Sharp PG-M15X Service Manual

Digital multimedia projector
Hide thumbs

Advertisement

Quick Links

In the interests of user-safety (Required by safety regulations in some countries) the set should be restored
to its original condition and only parts identical to those specified should be used.
Im lnteresse der Benutzersicherheit (erforderliche Sicherheitsregeln in einigen Ländern) muß das Gerät in seinen
Originalzustand gebracht werden. Außerdem dürfen für die spezifizierten Bauteile nur identische Teile verwendet
werden.
SHARP CORPORATION
SERVICE MANUAL
SERVICE-ANLEITUNG
DIGITAL MULTIMEDIA PROJECTOR
DIGITALER MULTIMEDIA PROJEKTOR
MODELS
MODELLE
This document has been published to be used for
after sales service only.
The contents are subject to change without notice.
1
PG-M15X
PG-M15S
AN-M15T
PG-M15X
PG-M15S
AN-M15T
S91A5PG-M15S/

Advertisement

loading

  Also See for Sharp PG-M15X

  Related Manuals for Sharp PG-M15X

  Summary of Contents for Sharp PG-M15X

  • Page 1 PG-M15X PG-M15S AN-M15T SERVICE MANUAL SERVICE-ANLEITUNG S91A5PG-M15S/ DIGITAL MULTIMEDIA PROJECTOR DIGITALER MULTIMEDIA PROJEKTOR PG-M15X PG-M15S MODELS AN-M15T MODELLE In the interests of user-safety (Required by safety regulations in some countries) the set should be restored to its original condition and only parts identical to those specified should be used.
  • Page 2: Table Of Contents

    PG-M15X PG-M15S AN-M15T CONTENTS Page Page » SPECIFICATIONS ..........3 » BLOCK DIAGRAM ........... 71 » IMPORTANT SERVICE SAFETY » SCHEMATIC DIAGRAM ........74 » PRINTED WIRING BOARD ASSEMBLIES ..99 NOTES (for USA) ..........4 » NOTE TO SERVICE PERSONNEL ....5 »...
  • Page 3: Specifications

    Soft carrying pouch (9HJ5383101001), Lens cap with strap (9HJ7083117001), CD-ROM (9HJ3683104001), Projector operation manual (9HJ3683107001), Projector quick reference guide (9HJ3683110001) This SHARP projector uses a DMD panel. This very sophisticated This unit has some inactive pixels within acceptable tolerances which panel contains 786,432 (PG-M15X)/480,000 (PG-M15S) pixels. As may result in inactive dots on the picture screen.
  • Page 4: Important Service Safety Notes (For Usa)

    PG-M15X PG-M15S AN-M15T IMPORTANT SERVICE SAFETY NOTES (for USA) Ë Service work should be performed only by qualified service technicians who are thoroughly familiar with all safety checks and servicing guidelines as follows: » Use an AC voltmeter with sensitivity of 5000 ohm WARNING per volt., or higher, sensitivity to measure the AC...
  • Page 5: Note To Service Personnel

    PG-M15X PG-M15S AN-M15T NOTE TO SERVICE NOTE POUR LE PERSONNEL PERSONNEL D’ENTRETIEN 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5...
  • Page 6: Lamp Replacement

    (Fig. 1). Note: Please obtain a lens cap before servicing a Remarque: Priére de se procurer un capuchon models PG-M15X/M15S that is received with- d'optique acant d'entretien un modéle out one. PG-M15X/M15S qui est livré sans.
  • Page 7 PG-M15X PG-M15S AN-M15T WARNING: High brightness light source, do not stare into the beam of light, or view directly. Be especially careful that children do not stare directly in to the beam of light. WARNING: TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK, DO NOT EXPOSE THIS UNIT TO MOISTURE OR WET LOCATIONS.
  • Page 8: Location Of Controls

