Exmark LAZER Z Operator's Manual page 32

For Exmark Mower Parts Call 606-678-9623 or 606-561-4983
4.1.7 Check rollover protections systems (roll bar) pins:
4.1.8 Check for loose hardware:
4.1.9 Service air cleaner:
4.1.10 Check Spark Arrester:
Service Interval: Daily
a) Make sure latch pin and hair pin are fully installed and lanyard is in good
condition.
Service Interval: Daily
a) Stop engine, wait for all moving parts to stop, and remove key. Engage
parking brake.
b) Visually inspect machine for any loose hardware or any other possible
problem. Tighten hardware or correct the problem before operating.
Service Interval: 50 hrs.
More often under severe conditions.
See Engine manual for additional information.
a) Stop engine, wait for all moving parts to stop, and remove key. Engage
parking brake.
b) Loosen retaining clips and remove air cleaner compartment cover.
c) Remove paper element. Check the condition of the paper element.
Replace if dirty, bent or damaged.
d) Check the condition of the inner element. Replace whenever it appears
dirty, typically every other time the paper element is replaced. Clean the
base around the inner element before removing, so dirt does not get into
the engine.
e) DO NOT wash or use pressurized air to clean paper element or inner
element.
f) Reinstall elements. Position the cover so that the rubber dust ejector is
pointing downward and secure with retaining clips.
Kohler EFI engines only:
POTENTIAL HAZARD
♦ Hot exhaust system components may
ignite gasoline vapors even after the
engine is stopped.
♦ Hot particles exhausted during engine
operation may ignite flammable materials.
WHAT CAN HAPPEN
♦ Fire may result in personal injury or
property damage.
HOW TO AVOID THE HAZARD
♦ Do NOT refuel or run engine unless spark
arrester is installed.
a) Shut off engine, remove key, and wait for all moving parts to stop. Engage
parking brake.
b) Wait for muffler to cool.
c) If any breaks in the screen or welds are observed, replace arrester.
www.mymowerparts.com
Service Interval: 50 hours
WARNING
27