Toro groundsmaster 3240-d Operator's Manual page 62

1.62
TROUBLE SHOOTING
When using the following chart it may be found that overhaul of major components or hydraulic
pressure adjustments are necessary. In this case it is recommended that your dealer make these repairs
as he is properly equipped to do this work.
WARNING: PREVENT ACCIDENTS - ALWAYS Apply the parking brake, switch off the engine
and remove the ignition key before attempting to work on the mower.
PROBLEM
Engine will not start with
ignition key.
For all other engine problems, refer - ENGINE HANDBOOK.
Flat Battery.
TROUBLE SHOOTING
POSSIBLE CAUSE
Transmission neutral interlock
switch not energised.
Parking brake interlock switch
not energised.
Cutterdeck drive interlock
switch not energised.
Faulty electrical connection.
Terminal connection
loose or corroded.
Loose or defective
alternator belt.
Defective battery.
Electrical short circuit.
REMEDY
Check telltale indicators.
Remove foot from
forward/reverse pedals.
Check setting of transmission
neutral interlock switch.
Check telltale indicators.
Operate parking brake lever to
the 'ON' position
Check setting of parking brake
interlock switch.
Check telltale indicators.
Move cutterdeck drive switch to
the 'OFF' position.
Check setting of cutterdeck
interlock switch.
Trace and correct fault.
Clean and tighten
terminal connections.
Recharge battery.
Re-tension or replace
drive belt, refer
- ENGINE HANDBOOK.
Recharge battery.
Replace battery.
Trace short circuit and
make good.
1.62