    PG-M15X PG-M15S AN-M15T Location of Controls Projector Front and Top View MENU button INPUT/BACK button ON/OFF button AUTO SYNC/ENTER butto n KEYSTONE ( / )/ + – POWER indicator SELECT/ADJUST ('/") buttons LAMP REPLACEMENT indicator TEMPERATURE WARNING indicator Cooling fan (Exhaust vent)
  • Page 9: Operating The Wireless Mouse Remote Control

    PG-M15X PG-M15S AN-M15T Operating the Wireless Mouse Remote Control Remote Control Front View Rear View Mouse ('/")/ Remote control signal Adjustment ('/") transmitting window buttons Remote control signal LEFT-CLICK/ transmitter indicator Mouse ( |) button BACK button (Flashes when remote...
  • Page 10: Connection Pin Assignments

    PG-M15X PG-M15S AN-M15T Connection Pin Assignments DVI INPUT 1 Port: 29-pin DVI input RGB input Pin No. Name Pin No. Name T.M.D.S. Data 2 Not connected C4 C3 T.M.D.S. Data 2 Not connected T.M.D.S. Data 2/4 Shield Not connected T.M.D.S. Data 4 * Not connected T.M.D.S.
  • Page 11 PG-M15X PG-M15S AN-M15T OUTPUT (INPUT 1) Signal Port: 15-pin Mini D-sub female connector COMPONENT output RGB output Analog Analog 1 Video output (red) 2 Video output (green/sync on green) 4 Not connected 3 Video output (blue) 5 Not connected 4 Not connected...
  • Page 12 PG-M15X PG-M15S AN-M15T Dimensions Rear View Top View Side View (225) Front View (76.5) Bottom View (153) Units: inches (mm)
  • Page 13: Removing Of Major Parts

    PG-M15X PG-M15S AN-M15T REMOVING OF MAJOR PARTS Tools required 1. Philips screw driver (Size : 1, 2) 2. Nut driver (2.5mm) 3. Ball end hexagonal driver (5.0mm) 1. Disassemble Top Cover Module, Main PWB Unit and DC to DC PWB Unit 1-1.
  • Page 14 PG-M15X PG-M15S AN-M15T 1-2. Lift up Top Cover and unplug two wires connected to IR PWB Unit and Main Unit. (Refer to Step 3~5.) 1-3. Remove Top Cover. 1-4. Remove one screw to take off IR PWB Unit and IR PWB Unit Cover.
  • Page 15 PG-M15X PG-M15S AN-M15T 2. Disassemble Optical Engine Module 2-1. Remove 4 screws from main PWB unit. 2-2. Using a ball end hexagonal driver, loosen 2 screws holding terminal sheet holder. (approx. 4 rotation)(Step 8.) 2-3. Place a tool in between main PWB unit and formatter PWB unit and disconnect the connector. (Step 9.) 2-4.
  • Page 16 PG-M15X PG-M15S AN-M15T 2-5. Remove one screw of DC to DC PWB Unit Holder, unplug three Connecting Cords, and then detach DC to DC PWB Unit. (Step 12,13.) 2-6. Remove push bar, push bar spring, and rubber. (refer to step 14~16.)
  • Page 17 PG-M15X PG-M15S AN-M15T 2-7. Unplug six wires of Thermal PWB Unit. (Step 17.) 2-8. Remove 5 screws from optical engine module (Step 18~20.) 2-9. Remove 2 screws from projection lens cover. (Step 21.) 2-10. Remove optical engine module, projection lens cover, and Thermal Unit. (Step 22, 23.)
  • Page 18 PG-M15X PG-M15S AN-M15T Projection Lens Cover Speaker Thermal PWB Unit Optical Engine Module DMD Off-Light Vent Push Bar Spring Pudh Bar Leakage Rubber...
  • Page 19 PG-M15X PG-M15S AN-M15T 3. Disassemble Ballast PWB unit 3-1. Remove two screws and detach Terminal Sheet Holder. 3-2. Remove two screws and detach Grounding Sheet. 3-3. Remove two screws and detach AC Code Fix. 3-4. Remove two screws and detach ignitor cable from Lamp Housing.
  • Page 20 PG-M15X PG-M15S AN-M15T 4. Disassemble Lamp Housing 4-1. Loosen two screws and remove Lamp Cover. 4-2. Loosen three screws and lift Lamp. 4-3. Remove screw and detach Output Air Guide and Output Rubber duct. 4-4. Remove three screws and detach Lamp Housing.
  • Page 21 PG-M15X PG-M15S AN-M15T 4-8. Remove screw and detach SW PWB unit and Interlock Protection Cover. 4-9. Remove screw and detach Thermal Switch. Interlock Protection Cover Thermal SW PWB unit Switch 70° Bottom Cover...
  • Page 22: Disassemble Fan Module

