Table Of Contents; General Information - BIG ASS FANS Isis Installation Manual

General Information

Introduction
Pre-Installation
Mounting Structure:
Bar Joists
Mounting Structure:
Wood Frame
Mounting Structure:
Solid Beam
Hanging the Fan
Installing Guy Wires
Installing Airfoils
Electrical Installation
Contents
Important Safety Information
Reference Guide
Reference Guide (Mounting)
Thank You
About Big Ass Fans
About this Fan
What's in the Box
Parts Included
Alternative Mounting Methods
Tools Needed
Fan Diagram
Preparing the Work Site
1. Select Proper Angle Irons
2. Pre-drill Angle Irons
3. Secure Angle Irons (span is longer than 8 ft)
4a. Fasten Single Angle Irons to Roof Structure Mounting Points
4b. Fasten Double Angle Irons to Roof Structure Mounting Points
5. Attach Upper Mount (to Angle Irons)
1. Identify Mounting Location
2a. Fasten Brackets (to Vaulted Ceiling Beams)
2b. Fasten Brackets (to Floor Joists)
2c. Fasten Brackets (to Ceiling Joists)
3. Attach Upper Mount (to Wood Framing Channels)
4. Fasten Wood Framing Channels (to Brackets)
1. Pre-drill Suitable Mounting Structure
2. Determine Bracket Orientation
3a. Attach L-Brackets (to Mounting Structure)
3b. Attach L-Brackets (to Mounting Structure with Safety Clips)
4. Attach Upper Mount (to L-Brackets)
1. Attach Extension Tube (to Upper Mount)
2a. Secure Safety Cable (to Angle Irons)
2b. Secure Safety Cable (to Wood Frame)
2c. Secure Safety Cable (to Solid Beam)
2d. Secure Safety Cable (to Solid Beam with Safety Clips)
3. Attach Main Fan Unit (to Extension Tube)
1. Attach Guy Wire Clamps
2. Attach Locking Carabiners to Guy Wire Clamps
3a. Attach Beam Clamp (Bar Joist Mounting)
3b. Attach Eyebolt (Wood Frame Mounting)
4. Route Guy Wire through Gripple
5. Install Three Remaining Guy Wires
1. Attach Winglets or Airfoil Tips (to Airfoils)
2. Position Airfoils
3. Attach Airfoils (to Main Fan Unit)
Electrical Installation Safety
Power Requirements
Wiring: Single Fan Application (120 V Isis
Wiring: Multi-Fan Application (120 V Isis)
Wiring the Fan (240 V, 50 Hz Isis)
Wiring the Fan (240 V, 50/60 Hz Isis
Mounting the Wall Controller (120 V Isis)
Mounting the Wall Controller (240 V, 50 Hz Isis)
Mounting the Wall Controller (240 V, 50/60 Hz Isis)
WWW.BIGASSFANS.COM ©2014 DELTA T CORP.
Isis
®
®
)
®
ALL RIGHTS RESERVED
ii
iii
iv
1
1
1
2
3
4
5
6
7
9
10
10
11
12
13
14
14
15
15
16
17
18
18
19
19
19
20
20
20
21
21
21
22
23
23
23
24
24
25
25
26
27
27
28
29
30
31
32
32
32