Page 1
CDX-C90 3 7 63 1515 0 SERVICE MANUAL US Model E Model Model Name Using Similar Mechanism CDX-C680/C780 SPECIFICATIONS CD Drive Mechanism Type MG-363S-121 Optical Pick-up Name KSS-520A AUDIO POWER SPECIFICATIONS (US model) POWER OUTPUT AND TOTAL HARMONIC DISTORTION...
Page 2
COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
http://www.xiaoyu163.com 3 7 63 1515 0 2-5. MD ASSY 7 MD assy 5 CN101 3 PTT 2.6x4 1 Slide the base panel in the direction of the arrow. 6 CN3 4 CN1 2 PTT 2.6x4 L 13942296513 2-6. AUDIO BOARD 2 BVTT 2x4 3 AUDIO board 1 BVTT 2x4...
http://www.xiaoyu163.com 3 7 63 1515 0 2-17. CHASSIS (OP) (O/S) ASSY 6 chassis (OP) (O/S) assy 8 compression spring (FL) 1 tension spring (angle) 7 compression spring (FL) 4 Fit lever (D) in the direction of the arrow. 5 Turn loading ring in the direction of the arrow.
http://www.xiaoyu163.com SECTION 3 ELECTRICAL ADJUSTMENTS 3 7 63 1515 0 CD SECTION FM Auto Scan/Stop Level Adjustment Setting : CD section adjustments are done automatically in this set. SOURCE button : FM 0 dB = 1 µV TUNER SECTION FM RF signal Cautions during repair generator When the tuner unit is defective, replace it by a new one...
Page 45
http://www.xiaoyu163.com 3 7 63 1515 0 FM Stereo Separation Adjustment (WIDE) FM Stereo Separation Adjustment (NARROW) Setting : Setting : SOURCE button : FM SOURCE button : FM FM RF signal FM RF signal generator generator level meter level meter antenna antenna terminal...
Page 46
http://www.xiaoyu163.com 3 7 63 1515 0 AM Auto Scan/Stop Level Adjustment Adjustment Location : tuner unit (TU701) Setting : SOURCE n MODE button : AM –set upper view– 30 Ω 15 pF 65 pF AM RF signal generator AM dummy antenna (50 Ω...
http://www.xiaoyu163.com SECTION 4 DIAGRAMS 3 7 63 1515 0 4-1. IC PIN DESCRIPTIONS • IC5 CXP84640-011Q (CD SYSTEM CONTROL) Pin No. Pin Name Pin Description 1 – 5 — Not used in this set. FP OPEN Front panel open detection input FP CLOSE Front panel close control output LINKOFF...
Page 48
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Pin Description BU.IN Back-up power detection input BUSON Bus on control input IN SW Disc in switch input (SW1) SELF SW Self switch input (SW2) TX CE EEPROM chip enable output SCK2 Sub Q read clock output Sub Q 80 bit, PCM peak and level data 16 bit input...
Page 49
http://www.xiaoyu163.com 3 7 63 1515 0 • IC501 CXD2548R (DIGITAL SERVO, DIGITAL SIGNAL PROCESSOR) Pin No. Pin Name Pin Description SYSM System mute input (Not used.) RMUT1 R-ch, “0” detection output. (“H” : ON, “L” : OFF) (Not used.) LMUT2 L-ch, “0”...
Page 50
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Pin Description ASY.O EFM full-swing output (“L” : VSS, “H” : VDD) Center voltage input Focus error signal input Sled error signal input Tracking error signal input Center error signal input RFDC RF signal input Condenser connection pin for LPF time constant of RF signal.
Page 51
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Pin Description ROUT2 R-ch, LINE output. (Not used.) AIN2 R-ch, OP amplifier input. (Not used.) AOUT2 R-ch, Analog output. (Not used.) AVDD2 — R-ch, Analog power supply. AVSS2 — R-ch, Analog GND. VSS0 —...
Page 52
http://www.xiaoyu163.com 3 7 63 1515 0 • IC300 MB90F574PFV-G-139-BND (SYSTEM CONTROL) Pin No. Pin Name Pin Description TIR WR TIR IC data write output (Not used in this set.) TIR RD TIR IC data read output (Not used in this set.) TIR CE TIR IC data chip enable output (Not used in this set.) TIR CE...
Page 53
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Pin Description — Power supply pin (+5 V) RAMBU RAM reset detection input TESTIN Test mode setting detection input AD ON Power control output of A/D conversion. 58, 59 RE IN0, 1 Rotary encoder input 0, 1 BOOT Compulsory boot mode input...
Page 54
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Pin Description SEEKOUT SEEK OUT output AM STIN AM stereo input (Not used in this set.) FM STIN Used in conjunction with stereo input/monaural output (FM mode) SD IN Signal detector input TU ATT Tuner mute output (Not used in this set.) TIR D0...
Page 55
http://www.xiaoyu163.com 3 7 63 1515 0 • IC500 HD6413002F16 (DISPLAY CONTROL) Pin No. Pin Name Pin Description — Power supply pin (+5 V) SIRCS Remote commander input SIRCS Remote commander input LCD-RST LCD controller reset control output ILL ON LCD controller power supply control output EL ON LCD back light EL power supply control output LCD-ST...