    PG-M15X PG-M15S AN-M15T 5. Disassemble Fan Module 5-1. Remove two Hexagon Copper Sticker and detach Assy Fan. 5-2. Remove two screws and detach Exhaust Window Assy. 5-3. Remove two screws and detach Fan and Rubber. Fan Ass'y Exhaust Window Hexagon Copper Sticker...
  • Page 23: Resetting The Total Lamp Timer

    WARNING temperature is ventilation. indicator abnormally high. • Cooling fan breakdown. • Take the projector to your nearest Sharp • Internal circuit failure. Authorized Projector Dealer or Service Center for repair. The indicator flashes in • Cooling down. • Wait until the indicator stops flashing and red.
  • Page 24: Turn Off The Power

    If you wish, you may have the lamp the projector will enter standby mode. over 1,500 hours. replaced at your nearest Sharp Authorized “LAMP” will appear in red in the lower-left Projector Dealer or Service Center. corner of the picture, and the power will turn off.
  • Page 25: Optical Adjustment And Measuring

    PG-M15X PG-M15S AN-M15T OPTICAL ADJUSTMENT AND MEASURING 1. Adjustment of Color Wheel Sensor » Adjustment needed 1. When the color wheel unit has been replaced. 2. When the color wheel sensor has been replaced. 3. When the optical drive unit has been replaced (If a deviation from normal setting is found).
  • Page 26: Color Wheel Index Adjustment

    PG-M15X PG-M15S AN-M15T 2. Color Wheel Index Adjustment Choose R.G.B.W 4-color image. 3. Choose "Color Wheel Index" to do adjustment. 1-1. Execute the “M15 Pattern dmw” command. 1-2. Click on “Color and Gray Scale”. 1-3. Left-click on the mouse to switch the pattern and to provide the “R.G.B.W 4-color Image”...
  • Page 27 PG-M15X PG-M15S AN-M15T 3. DMD Type Setting Sop 1. Record type of DMD chip (An English letter in 3. Choose "DMD Bin" to do setting. capital) before assembly. Select “DMD” on the process mode screen. 2-1. Turn on the power. Press the ON/OFF button on the projector or the POWER button on the remote controller.
  • Page 28: The Optical Unit Outline

    PG-M15X PG-M15S AN-M15T THE OPTICAL UNIT OUTLINE <Conceptual Drawing> Condenser Lens 2 Lamp Projection Zoom Lens Condenser UV-IR Filter Lens 1 Rod Lens DMD Chip Reflection Mirror Color Wheel 1. OSRAM Elliptical Reflector Kind of 6. Condenser Lens 2 HID Lamp 130W 7.
  • Page 29 PG-M15X PG-M15S AN-M15T Æ Precautions in disassembling the optical mechanism Note: If the optical mechanism needs repairs, preferably replace the entire optical mechanism assembly with new one. This is because to very fine adjustments are needed for some parts. Condenser lens 1 and 2...
  • Page 30: Trouble Shooting Table

