Battery Charge/Jump Troubleshooting; Section 13 − Parts List; Recommended Spare Parts - Miller TRAILBLAZER 302 AIR PAK Owner's Manual

Trouble
Air compressor overheats (continued)
Oil in compressor air cleaner.
Water in compressor oil.
Moisture in compressor air.
System retains pressure after shutdown. Have Factory Authorized Service Agent check compressor blow down valve, and leak back from airline.

12-7. Battery Charge/Jump Troubleshooting

Trouble
No battery charge/jump output.
Charging current turns on and off while
charging battery.

13-1. Recommended Spare Parts

Dia. Part
Mkgs.
. . . . . . . . . . . F6 . . . . . 021718
. . . . . . . . . . . F7 . . . . . 242712
. . . . . . . . . . . . . . . . . . . . 238743
. . . . . . . . . . . . . . . . . . . . 238744
. . . . . . . . . . . . . . . . . . . . 238745
. . . . . . . . . . . . . . . . . . . . 066698
. . . . . . . . . . . . . . . . . . . . 215985
. . . . . . . . . . . . . . . . . . . . 238746
. . . . . . . . . . . . . . . . . . . . 232207
. . . . . . . . . . . . . . . . . . . . 232208
. . . . . . . . . . . . . . . . . . . . 232209
. . . . . . . . . . . . . . . . . . . . 250892
♦203877
. . . . . . . . . . . . . . . . . .
♦OPTIONAL
Adjust compressor air pressure (see Section 7-2).
Replace compressor oil filter (see Section 11-5).
Have Factory Authorized Service Agent check cooling fan. Automatic shutdown stops compressor if
compressor temperature is too high.
Have Factory Authorized Service Agent check thermal valve element, and replace if necessary.
Have Factory Authorized Service Agent clean compressor cooler core.
Have Factory Authorized Service Agent verify compressor inlet valve is operating properly.
Operate air compressor at 3600 rpm to remove water.
If oil appears milky, change oil, oil filter, and air/oil separator.
Install optional air cooler with separator (Part No. 300 420), or desiccant dryer (Part No. 195 117).
Be sure DC/Battery/AC switch is in Jump/Charge position.
Be sure Compressor switch is in a Jump or Charge position.
Be sure battery is connected.
Check battery voltage, charging may be finished.
Have Factory Authorized Service Agent check battery charge circuitry.
Clean and tighten battery connections, if necessary. Clean battery terminals and posts with baking soda
solution and rinse with clear water.
Decrease Voltage/Amperage control setting.
SECTION 13 − PARTS LIST
No.
Recommended Spare Parts
. . Fuse, Mintr Gl 30 Amp 32 Volt
. . Fuse, 15 Amp Automotive Blade
. . Tune−up & Filter Kit, Kohler (Includes)
. . . . Air Filter Element
. . . . Air Filter, Kohler Safety Element
. . . . Oil Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . Filter, Fuel w/Clamps & 1/4 in Fuel Line
. . . . Spark Plug . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . Filter, Oil Air Compressor
. . Filter, Inlet Air Air Compressor
. . Separator, Oil/Air Rotary Screw Compressor
. . Belt, Drive AirPak 6 Rib Poly V K
. . Element, Filter 5 Micron
.
A complete Parts List is available at www.MillerWelds.com
Remedy
Remedy
Description
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Quantity
. . . . . . . . . . . . . . . . . . . . . . .
OM-229 930 Page 61
1
1
1
1
1
1
1
2
1
1
1
1
1