Table of Contents
Advertisement
Quick Links
EMPIRE
EMPIRE
Comfort Systems
!
danGer
Installer:
leave this manual with the appliance.
consumer:
retain this manual for future reference.
— Do not store or use gasoline or other flammable va-
pors and liquids in the vicinity of this or any other ap-
pliance.
— Installation and service must be performed by a quali-
fied installer, service agency or the gas supplier.
warnInG
If the information in these instructions are
not followed exactly, a fire or explosion may
result causing property damage, personal
injury or loss of life.
warnInG
Improper installation, adjustment, alteration,
service or maintenance can cause injury
or property damage. read the installation,
operating and maintenance instructions
thoroughly before installing or servicing this
equipment.
InstallatIon InstructIons
owner's Manual
GAS-FIRED
this appliance can produce carbon monoxide which has no
odor.
using it in an enclosed space can kill you.
never use this appliance in an enclosed space such as a camp-
er, tent, car or home.
and
outdoor Ventless
decoratIVe aPPlIance
InterMIttent IGnItIon Models
olI-24-1
olI-30-1
carBon MonoXIde HaZard
For outdoor use only.
If not installed, operated and maintained in accor-
dance with the manufacturer's instructions, this
product could expose you to substances in fuel
or from fuel combustion which can cause death
or serious illness.
If you smell gas:
1. shut off gas to the appliance.
2. Extinguish any open flame.
3. If odor continues, keep away from the appli-
ance and immediately call your gas supplier
or fire department.
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
an lP-cylinder not connected for use shall not
be stored in the vicinity of this or any other ap-
pliance.
warnInG
warnInG
warnInG
warnInG
Page 1
Advertisement
Table of Contents
Related Manuals for Empire OLI-24-1
Summary of Contents for Empire OLI-24-1
- Page 1 InstallatIon InstructIons EMPIRE EMPIRE owner's Manual Comfort Systems outdoor Ventless decoratIVe aPPlIance InterMIttent IGnItIon Models olI-24-1 GAS-FIRED olI-30-1 carBon MonoXIde HaZard danGer this appliance can produce carbon monoxide which has no odor. using it in an enclosed space can kill you.
-
Page 2: Table Of Contents
taBle oF contents section Page Important Safety Information ......................3 Safety Information for Users of LP-Gas ..................4 Introduction ..........................5-7 General Information ........................7 Clearances ............................. 8 Specifications ..........................8 Before Fully Installing the Appliance ....................8 Gas Supply ............................. 9 Operation Instructions/Flame Appearance ................... -
Page 3: Important Safety Information
IMPoRTAnT SAFETY InFoRMATIon Installer: Please leave these instructions with the owner for future Proper installation, burner pan location is important to achieve reference. optimum look and performance of your appliance. Do not operate this appliance with glass doors in the closed This unit complies with ANSI Z21.97/CSA 2.41 Decorative Gas position. -
Page 4: Safety Information For Users Of Lp-Gas
SAFETY InFoRMATIon FoR USERS oF LP-GAS Propane (LP-Gas) is a flammable gas which can cause fires with the members of your household. someday when there and explosions. In its natural state, propane is odorless and may not be a minute to lose, everyone's safety will depend colorless. -
Page 5: Introduction
ANY CHANGE TO THIS APPLIANCE OR ITS CONTROLS CAN BE DANGEROUS. damage: Empire Comfort Systems recommends a slope of 1/8 in Improper installation or use of the appliance can cause se- to 1/4 in per foot towards the drain port suggested. The fireplace can be shimmed level. - Page 6 IntroductIon Qualified Installing Agency • For appliances for fixed fuel piping system and equipped Installation and replacement of gas piping, gas utilization equipment with an appliance gas pressure regulator, the appliance and or accessories and repair and servicing of equipment shall be its individual shutoff valve must be disconnected from the performed only by a qualified agency.
-
Page 7: General Information
IntroductIon Ventilation opening(s) shall be provided at floor • Cylinder valves shall be readily accessible for hand opera- level and shall have a total free area of not less tion. A door on the enclosure to gain access to the cylinder than 1/2 square inch per pound (3.2 sq. -
Page 8: Clearances
clearances Minimum dimensions For solid Fuel Burning Fireplaces Glass doors Make sure that glass doors are open during all operations of the Model appliance. The opening of the glass door frame should be the OLI-24 27" 18" 34" 18" dimension used for the minimum front opening of the firebox. OLI-30 30"... -
Page 9: Gas Supply
GAS SUPPLY Check all local codes for requirements, especially for the size and type of gas supply line required. recommended Gas Pipe diameter Pipe Length Schedule 40 Pipe Tubing, Type L Inside Diameter Outside Diameter Nat. L.P. Nat. L.P. 0-10 feet 1/2”... -
Page 10: Operation Instructions/Flame Appearance
oPeratIon InstructIons/FlaMe aPPearance NOTICE: all flames will be random by design, flame height will go up and down. During manufacturing, fabricating and shipping, various components of this appliance are treated with certain oils, films or bonding agents. These chemicals are not harmful, but may produce annoying smoke and smells as they are burned off during the initial operation of the appliance, possibly causing headaches or eye or lung irritation. -
Page 11: Oli-(24,30) Lighting Instructions
olI-(24,30) lIGHtInG InstructIons FOR YOUR SAFETY READ BEFORE LIGHTING WARnInG: IF YoU Do noT FoLLoW ThESE InSTRUCTIonS EXACTLY, A FIRE oR EXPLoSIon MAY RESULT CAUSInG PRoPERTY DAMAGE, PERSonAL InJURY, oR loss oF lIFe. a. BeFore lIGHtInG, smell around the appliance area for B. -
Page 12: Main Burner Flame Characteristics
MaIn Burner FlaMe cHaracterIstIcs Main Burner Flame Pattern Main Burner Flame Ignition and extinction The main burner flame will be completely yellow. When the main burner is ignited it will take a few seconds for the full flame pattern to develop. When the main burner is extinguished it will take a few seconds for the flames to disappear. -
Page 13: Remote Control Installation And Operation
reMote control InstallatIon & oPeratIon TWo-FUnCTIon WIRELESS REMoTE ConTRoL SYSTEM For on/oFF-HI/lo oPeratIon oF tHe aF-4000 Gas control ValVe IF YoU CAnnoT READ oR UnDERSTAnD ThESE InSTALLATIon InSTRUCTIonS Do noT atteMPt to oPerate IntroductIon This remote control system was developed to provide a safe, reliable, and user-friendly remote control system for use with the AF-4000 gas control valve used with some gas heating appliances. -
Page 14: Parts View
Parts VIew Parts lIst Part no. Index no. description olI24 olI30 28103 28105 Top Cover 27972 27972 Inlet Tubing P212 P212 Orifice Holder P245 P265 Orifice - LP P301 P209 Orifice - NAT R10808 R10808 Air Shutter 28739 28740 Burner with Bracket R10814 R10814 Spark Probe... -
Page 15: Master Parts Distributor List
Master Parts dIstrIButor lIst To Order Parts Under Warranty, please contact your local Empire dealer. See the dealer locator at www.empirecomfort. com. To provide warranty service, your dealer will need your name and address, purchase date and serial number, and the nature of the problem with the unit. -
Page 16: Warranty Terms
WARRAnTY TERMS Empire Comfort Systems Inc. warranties this hearth product to be free from defects at the time of purchase and for the pe- riods specified below. Hearth products must be installed by a qualified technician and must be maintained and operated safely, in accordance with the instructions in the owner’s manual.