    PG-M15X PG-M15S AN-M15T TROUBLE SHOOTING TABLE 1. Equipment Needed » PG-M15X/S » VGA Cable, Power Cord » PC (Personal Computer) » Audio Input, Video Input » Screw Driver 2. Main Procedure Start Connect AC cord, VGA cable and audio signal, then turn...
  • Page 31 PG-M15X PG-M15S AN-M15T 2-1. A. Power Troubleshooting Start Check AC cord and Is LED indicator Lamp assembly Reassembly input power voltage lamp Supply Change AC Cord DC to DC PWB unit Main PWB unit Troubleshooting Change Is Lamp OK? Lamp unit...
  • Page 32 PG-M15X PG-M15S AN-M15T 2-2. B. Performance Troubleshooting Start Main PWB unit Change Have image? Troubleshooting DMD Module Have garbage Change Main PWB unit pattern? DMD Module Troubleshooting (White Screen) Change Uniformity OK? Optical Engine Module Change Main PWB unit Change...
  • Page 33 PG-M15X PG-M15S AN-M15T 2-2-1. White Screen or Garbage Pattern Start Check JP1 H, V SYNC in Check U9 GH, GV SYNC Check U17 Pin (5) DCLK Check U16 Pin (5) MCLK 2-2-2. Color abnormal (VGA) Start Check JP1 Pins (25), (26) and...
  • Page 34 PG-M15X PG-M15S AN-M15T 2-3. C. Function Troubleshooting Start Main PWB unit Is Remote Does OSD Is SW PWB unit Troubleshooting Controller OK? show up? Change Change SW PWB unit battery Main PWB unit Can function Change Troubleshooting be adjusted? Remote Controller 2-4.
  • Page 35 PG-M15X PG-M15S AN-M15T 3. Main PWB unit Troubleshooting » » » » » Condition-1. PC Source Check VGAIN-R/G/B, HSYNCIN, VSYNCIN PATH Change AD9886 Check U9 AD9886 Check U11 PW164 Change PW164 DMD PWB unit » » » » » Condition-2.
  • Page 36 PG-M15X PG-M15S AN-M15T » » » » » Condition-3. Component-i Source Check Cr/Pr, YIN, Cb/Pb PATH Change LT1399 Check U2 LT1399 Check U24 VPC3230 Change VPC3230 Check U11 PW164 Change PW164 DMD PWB unit » » » » » Condition-4.
  • Page 37 PG-M15X PG-M15S AN-M15T » » » » » Condition-5. PC Source Output Check U3 LT1399 Change LT1399 MONITOR DISPLAY » » » » » Condition-6. AUDIO Source Check U22 LM4832 Change LM4832 Check U23 LM4871 Change LM4871 SPEAKER OUTPUT » » » » » Condition-7.
  • Page 38: Gesamtschaltplan

