What To Do Before Calling For Service - Scotsman F0522 Installation And User Manual

N0422, F0522, N0622, F0822, N0922, F1222, N1322, F1522
D Series Air, Water or Remote User Manual

What to do before calling for service

Normal Operation:
Ice
The machine will make either flaked or nugget ice,
depending upon the model. The ice will be produced
continuously until the bin is full. It is normal for a few
drops of water to occasionally fall with the ice.
Heat
On remote models most heat is exhausted at the
remote condenser, the ice machine should not
generate significant heat. Water cooled models
also put most of the heat from ice making into the
discharge water. Air cooled models will generate heat,
and it will be discharged into the room.
Noise
The ice machine will make noise when it is in ice
making mode. The compressor and gear reducer will
produce sound. Air cooled models will add fan noise.
Some ice making noise could also occur. These
noises are all normal for this machine.
Reasons the machine might shut itself off:
• Lack of water.
• Does not make ice
• Auger motor overload
• High discharge pressure.
• Low refrigeration system pressure.
Steady Green
Blinking Green
Blinking Red
Yellow
Blinking Yellow
Light Off
Power Status
Normal Normal
Self Test Failure Switching on or
off. When Smart-
Board used,
machine attention
recommended.
- Diagnostic shut
down
- -
- -
No power Switched to Off
Check the following:
1. Has the water supply to the ice machine or
building been shut off? If yes, the ice machine will
automatically restart within minutes after water begins
to flow to it.
2. Has power been shut off to the ice machine? If yes,
the ice machine will automatically restart when power
is restored.
3. Has someone shut the power off to the remote
condenser while the ice machine still had power? If
yes, the ice machine may need to be manually reset.
To Manually Reset the machine.
• Open the swtich door
• Push and release the Off button.
• Push and release the On button.
To Shut the Machine Off:
Push and hold the Off button for 3 seconds or until the
machine stops.
Indicator Lights & Their Meanings
Water
-
-
Lack of water
-
-
Normal
October 2014
Page 22
Open Switch Door
De-Scale &
Sanitize
-
-
-
Time to descale and
sanitize
In Cleaning Mode
Normal