Replacing The Fuel Line; Electrical System Maintenance; Servicing The Traction Interlock Switch - Toro Greensmaster Flex 1800 04040 Operator's Manual

6. Install the fuel tank cap to the fuel tank.

Replacing the Fuel Line

Service Interval: Every 1,000 hours
Replace the fuel line after every 1000 hours. If fuel leaks from
the line, replace it immediately.
Electrical System
Maintenance
Servicing the Traction
Interlock Switch
Use the following procedure if the switch needs adjustment
or replacement.
1. Make sure the engine is off.
2. Remove the control panel.
3. Engage the traction lever.
1. Traction lever
4. Loosen the interlock switch mounting fasteners
39).
5. Place a 1.6 mm (0.062 inch) thick shim between the
traction lever and the interlock switch
6. Tighten the interlock switch mounting fasteners.
7. Engage the traction lever and check the gap. The
normal operating range is between 0.76 to 3.05 mm
(0.03 to 0.12 inches). With the traction lever engaged,
verify that the switch loses continuity. Replace the
switch, if required.
30
Figure 39
2. Interlock switch
(Figure
(Figure
39).