    PG-M15X PG-M15S AN-M15T OVERALL WIRING DIAGRM / GESAMTSCHALTPLAN...
  • Page 39 PG-M15X PG-M15S AN-M15T BLOCK DIAGRAM-1 / BLOCKSCHALTBILD-1 Ë MAIN Unit / HAUPT-Einheit PW_RX D PW_TXD RS232 AUDIO COMP S-Video D USB15...
  • Page 40 PG-M15X PG-M15S AN-M15T BLOCK DIAGRAM-2 / BLOCKSCHALTBILD-2 (PG-M15X) Ë FORMATTER Unit / FORMATIERER-Einheit...
  • Page 41 PG-M15X PG-M15S AN-M15T BLOCK DIAGRAM-2 / BLOCKSCHALTBILD-2 (PG-M15S) Ë FORMATTER Unit / FORMATIERER-Einheit...
  • Page 42 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-1/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-1/16 Ë DIGITAL INPUT CONNECTOR / DIGITAL-EINGANGSANSCHLUSS...
  • Page 43 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-2/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-2/16 Ë VGA OUTPUT CONNECTOR / VGA-AUSGANGSANSCHLUSS...
  • Page 44 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-3/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-3/16 Ë U7 (SII151A)
  • Page 45 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-4/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-4/16 Ë U9 (AD9886)
  • Page 46 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-5/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-5/16 Ë U11 (PW164-1) GAPHICS and VIDEO PORT / GRAFIK- UND VIDEO-SCHNITTSTELLE...
  • Page 47 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-6/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-6/16 Ë U11 (PW164-2) MICROPROCESSOR / MIKROPROZESSOR...
  • Page 48 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-7/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-7/16 Ë U11 (PW164-3) DISPLAY PORT / DISPLAY-SCHNITTSTELLE...
  • Page 49 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-8/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-8/16 Ë RESET and CLOCK GENERATOR / NULLSTELLUNGS- UND TAKTGEBER...
  • Page 50 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-9/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-9/16 Ë FLASH MEMORY / FLASH-SPEICHER...
  • Page 51 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-10/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-10/16 Ë 100 PIN INTERFACE / SCHNITTSTELLE (100POLIG)
  • Page 52 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-11/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-11/16 Ë AUDIO / AUDIO...
  • Page 53 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-12/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-12/16 Ë VIDEO INPUT / VIDEO EINGANG...
  • Page 54 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-13/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-13/16 Ë VIDEO DECODER / BILDDECODIERER...
  • Page 55 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-14/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-14/16 Ë RS232...
  • Page 56 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-15/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-15/16 Ë SUB-MICRON / SUB-MIKRON...
  • Page 57 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: MAIN Unit-16/16 / SCHEMATISCHEN SCHALTPLANS: HAUPT-Einheit-16/16 Ë KEYPAD CONTROL / TASTATURSTEUERUNG...
  • Page 58 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: THERMAL Unit-1/7 / SCHEMATISCHEN SCHALTPLANS: THERMO-Einheit-1/7 Ë CONNECTOR INTERFACE / STECKERSCHNITTSTELLE...
  • Page 59 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: THERMAL Unit-2/7 / SCHEMATISCHEN SCHALTPLANS: THERMO-Einheit-2/7 Ë FAN FEEDBACK DETECT / GEBLÄSE-RÜCKFÜHRUNGSERKENNUNG...
  • Page 60 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: THERMAL Unit-3/7 / SCHEMATISCHEN SCHALTPLANS: THERMO-Einheit-3/7 Ë COLOR WHEEL and LAMP CONTROL / FARBSCHEIBEN- UND LAMPENREGELUNG...
  • Page 61 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: THERMAL Unit-4/7 / SCHEMATISCHEN SCHALTPLANS: THERMO-Einheit-4/7 Ë SYSTEM MAIN POWER CONTROL / SYSTEM-HAUPSTROMSTEUERUNG...
  • Page 62 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: THERMAL Unit-5/7 / SCHEMATISCHEN SCHALTPLANS: THERMO-Einheit-5/7 Ë FAN POWER CONTROL / GEBLÄSESTROMREGELUNG...
  • Page 63 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: THERMAL Unit-6/7 / SCHEMATISCHEN SCHALTPLANS: THERMO-Einheit-6/7 Ë POWER GOOD FOR FORMATTER UNI / Ë STROMKREISLAUF FÜR FORMATIEREREINHEIT...
  • Page 64 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: THERMAL Unit-7/7 / SCHEMATISCHEN SCHALTPLANS: THERMO-Einheit-7/7 Ë THERMAL BOARD CONNECTOR INTERFACE / Ë THERMOPLATINEN-ANSCHLUSSSCHNITTSTELLE...
  • Page 65 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: IR Unit / SCHEMATISCHEN SCHALTPLANS: IR-Einheit...
  • Page 66 PG-M15X PG-M15S AN-M15T SCHEMATIC DIAGRAM: SW Unit / SCHEMATISCHEN SCHALTPLANS: SCHALTER-Einheit...
  • Page 67: Printed Wiring Board Assemblies

    PG-M15X PG-M15S AN-M15T PRINTED WIRING BOARD ASSEMBLIES / LEITERPLATTENINHEITIN Main Unit (Wiring Side) / Main Unit (Component Side) / Haupteinheit (Leiterbahnseite) Haupteinheit (Bestückungsseite)
  • Page 68 PG-M15X PG-M15S AN-M15T Thermal Unit (Wiring Side)/ Thermoeinheit (Leiterbahnseite) Thermal Unit (Component Side)/ Thermoeinheit (Bestückungsseite) IR Unit (Component Side)/ SW Unit (Component Side)/ IR-Einheit (Bestückungsseite) Schaltereinheit (Bestückungsseite)
  • Page 69: Parts List

