Table of Contents
Advertisement
CONTENTS
CW-C180EF-W
CW-C240EF
CW-C180EF-M
CW-SC180EF
Page
2
3
4
6
6
6
8
© 2000 Matsushita Industrial Corp. Sdn. Bhd.
(11969-T). All rights reserved. Unauthorized copying
and distribution is a violation of law.
Order No. MAC0011062C3
Room Air Conditioner
Page
10
14
15
16
17
18
Advertisement
Table of Contents
Related Manuals for Panasonic CW-C180EF-W
Summary of Contents for Panasonic CW-C180EF-W
-
Page 1: Table Of Contents
Order No. MAC0011062C3 Room Air Conditioner CW-C180EF-W CW-C240EF CW-C180EF-M CW-SC180EF CONTENTS Page Page 1 Product Specifications 8 How to Install 2 Dimensions 9 Care and Maintenance 3 Wiring Diagram 10 Service Information 4 Refrigeration Cycle Diagram 11 Technical Data 5 Air Conditioner Performance Evaluation... -
Page 2: Product Specifications
CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 1 Product Specifications Model CW-C180EF-W CW-C240EF CW-C180EF-M CW-SC180EF Phase Single Single Voltage 220 - 240 V 220 - 240 V Frequency 50 Hz 50 Hz Capacity 5.34 - 5.40 kW 6.95 - 7.10 kW... -
Page 3: Dimensions
CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 2 Dimensions 2.1. Top View, Front View & Side View. 2.2. Unit. Item CW-C180EF-W CW-C240EF CW-C180EF-M CW-SC180EF A - Width 26” (660) B - Height 16-7/8” (428) C - Depth 27-9/16” (700) 30-11/32” (770) 1-31/32”... -
Page 4: Wiring Diagram
CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 3 Wiring Diagram 3.1. CW-C180EF-W, CW-C180EF-M & CW-SC180EF. 3.1.1. Resistance of Fan Motor windings 3.1.2. Resistance of Compressor and the rated Capacitor. windings and the rated Capacitor. CW-C180EF-W CW-C180EF-W CW-C180EF-M CW-C180EF-M CW-SC180EF CW-SC180EF... - Page 5 CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 3.2. CW-C240EF. 3.2.1. Resistance of Fan Motor windings 3.2.2. Resistance of Compressor and the rated Capacitor. windings and the rated Capacitor. CW-C240EF CW-C240EF Connection CWA921039 Connection 2JS438D4CA02 17.42 Ω 0.820 Ω Blue - Yellow 2.34 Ω...
-
Page 6: Refrigeration Cycle Diagram
CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 4 Refrigeration Cycle Diagram CW-C180EF-W, CW-C180EF- CW-C240EF M & CW-SC180EF Item Pressure Temperature Pressure Temperature (MPa) (°C) (MPa) (°C) 2.09 ~ 2.19 64 ~ 83 2.23 ~ 2.30 72 ~ 88 1.94 ~ 2.04 38 ~ 48 2.01 ~ 2.16... - Page 7 CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF Trouble Check Result Cause Remedy • Air Swing Switch. • OFF position. • Open circuit. • Set it ON. Air Swing won’t run. • Resistance between • No contact at • Shorted or open circuit.
-
Page 8: Operating Instructions
CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 7 Operating Instructions 7.1. Parts Identification. 7.1.1. Vertical Airflow Direction Vane. 7.1.3. Neon Lamp Indicator. Airflow direction adjustment Up-and-Down. Neon Lamp Indicator. • The vertical airflow direction vane is • The green neon light mounted above... -
Page 9: How To Operate
CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 7.2. How to Operate. Open the Control Panel Cover. Fig. 1 Power Supply Switch off the breaker and set the Main Control Knob to the OFF position before connecting the power plug cord to an independent power supply. -
Page 10: How To Install
• Some installation locations may require installation of a short-circuit breaker. • Time delay fuse or circuit breaker rating is 16 Amp. for CW-C180EF-W/M & CW-SC180EF and 25 Amp. for CW-C240EF. • Nominal cross sectional area of power supply wire must be 3 core x 2.0 mm or above (CW-C180EF-W/M &... -
Page 11: Installation Procedure
CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 8.3. Installation Procedure. 8.3.1. Remove the Chassis Locking 8.3.4. Slide the Chassis back into the Bracket and screws. Cabinet. • Unscrew and remove the Chassis Locking Bracket from the front of the Cabinet. Remove the two screws from the rear of the Cabinet (For transportation purpose only). -
Page 12: Removal Of The Front Grille
CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 8.3.7. Insert the Air Filter. 8.3.8. Attach the Front Intake Grille. • Slide the Front Intake Grille slightly to the right to attach it, then push down to secure it. 8.4. Removal of the Front Grille. - Page 13 CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 8.5. Condensed Water Drainage. This air conditioner employs a “Slinger-Up System” which is designed to splash the condensed water on the condenser coil for maximum cooling efficiency, thus producing a splashing sound. If the splashing sound annoys you, you can provide an outside drainage by using the following procedure which may, however, cause a small loss of performance.
-
Page 14: Care And Maintenance
CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 9 Care and Maintenance Caution: Always turn off the air conditioner and the main power supply before unplugging the power cord to clean the unit. 9.1. Cleaning the Unit. 9.3. Cleaning the Air Filter. -
Page 15: Service Information
CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 10 Service Information 10.1. Removal of the Control Board 1. Remove the Front Intake Grille (refer to page 12). 2. Remove the Air Filter (refer to page 12). 3. Remove the Front Grille (refer to page 12). -
Page 16: Technical Data
CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 11 Technical Data 11.1. Thermostat Characteristics. 11.1.1. CW-C180EF-W, CW-C240EF, CW-C180EF-M & CW-SC180EF. 11.1.1.1. Mechanical Thermostat. 11.2. Operation Characteristics. 11.2.1. CW-C180EF-W, CW-C180EF-M & 11.2.2. CW-C240EF. CW-SC180EF. 11.2.2.1. Cooling Characteristics Vs. 11.2.1.1. Cooling Characteristics Vs. -
Page 17: Exploded View
CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 12 Exploded View (Note) • The above exploded view is for the purpose of parts disassembly and replacement. • The non-numbered parts are not kept as standard service parts. -
Page 18: Replacement Part List
CW-C180EF-W / CW-C240EF / CW-C180EF-M / CW-SC180EF 13 Replacement Part List Ref. No. Part Name & Description Qty. CW-C180EF-W CW-SC180EF CW-C180EF-M CW-C240EF Base Pan Complete CWD52K1021A <---- <---- CWD52K1024A Bulkhead Complete CWD531007 <---- <---- CWD53K1007 Air Guide - Propeller Fan CWD311010 <----...