Sign In
Upload
Manuals
Brands
ADC Manuals
Dryer
ADG-75D
ADC ADG-75D Manuals
Manuals and User Guides for ADC ADG-75D. We have
2
ADC ADG-75D manuals available for free PDF download: Installation And Operation Manual, User Manual
ADC ADG-75D Installation And Operation Manual (77 pages)
Brand:
ADC
| Category:
Dryer
| Size: 2.48 MB
Table of Contents
What to Do if You Smell Gas
1
Table of Contents
5
Receiving and Handling
7
Specifications
10
Specifications
11
Component Identification
12
Product View
12
Dryer Front View
12
Dryer Rear View
13
Installation Procedures
14
Location Requirements
14
Unpacking/Setting up
15
Leveling Dryer
15
Dryer Enclosure Requirements
16
Fresh Air Supply
17
Exhaust Requirements
18
General Exhaust Duct Work Information
18
Horizontal Venting
18
Vertical Venting
18
Outside Duct Work Protection
19
Single Dryer Venting
19
Multiple Dryer (Common) Venting
21
Electrical Requirements
23
Electrical Information
23
Electrical Service Specifications
24
Grounding
26
Electrical Connections
26
Gas Supply
31
Gas Information
31
Technical Gas Data
32
Piping/Connections
33
Steam Information
34
Steam Coil PH Level
34
Steam Requirements - High Pressure
35
Steam Lines Installation
35
Steam Damper Air System Connections
37
Steam Damper System Operation
38
Steam Damper Air Piston (Flow Control) Operation Adjustment
39
Preparation for Operation/Start-Up
40
Preoperational Tests
41
Preoperational Instructions
43
Shut down Instructions
44
Service/Parts Information
45
Warranty Information
46
Returning Warranty Cards
46
Returning Warranty Parts
46
Routine Maintenance
48
Cleaning
48
Adjustments
50
Functional Check of Replacement Components
51
Microprocessor (Computer) Board
51
Direct Spark Ignition (DSI) System
52
Reversing Timer Spin/Dwell Adjustments
53
Section VIII
53
Technical Information
54
Data Label
54
Troubleshooting
56
No LED Display
58
Drive Motor Is Not Operating (Does Not Start)
58
Drive Motor Operates in One Direction Only
58
Drive Motor Operates Okay for a few Minutes, then Stops
58
Blower/Fan Motor Is Not Operating (Does Not Start)
59
Blower/Fan Motor Operates Okay, then Stops
59
Both Drive Motor and Blower Motor Not Operating
59
Both Drive Motor and Blower (Impeller/Fan) Motor Run and Stop
59
Microprocessor LED Display Reads "Dsfl" Continuously
60
Microprocessor Controller LED Display Reads "Door"
60
Microprocessor Controller will Not Accept Keyboard Entries
60
Microprocessor Controller will Only Accept Certain Keyboard Entries
60
Dryer Stops During a Cycle, Microprocessor Controller Buzzer Sounds
61
Microprocessor Controller LED Display Reads "SEFL"
61
Microprocessor Controller LED Display Reads "Hot"
61
Heating Unit Is Not Operating (no Heat), no Voltage at Heating Unit
62
Dryer Operates but Is Taking too Long to Dry
64
At Completion of "Auto" Cycle the Load Is Coming out over Dried
66
At Completion of "Auto" Cycle the Load Is Coming out Still Damp
66
Main Burners Are Burning with a Yellow Flame
67
Condensation on Main Door Glass
67
Scraping Noise at Basket (Tumbler) Area
67
Excessive Noise And/Or Vibration
67
Both Driver and Motor and Blower Motor Are Not Operating
68
No Heat, no Voltage at Heating Unit
71
Advertisement
ADC ADG-75D User Manual (66 pages)
Phase 5 Coin Microprocessor Controller
Brand:
ADC
| Category:
Dryer
| Size: 0.66 MB
Table of Contents
Table of Contents
3
Section I
6
Introduction
6
Phase 5 Coin Microprocessor Controller (Computer) Features
6
Display and Codes
10
Operating Instructions
12
Timed Mode
12
Automatic Mode (Patent No. 4,827,627)
13
Free Dry Mode
14
Program Selection
15
Temperature Display Mode
15
Right Coin Count (Rcc)/Left Coin Count (LCC)
15
Automatic Review of Program Location
16
PL01 - Temperature Conversion Status
17
Automatic Mode (Auto) Patent No. 4,827,627
17
Timed Mode (Tine)
17
Anti-Wrinkle Program (Grd)
18
Buzz/Tone (Buz)
18
Free Dry Mode Cycle (Free)
18
Coin Mode (Coin)
19
Flash Display Status (FLS)
19
Bad Coin Lockout Status (Bclo)
19
Bad Coin Reset (Bcrs)
19
Accumulative Time (Atin)
20
Accumulative Coin (Acon)
22
Rotational Safe Guard - OPTIONAL (Nsen)
23
PL02 - Percent Dry (Pdry)
23
PL03 - High Temperature (HI° F)
23
PL04 - High Cool down Temperature/Time (Hicd)
24
Pl05 - Low Temperature (Lo°F)
24
PL06 - Low Cool down Temperature/Time (Locd)
24
Pl07 - Permanent Press (Pp°F)
24
PL08 - PERMANENT PRESS COOL down TEMPERATURE/TIME (Ppcd)
24
PL09 - Left Coin Slot Denomination (Lcde)
24
PL10 - Right Coin Slot Denomination (Rcde)
25
PL11 - Time for Amount to Start (Tfas)
25
PL12 - Amount to Start (Atst)
25
PL13 - Minimum Amount for Additional Time (AFAT)
25
PL14 - Maximum Time for Automatic Dry (Adrt)
25
PL15 - Anti-Wrinkle Timing
26
Guard Delay Time (Gdly)
26
Guard on Time (Gont)
26
PL16 - Active Guard Time (Agt)
26
PL17 - "A" and "B" Factors
26
Programming Instructions
27
Introduction to Programming
27
Programming (Flowcharts)
28
Programming
31
Temperature Display Mode
31
Left Coin Count
32
Right Coin Count
33
Program Location 01 (PL01)
34
Program Location 02 (PL02)
38
Program Location 03 (PL03)
39
Program Location 04 (PL04)
40
Program Location 05 (PL05)
41
Program Location 06 (PL06)
42
Program Location 07 (PL07)
43
Program Location 08 (PL08)
44
Program Location 09 (PL09)
45
Program Location 10 (PL10)
46
Program Location 11 (PL11)
47
Program Location 12 (PL12)
48
Program Location 13 (PL13)
49
Program Location 14 (PL14)
50
Program Location 15 (PL15)
51
Program Location 16 (PL16) and Program Location 17 (PL17)
52
Factory Preset Programs/Parameters
53
Single Coin Only
54
For All Dryer Models Except AD-26/AD-295 and AD-540/WDA-540
54
Dual Coin Only
55
For All Dryer Models Except AD-26/AD-295 and AD-540/WDA-540
55
Single Coin Only
56
For Dryer Models AD-26/AD-295 Only
56
Dual Coin Only
57
For Dryer Models AD-26/AD-295 Only
57
Phase 5 Coin System Diagnostics
58
Diagnostic (L.E.D) Failure Codes
58
Door
58
Dsfl
58
Sefl
59
Hot
59
Display Indicators/Dots
59
Phase 5 Microprocessor Controller (Computer) Relay Output L.E.D. Indicators
60
Door
60
Heat
61
MTR" (Motor)
61
1 Heat Circuit Indicator
59
2 Motor Circuit Indicator
59
Phase 5 Auto Cycle (Patent No. 4,827,267) "A" and "B" Factor Parameters
62
Optional 9 Volt Battery Backup
64
Advertisement
Related Products
ADC ADG-758
ADC ADG-115
ADC ADG-25D
ADC ADG-26D
ADC ADG-215D
ADC ADG-220D
ADC ADG-230D
ADC ADG-320D
ADC ADG-30DS (A)
ADC ADG-30DS (b)
ADC Categories
Network Hardware
Dryer
Medical Equipment
Thermometer
Blood Pressure Monitor
More ADC Manuals
Login
Sign In
OR
Sign in with Facebook
Sign in with Google
Upload manual
Upload from disk
Upload from URL