    6. QUANTITY in USA: Contact your nearest SHARP Parts Distributor. For location of SHARP Parts Distributor, Please call Toll-Free; 1-800-BE-SHARP in CANADA: Contact SHARP Electronics of Canada Limited Phone (416) 890-2100. MARK: SPARE PARTS-DELIVERY SECTION MARKIERUNG : ERSATZTEILE-LIEFERUNG Ref. No.
  • Page 70 PG-M15X PG-M15S AN-M15T Ref. No. Part No. Description Code Ref. No. Part No. Description Code 9HJ7083204001 (PG-M15X) 9HJ09DA221001 J Diode, DA221 9HJ7083114001 (PG-M15S) 9HJ09DA221001 J Diode, DA221 9HJ09DA221001 J Diode, DA221 MAIN UNIT (Continued) 9HJ09DA221001 J Diode, DA221 9HJ20AHCT1401 J 74AHCT14...
  • Page 71 PG-M15X PG-M15S AN-M15T Ref. No. Part No. Description Code Ref. No. Part No. Description Code 9HJ7083204001 (PG-M15X) 9HJ0222447101 J 22p Ceramic 9HJ7083114001 (PG-M15S) 9HJ0222447101 J 22p Ceramic 9HJ0222447101 J 22p Ceramic MAIN UNIT (Continued) 9HJ0210074502 J 10 Tantalum BC26 9HJ0210887101 J 0.1...
  • Page 72 PG-M15S AN-M15T Ref. No. Part No. Description Code Ref. No. Part No. Description Code 9HJ7083204001 (PG-M15X) 9HJ0110336502 J 10k 1/16W Chip 0603 9HJ7083114001 (PG-M15S) 9HJ0110336502 J 10k 1/16W Chip 0603 9HJ0110336502 J 10k 1/16W Chip 0603 MAIN UNIT (Continued) 9HJ0120236501...
  • Page 73 PG-M15X PG-M15S AN-M15T Ref. No. Part No. Description Code Ref. No. Part No. Description Code 9HJ7083204001 (PG-M15X) R191 9HJ0133134501 J 330 1/4W Chip 1206 9HJ7083114001 (PG-M15S) R192 9HJ0139134501 J 390 1/4W Chip 1206 R193 9HJ0139134501 J 390 1/4W Chip 1206...
  • Page 74 PG-M15X PG-M15S AN-M15T Ref. No. Part No. Description Code Ref. No. Part No. Description Code 9HJ8083102001 9HJ0210070901 J 10 Tantalum 9HJ0210070901 J 10 Tantalum THERMAL UNIT 9HJ0210747101 J 0.01 Ceramic INTEGRATED CIRCUITS RESISTORS 9HJ20LM393002 J LM393 9HJ0133236501 J 3.3k 1/16W Chip 0603...
  • Page 75 PG-M15X PG-M15S AN-M15T Ref. No. Part No. Description Code Ref. No. Part No. Description Code 9HJ8083102001 THERMAL UNIT (Continued) 9HJ0110310001 J Thermistor, 10k TH20-3H103FT 9HJ0110310001 J Thermistor, 10k TH20-3H103FT MISCELLANEOUS PARTS 9HJ11039M2304 J Jack, 3-pin 9HJ11039N2302 J Jack, 3-pin 9HJ11029M2302...
  • Page 76: Cabinet And Mechanical Parts

