Delta Environmental Products ECOPOD-N Series Safety Instructions Installation And Service Manual page 3

Homeowner Care And Operation Instructions
The ECOPOD-N Fixed Film Wastewater Treatment System has
™
been designed and built to provide long term, reliable and efficient
service.
Once the unit has been installed, (see installation instructions) the
unit will operate with a minimum amount of attention.
Please reference the system's Data Plates that are located on the
tank, air pump and the alarm panel in the event that a problem
arises or service is required.
The following should be accomplished as checks for system
failure:
Daily: Observe the warning device, which comes
on when the power to the air pump has been
interrupted or when the air supply system has
malfunctioned or when there is a high water
level in the treatment plant. If the alarm is
activated check for a blown fuse or thrown
circuit breaker. Check air pump to be sure
it is operating. Once accustomed to the
soft humming sound of a properly operating
unit, any unusual noise is an indication of
malfunction. If an unusual noise is detected or
total failure is observed, call your local dealer
for service.
Weekly: Check the treatment plant for offensive odor.
If such a condition should develop, call an
authorized Delta dealer/distributor.
Every 3 Months: The air filter on the air pump should be
cleaned. Rinse with warm water if necessary.
(See installation instructions). Do not use oil or
other solvents.
Every 6 Months: Inspect and make any necessary adjustments
to mechanical and electrical components.
Inspect effluent quality's color, turbidity and
check for any odor.
Take a sample from the reactor tank to check
the sludge level described in the "Solids
Removal" section.
The homeowner must be notified in writing
if any improper operation is observed and
cannot be corrected at the time of service.
Note: To keep maintenance to a minimum and
ensure high effluent quality, the following items
should not be permitted to enter the system.
Items Not Permitted In System
• Strong disinfectants or bleaches, other than small amounts
normally utilized in day to day cleaning and laundry (be
conservative). Laundry detergents recommended for use
are low-sudsing, low phosphates and biodegradable, such as
Gain, Arm & Hammer, All, Fresh Start and Dash Bright.
• Discharge from water softener.
• Any type of oils, greases, or other chemical wastes.
• Disposable baby diapers and wipes.
• Sanitary napkins, condoms or other similar items.
• Hair, bandages, rags or string.
• Latex, plastic or metallic objects.
• Coffee grounds or cigarette butts.
• Mud or sticks.
• Paper towels, napkins or Kleenex
• Tidy Bowl type products.
• Beer waste or any other rich liquids.
• Garbage disposal should be used sparingly, not as a method
of disposing all solid food waste. In order to ensure good
plant operation, waste should be disposed of in the garbage
container.
The ECOPOD-N Fixed Film Wastewater Treatment System
™
is designed to handle domestic wastewater and nothing else
should go into it. For anything other than domestic wastewater
contact Delta Environmental Products.
3