz, 10 amp, 3-wire grounded
(earthed) service, or 230-volt, single-phase, 50-Hz, 5 amp, 1 phase service. The 120-
volt gas fryer is factory equipped with a grounded (earthed) cord and plug for your
protection against shock, and should be plugged into a three prong grounded
(earthed) receptacle. Do not cut or remove grounding (earthing) prong. A wiring
diagram is located behind the right side panel, and can be accessed by removing the
side panel. The 230-volt plug must conform to all local, state and national codes.
• D D o o n n o o t t d d i i s s c c o o n n n n e e c c t t t t h h e e g g r r o o u u n n d d ( ( e e a a r r t t h h ) ) p p l l u u g g . . T T h h i i s s f f r r y y e e r r
• T T o o a a v v o o i i d d e e l l e e c c t t r r i i c c a a l l s s h h o o c c k k , , t t h h i i s s a a p p p p l l i i a a n n c c e e m m u u s s t t b b e e
2 2 . . 1 1 5 5 C C h h e e c c k k i i n n g g T T h h e e F F i i l l t t e e r r P P u u m m p p
Use the following testing procedure on new or old fryers.
Open the front door of the fryer.
1 1 ) )
Loosen the filter union connection.
2 2 ) )
Turn the main power switch to the pump position. Open the filter valve. You will
3 3 ) )
hear the electric motor running. NOTICE Only run the pump for a few seconds
or damage to the pump could result.
Place your thumb over the open filter union flare. See
4 4 ) )
Filter Pump , page
pump.
KW Amps
13.50 33
11.25 14
13.50 16
m m u u s s t t b b e e a a d d e e q q u u a a t t e e l l y y a a n n d d s s a a f f e e l l y y g g r r o o u u n n d d e e d d ( ( e e a a r r t t h h e e d d ) ) , , o o r r
e e l l e e c c t t r r i i c c a a l l s s h h o o c c k k c c o o u u l l d d r r e e s s u u l l t t . . R R e e f f e e r r t t o o l l o o c c a a l l e e l l e e c c t t r r i i c c a a l l
c c o o d d e e s s f f o o r r c c o o r r r r e e c c t t g g r r o o u u n n d d i i n n g g ( ( e e a a r r t t h h i i n n g g ) ) p p r r o o c c e e d d u u r r e e s s , , o o r r i i n n
a a b b s s e e n n c c e e o o f f l l o o c c a a l l c c o o d d e e s s , , w w i i t t h h T T h h e e N N a a t t i i o o n n a a l l E E l l e e c c t t r r i i c c a a l l
C C o o d d e e , , A A N N S S I I / / N N F F P P A A N N o o . . 7 7 0 0 - - ( ( t t h h e e c c u u r r r r e e n n t t e e d d i i t t i i o o n n ) ) . . I I n n
C C a a n n a a d d a a , , a a l l l l e e l l e e c c t t r r i i c c a a l l c c o o n n n n e e c c t t i i o o n n s s a a r r e e t t o o b b e e m m a a d d e e i i n n
a a c c c c o o r r d d a a n n c c e e w w i i t t h h C C S S A A C C 2 2 2 2 . . 1 1 , , C C a a n n a a d d i i a a n n E E l l e e c c t t r r i i c c a a l l C C o o d d e e
P P a a r r t t 1 1 , , a a n n d d / / o o r r l l o o c c a a l l c c o o d d e e s s . .
e e q q u u i i p p p p e e d d w w i i t t h h a a n n e e x x t t e e r r n n a a l l c c i i r r c c u u i i t t b b r r e e a a k k e e r r w w h h i i c c h h w w i i l l l l
d d i i s s c c o o n n n n e e c c t t a a l l l l u u n n g g r r o o u u n n d d e e d d ( ( u u n n e e a a r r t t h h e e d d ) ) c c o o n n d d u u c c t t o o r r s s . . T T h h e e
m m a a i i n n p p o o w w e e r r s s w w i i t t c c h h o o n n t t h h i i s s a a p p p p l l i i a a n n c c e e d d o o e e s s n n o o t t
d d i i s s c c o o n n n n e e c c t t a a l l l l l l i i n n e e c c o o n n d d u u c c t t o o r r s s . .
18. You should feel suction. Close the filter valve. Turn off the
Supply Wire Minimum
Size Fuse Size
8 50
14 25
14 25
Figure 2-11 Checking
17