    9HJ5183142002 J Fuse Cover (PG-M15S) 9HJ7083126001 J Top Cover Module Refer to Optical Engine Mechanical Parts (PG-M15X) 9HJ6183116031 J ID Top Cover (PG-M15X) å BQC-PGM15X//1 J Lamp Full Ass’y 9HJ6183116021 J ID Top Cover (PG-M15S) 9HJ4283106001 J Extension Cable 3-pin 9HJ3583101001 J Badge, "SHARP"...
  • Page 77 PG-M15X PG-M15S AN-M15T CABINET AND MECHANICAL PARTS / GEHÄUSE UND MECHANISCHE BAUTEILE 1-12 1-11 1-10 1-14 1-17 1-16 1-13 1-15 2-22 2-28 2-24 2-25 2-27 2-26 2-30 2-23 2-15 2-19 2-13 2-17 2-29 2-18 2-11 2-16 2-12 2-29 2-14 2-20...
  • Page 78 Ref. No. Part No. Description Code CABINET AND MECHANICAL PARTS (Continued) 9HJ8083101001 J Formatter Unit (PG-M15S) CQ 9HJ8083201001 J Formatter Unit (PG-M15X) CR 9HJ6183108001 J Angle (Thermal Unit) 9HJ851A320050 J Screw M2x5 9HJ8083102001 – Thermal Unit — 9HJ5183144001 J Main Unit Connector Cover AF 9HJ7083204001 –...
  • Page 79 PG-M15X PG-M15S AN-M15T Ref. No. Part No. Description Code Ref. No. Part No. Description Code 9HJ7083130001 J Condenser Lens Cover OPTICAL ENGINE MECHANICAL PARTS 9HJ5183140001 J Insulating Cover 6-11 9HJ5283103001 J Spacer for Project Lens 6-16 9HJ5283120001 J Spacer 9HJ7083120001...
  • Page 80: Ë Packing Parts

    Ref. No. Part No. Description Code PACKING PARTS SUPPLIED ACCESSORIES (NOT REPLACEMENT ITEM) 9HJ3683101001 J Warranty Card (U.S) 9HJ5583112001 – Packing Case (PG-M15X) — 9HJ3683102001 J Warranty Card (Australia) 9HJ5583110001 – Packing Case (PG-M15S) — 9HJ3683104001 J CD-ROM 9HJ5683111001 – Polystyrene Cover —...
  • Page 81: Packing Of The Set

    PG-M15X PG-M15S AN-M15T PACKING OF THE SET / VERPACKEN DES GERÄTS Warranty Card (9HJ3683101001)(U.S) (9HJ3683118001)(Canada) (9HJ3683102001)(Australia) CD-ROM (9HJ3683104001)(U.S, Canada) Projector operation manual (9HJ3683107001)(U.S, Canada) Projector quick reference guide (9HJ3683110001) Canadian Paper O/M Requested Sheet (9HJ3683115001)(U.S, Cnada) Express Repair Package (9HJ3683116001)(U.S)
  • Page 82: An-M15T

    6. QUANTITY in USA: Contact your nearest SHARP Parts Distributor. For location of SHARP Parts Distributor, Please call Toll-Free; 1-800-BE-SHARP in CANADA: Contact SHARP Electronics of Canada Limited Phone (416) 890-2100. MARK: SPARE PARTS-DELIVERY SECTION MARKIERUNG : ERSATZTEILE-LIEFERUNG Ref. No.
  • Page 83: Verpacken Des Geräts

    PG-M15X PG-M15S AN-M15T PACKING OF THE SET / VERPACKEN DES GERÄTS Mirror Mat (9AQAN-M15T-09) Operation Manual (9AQAN-M15T-11) Polystyrene Bage (9AQAN-15AG2-08) Pad (Bottom) (9AQAN-M15T-06) Screw M6x16 (9AQAN-M15T-03) Screw M3x8 (9AQAN-NV4T-14) Polystyrene Bage (9AQAN-NV4T-16) Pad (Top) (9AQAN-M15T-08) Pad (Base) (9AQAN-M15T-07) Packing Case...
  • Page 84 PG-M15X PG-M15S AN-M15T COPYRIGHT © 2001 BY SHARP CORPORATION ALL RIGHTS RESERVED. No part of this publication may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, without prior written permission of the publisher.

This manual is also suitable for:

Pg-m15sAn-m15t