Summary of Contents for WILDWOOD OVENS &BBQ’S TOSCANO
Page 1
TOSCANO OVEN INSTALLATION INSTRUCTIONS 4.0 WILDWOOD OVENS &BBQ’S 5020 EAGLE ROCK BLVD. LOS ANGELES, CA 90041 TEL. 323-255-6578 FAX. 323-306-5689 www.wildwoodovens.com info@wildwoodovens.com SAVE THESE INSTRUCTIONS! READ ALL INSTUCTIONS BEFORE INSTALLING AND USING THE APPLIANCE. WHEN THIS OVEN IS NOT PROPERLY INSTALLED, A FIRE MAY RESULT. TO REDUCE THE RISK OF FIRE, FOLLOW THE INSTRUCTIONS.
TABLE OF CONTENTS MILANO Oven Kit Parts List Oven Base and Enclosure Material List Minimum Clearances Safety Plaque Information Minimum Footprint Requirements Wood-Fired Oven Operating Tips Wood-Fired Oven Maintenance Tips Pre-Construction Checklist Building Foundation and Base Oven Assembly Instructions Roofing and Finishing the Exterior Chimney Assembly Curing the Oven Cooking Pizza in the Oven...
Be sure to place orders early for any items that are necessary to complete your project. It is best to have everything you need prior to beginning construction. TOSCANO OVEN KIT PARTS LIST 2-Pre-cast hearth sections 4-Pre-cast dome sections...
Toscano Wood Fired Oven Installation Instructions Version 4.0 OVEN BASE AND ENCLOSURE MATERIAL LIST The following list is provided for your convenience only; the materials are not part of the oven kit. List may vary depending on construction method. MASONARY CONSTRUCTION METHOD FOUNDATION AND SLAB ...
Toscano Wood Fired Oven Installation Instructions Version 4.0 MINIMUM CLEARANCES Please refer to the Minimum Clearance Diagram below. 1. Build your oven in such an area where smoke will not infiltrate your home or homes close to you. The minimum clearance from combustibles is 30 inches (762 mm) to each side of the door opening, and 36 inches (914 mm) in front of the door opening.
Toscano Wood Fired Oven Installation Instructions Version 4.0 SAFETY PLAQUE INFORMATION NOTE: Diagram above shows recommendations for the location of SAFETY INFORMATION PLAQUE on finished oven. Oven designs and finishes vary; therefore one or more of the options may not apply. Locate plaque where visible and do not remove.
Toscano Wood Fired Oven Installation Instructions Version 4.0 WOOD-FIRED OVEN OPERATING TIPS WARNING-KEEP THESE INSTRUCTIONS FOR FUTURE REFERENCE WOOD-FIRED OVEN IS INTENDED FOR OPERATION BY TRAINED AND QUALIFIED PERSONNEL ONLY. INQUIRE ABOUT OUR OVEN OPERATION/COOKING CLASSES AT WILDWOOD! THIS OVEN IS A HIGH HEAT PRODUCING APPLIANCE AND MAY CAUSE SEVERE BURNS IF TOUCHED DURING OPERATION.
Page 8
Toscano Wood Fired Oven Installation Instructions Version 4.0 USE ONLY SEASONED OR DRIED, UNTREATED WOOD IN THE OVEN. DO NOT BURN CHARCOALS, COALS, TRASH/GARBAGE OR MANUFACTURED LOGS (PROCESSED SOLID FUEL). STORE WOOD IN A DRY PLACE PROTECTED FROM THE ELEMENTS.
Toscano Wood Fired Oven Installation Instructions Version 4.0 WOOD-FIRED OVEN MAINTENANCE TIPS READ AND FOLLOW INSTRUCTIONS CAREFULLY. FOLLOW THE COMBUSTIBLE CLEARANCE REQUIREMENTS AND MAKE SURE TO KEEP THE AREA AROUND OVEN CLEAN AND CLEAR. WHEN WOOD IS STORED BELOW THE OVEN UNIT, IT SHALL NOT BE STORED WITHIN 3 INCHES OF HEAT STOPPER BOARD.
Toscano Wood Fired Oven Installation Instructions Version 4.0 PRE CONSTRUCTION CHECKLIST Order oven kit Order chimney system Order additional construction materials Order finish materials OVEN ASSEMBLY CHECKLIST Mark an outline on the floor of the desired oven location to ensure an adequate fit...
Toscano Wood Fired Oven Installation Instructions Version 4.0 BUILDING FOUNDATION AND BASE Refer to FIG. 1 MASONARY ENCLOSURE 1. Dig a 56” wide by 60” deep trench to a depth of at least 12 inches. Set forms around the perimeter using 2x4 or 2x6 boards held by stakes.
Toscano Wood Fired Oven Installation Instructions Version 4.0 OVEN ASSEMBLY Dry assemble the oven at a convenient location to ensure a proper fit. Assemble the oven sections sequentially. Refer to the illustration to the right. Place the hearth section(1) at the desired location on top of the 1”...
Page 14
Toscano Wood Fired Oven Installation Instructions Version 4.0 Set dome section(3) in place; apply the fireplace mortar to the applicable outer edge of hearth generously. Apply mortar to the hearth and all sides of the overlapping joint between section (3) & (4).
Page 15
Toscano Wood Fired Oven Installation Instructions Version 4.0 After the chimney has been attached, allow mortar on oven/chimney to dry, following the instructions on the label. Upon drying, fire up the oven to cure mortar. The oven should be heated up to 350 degrees F.
Page 16
Toscano Wood Fired Oven Installation Instructions Version 4.0 Secure the fiber blanket insulation using the diamond lath mesh. Wrap the mesh around the oven as done previously with the insulation. Tie mesh together using wire to tie the cut seams. Refer to illustrations below.
Toscano Wood Fired Oven Installation Instructions Version 4.0 ROOFING AND FINISHING THE EXTERIOR Roof your project using non-flammable roofing materials conforming to local building codes. Finish the oven in the desired style or contact the designer at Wildwood for consultation.
Page 18
Toscano Wood Fired Oven Installation Instructions Version 4.0 The oven shall only be installed with exhaust hoods constructed in accordance with NFPA 96 or LISTED building heating appliance chimneys also LISTED as grease ducts. For specific installation requirements refer to Mechanical Sales and Grease Duct Installation Instructions or Metal-Fab IPIC Installation Instructions.
Page 19
Toscano Wood Fired Oven Installation Instructions Version 4.0 FOR COMMERCIAL APPLICATIONS ONLY If required, a Type 1 hood must be placed above the cooking opening and set on the top of the oven. The grease filters must be positioned at the rear of the exhaust hood and must be of the steel baffle type (Mesh type grease filters must not be used).
Toscano Wood Fired Oven Installation Instructions Version 4.0 CURING THE OVEN Note: In cold or humid climates it is recommended that the minimal curing period be extended to ensure completion. Initial firing procedures The oven must be cured so as to remove moisture that has accumulated during the installation.
Toscano Wood Fired Oven Installation Instructions Version 4.0 USING YOUR OVEN Always •Allow 1-2 hours to bring your oven to temperature slowly. •Add firewood in intervals (not all at once). •Add wood of similar size. •Keep oven door on when not in use.