Page 56
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Pin Description DEC-INT Demodulator LSI initial output (Not used in this set.) ROM-CS PROM chip enable output — UNI-REQ Not used. LINK-OFF BUS interface link output DEC-ON Not used. DEC-CLR Demodulator LSI reset output (Not used in this set.) 97 –...
Page 63
http://www.xiaoyu163.com 3 7 63 1515 0 IC4 MB814400C-70PFTN (SERVO BOARD) IC601 BA6195FP-YT2 25 24 23 22 21 16 15 THERMAL SHUT DOWN WRITE DRIVER DATA INPUT DATA OUTPUT CLOCK MUTE BUFFER BUFFER GENERATOR LEVEL SHIFT – – – CLOCK GENERATOR 4M BIT COLUMN SENSE AMP...
Page 64
http://www.xiaoyu163.com 3 7 63 1515 0 IC1 CXD8679Q (MAIN BOARD) TIMING CIRCUIT IF SELD S / P INAF "0" DETECT IF SELC OVFLAG MUTE CIRCUIT MUTER MUTEL SBCKI MODE 4BIT DATA 3rd order L . I . P. NOISE SDATAR MTPOL SHAPER BITSTREAM...
Page 65
http://www.xiaoyu163.com 3 7 63 1515 0 IC102 CXA1946BR IC302 BA8270F-E2 BUS ON BUS ON SWITCH 35 34 30 29 28 27 26 RESET SWITCH 24 FNTO1 VOLUME VOLUME BUS ON LOUD TONE FADER 8dB STEP 1dB STEP 23 REO1 CLK IN BATTERY BATT BU IN...
http://www.xiaoyu163.com SECTION 5 EXPLODED VIEWS 3 7 63 1515 0 NOTE: • The mechanical parts with no reference • Color Indication of Appearance Parts The components identified by number in the exploded views are not supplied. Example : mark ! or dotted line with mark. •...
http://www.xiaoyu163.com 3 7 63 1515 0 5-6. CD MECHANISM SECTION (3) (MG-363S-121) M901 M902 L 13942296513 The components identified by mark ! or dotted line with mark. ! are critical for safety. Replace only with part number specified. Ref. No. Part No.
http://www.xiaoyu163.com SECTION 6 AUDIO ELECTRICAL PARTS LIST 3 7 63 1515 0 NOTE: • Due to standardization, replacements in • Items marked “*” are not stocked since The components identified by the parts list may be different from the they are seldom required for routine service. mark ! or dotted line with mark.
Page 74
http://www.xiaoyu163.com AUDIO DISC IN SW 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < TRANSISTOR > R146 1-260-008-11 CARBON MELF 1/8W R147 1-216-033-00 METAL CHIP 1/10W Q101 8-729-921-25 TRANSISTOR FMC2 R148 1-216-033-00 METAL CHIP 1/10W Q102...
Page 75
http://www.xiaoyu163.com MAIN LOAD SW LIMIT SW 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < DIODE > A-3313-956-A MAIN BOARD, COMPLETE (US) A-3317-107-A MAIN BOARD, COMPLETE (E) D550 8-719-978-24 DIODE DTZ-TT11-5.6A ********************* D551 8-719-977-21 DIODE DTZ8.2C...
Page 82
http://www.xiaoyu163.com SERVO 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C107 1-115-581-11 TANTAL. CHIP 100uF 8-752-374-12 IC CXD2522R-T6 C108 1-164-004-11 CERAMIC CHIP 0.1uF 8-759-427-15 IC MB814400C-70PFTN C109 1-115-581-11 TANTAL. CHIP 100uF 8-752-889-54 IC CXP84640-011Q C110 1-163-251-11 CERAMIC CHIP...
Page 83
http://www.xiaoyu163.com SERVO 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R302 1-216-037-00 METAL CHIP 1/10W R604 1-216-097-00 RES,CHIP 100K 1/10W R303 1-216-308-00 METAL CHIP 1/10W R605 1-216-081-00 METAL CHIP 1/10W R304 1-216-683-11 METAL CHIP 0.5% 1/10W...
Page 84
http://www.xiaoyu163.com 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark PARTS FOR INSTALLATION AND CONNECTIONS *************** HARDWARE LIST *************************************** *************** 3-009-613-21 FRAME 7-685-851-04 SCREW +BVTT 2X4 (S) 3-025-812-01 COLLAR (90) 7-685-792-09 SCREW +PTT 2.6X6 (S) 3-027-138-01 SPRING, FITTING 7-685-105-19 SCREW +P 2X8 TYPE2 NON-SLIT 3-934-325-01 SCREW, +K (5X8) TAPPING...
Page 85
CDX-C90 3 7 63 1515 0 L 13942296513 u163 Sony Corporation 98G0433-1 9-925-982-11 Personal & Mobile Communication Company Printed in Japan C1998. 7 – 114 – Published by Quality Assurance Dept. http://www.xiaoyu163.com...