Nokia RM-57 Service Manual page 263

Nokia Customer Care
(triggering needed). Another possibility is to use following settings: RBW = VBW = 1 MHz,
Span 200 kHz and sweep time at least 2.5 seconds.
Connect the RF probe to the T7503 input. VCO shield has to be removed before measurement.
•
Remember to solder the shield back after the phone repairing.
• Check if the frequency of the TX VCO is as expected. If the VCO signal is not found try to use
wider span setting. The output level of the VCO should be about -25 dBm during GSM TX burst.
3.1.3.2.1.1 Replace TX VCO G7502
3.1.3.2.2 Replace balun T7503
3.1.3.3 VCTCXO frequency and output level ok?
Measurement can be done with an oscilloscope and a probe.
•
• Connect the probe to C7529 (or C7582)
• The frequency of the VCTCXO should be quite exactly 38.4 MHz and level about 0.5 - 0.9 Vpp.
Example of the correct VCTCXO output signal is presented in figure
Offset 1.24 V)".
3.1.3.3.1 VXO-voltage ok? (=Vdig).
• Measurement can be done with an oscilloscope and a probe
• Connect the probe to C7560 (or C7526, C7513)
• VXO-voltage should be about 2.5 V
3.1.3.3.1.1 C7560, C7513, C7526 and C2214 ok?
• Check that components are in place and solder joints are ok
• Disconnect the power supply from the phone and use an ohmmeter to find out if the VXO-line
is short-circuited to the ground. If short-circuit is found replace C7560, C7513, C7526 and
C2214. If replacing does not help then go to the next steps.
3.1.3.3.1.2 Replace Retu
3.1.3.3.1.3 Replace Hinku (N7500) or Vinku (N7501) or VCTCXO (G7501) or all three components
3.1.3.3.2 BB AFC-voltage ok?
• Measurement can be done with an oscilloscope and a probe
Connect the probe to R7509 (or C7533)
•
• AFC-voltage may vary between 0.1 - 2.3 V. Typical value is 1.2 V. Phoenix "RF Controls" tool can
be used to change the AFC value. Voltage level should be about 0.1 V with AFC value -1024
and about 2.3 V with AFC value 1023.
Company Confidential
Copyright © 2005 Nokia. All rights reserved
Appendix A: RF Troubleshooting
4.6.1 "VCTCXO Output (DC
A-45