Inspecting The Wheels And Tires; Servicing The Air Cleaner - Toro 41581 Operator's Manual

The jacking point at the rear of the sprayer is on the rear
side where the boom supports are (Figs. 29 and 30).
Figure 29
1. Rear jacking points
1
Figure 30
1. Rear jacking point (2)
Inspecting the Wheels and
Tires
Check the wheels to ensure that they are mounted securely
after the first 1 to 4 operating hours and then every
100 operating hours thereafter. Torque the front bolts to 55
to 75 ft-lb (75 to 102 N⋅m) and the rear lug nuts to 70 to
90 ft-lb (95 to 122 N⋅m).
Check the tire condition at least every 100 operating hours.
Operating accidents, such as hitting curbs, can damage a
tire or rim and also disrupt wheel alignment, so inspect the
tire condition after an accident.
1

Servicing the Air Cleaner

Check the air cleaner body for damage that could cause an
air leak. Ensure that the dust cap is tightly sealed onto the
air cleaner. Replace a damaged air cleaner body. Squeeze
the valve (Fig. 31) before each use to clear it of dust and
debris. Service the air cleaner filter every 100 hours.
2
1. Air cleaner strap (2)
2. Dust cap
Note: Service the air cleaner more frequently if operating
conditions are extremely dusty or sandy.
Removing the Filter Element
1. Set the parking brake, stop the pump, stop the engine,
and remove the ignition key.
2. Raise the passenger seat.
3. Loosen the air cleaner strap that secures the air cleaner
cover to the air cleaner body (Fig. 31) and separate the
cover from the body.
4. Clean the inside of the air cleaner cover.
5. Gently slide the filter out of the air cleaner body to
reduce the amount of dust dislodged.
Note: Avoid knocking the filter against the air cleaner
body.
6. Inspect the filter and discard it if it is damaged.
Important
Do not wash or reuse a damaged filter.
Cleaning the Filter Element
Clean the air filter using one of the following methods:
• Wash the filter to remove fine dust and dirt embedded
in the filter.
• Clean the filter with low pressure compressed air if it
has large particles or is not very dirty.
29
4
3
Figure 31
3. Filter
4. Valve
1