Specifications; General Specifications - Toro 44044 Operator's Manual

Specifications

General Specifications

Type
Engine
Battery
Fuel System
Electrical
Traction System
Controls
Gauges
Reel Drive
Steering
Brakes
Tires, Wheels
Seat
Interlock Switches
Hopper
Three wheeled, front steer, rear drive, one person ride–on turf sweeper with welded
steel frame and integral hopper for collecting debris.
Manufacturer: Kohler, Model CH1 BS, air cooled, 4 cycle
Horsepower: 18 @ 3600 RPM
Maximum Torque: 30 ft.–lb. @ 2500 RPM
Compression Ratio: 8.5. I
Displacement: 38.1 cu. in. (624 CC)
Oil Capacity w/filter: 2.1 quarts (2 liters)
Governor: Mechanical
Governor Limit: 3000 RPM
Idle Speed: 1200 RPM
Air Cleaner–High density paper element with oiled foam precleaner
Fuel Filter: 15 micron in–line filter
12 volt with 370 cold cranking amps. (CCA) at 0_ F. Type 24.
5 gallon (18.9 liter) tank.
Type 24. 12 volt with 370 Cold Cranking Amps (CCA) at 0_ F. Electrical circuit is
fused at 10.0 Amps.
Sundstrand Series 15 pump coupled to Parker/Ross Model MS 10 wheel motors.
Filtration – 25 micron suction line filter (replaceable spin on element).
Foot pedal control with cable to ramped neutraling device on hydrostatic pump with
eccentric neutral adjust.
Throttle, choke, Reel PTO Engagement handle, parking brake, hopper release
handle, and ignition switch are all hand–operated. Forward/reverse traction pedal is
foot operated.
Hour meter, hydraulic vacuum gauge, and engine oil pressure warning light.
Electric clutch with brake. Automatically engages when Reel PTO Engagement
Handle lowers reels (2 heights). Sweeping pick–up with two counter–rotating finger
reels, baffles and skirts. Reels rotate at 1100 RPM, and effectively pick up light
debris on turf up to 5 mph.
Manual, 14 in. soft touch, 3 position tilt steering wheel, 6 to 1 ratio.
Rear 6 in. drums with hand lever actuated to dual cables.
Front (1)–18 x 8.5–8 in. turf tread.
Rear (2)–18 x 9.5–8 in. ribbed tread. All tires 4 ply rating, tubeless type.
High–back cushion with slide adjust.
Prevents engine starting if traction pedal or Reel PTO Engagement handle are
engaged. Stops engine if operator leaves seat with either traction pedal or PTO
switch engaged.
Stationary, 1.25 cu. yd. capacity, with deflectors and grass filling baffles. Gas strut
supported rear dumping door, with integral discharge duct and wire mesh screen
for directing dust and air away from operator.
9