Table of Contents
Advertisement
WARNING
If the information in this manual is not
followed exactly, a fire or explosion may
result causing property damage, personal
injury or loss of life.
FOR USE ONLY WITH A LISTED GAS-FIRED
UNVENTED DECORATIVE ROOM HEATER
NOT TO EXCEED 50,000 BTU/H.
DO NOT BUILD A WOOD FIRE.
Carefully review the instructions supplied
with the decorative type unvented room
heater for the minimum firebox size
requirement.
DO NOT INSTALL AN APPLIANCE IN THIS
FIREBOX UNLESS THIS FIREBOX MEETS
THE MINIMUM DIMENSIONS REQUIRED
FOR THE INSTALLATION.
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. If odor continues, keep away from the
appliance and immediately call your gas
supplier or fire department.
WARNING
Improper installation, adjustment,
alteration, service or maintenance can
cause injury or property damage. Read the
installation, operating and maintenance
instructions thoroughly before installing or
servicing this equipment.
INSTALLATION INSTRUCTIONS
AND OWNER'S MANUAL
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
DANGER
OUTDOOR VENTLESS FIREBOX
MODELS:
OP32FB2MF-3*
OP36FB2MF-3
OP42FB2MF-3
* Please note, Empire Comfort Systems does not
offer an outdoor gas burner to fit the OP32FB2MF
firebox. You will need to find a suitable burner from
another manufacturer.
This product complies with ANSI Z.21.91 for outdoor use with
Z21.97 burners, 50,000 BTU Max.
GAS-FIRED
MH45080
Page 1
Advertisement
Table of Contents
Related Manuals for Empire OP32FB2MF-3
Summary of Contents for Empire OP32FB2MF-3
-
Page 1: Installation Instructions
FOR THE INSTALLATION. OP36FB2MF-3 OP42FB2MF-3 DANGER * Please note, Empire Comfort Systems does not offer an outdoor gas burner to fit the OP32FB2MF If you smell gas: firebox. You will need to find a suitable burner from 1. Shut off gas to the appliance. -
Page 2: Table Of Contents
TABLE OF CONTENTS SECTION PAGE BEFORE YOU START .....................3 CARTON CONTENTS & HARDWARE PACKAGE ..........3 IMPORTANT SAFETY INFORMATION ..............4 HOMEOWNER REFERENCE INFORMATION ............5 INTRODUCTION ....................5 - 6 ACCESSORIES .......................6 FIREBOX DIMENSIONS ..................7 CLEARANCES ......................8-9 PLANNING INSTALLATION ................10-11 FIREBOX INSTALLATION INSTRUCTIONS ............11-12 INSTALLING HOOD ....................12 GAS LINE CONNECTION ..................13 MAINTENANCE .....................13... -
Page 3: Before You Start
BEFORE YOU START Sample Warnings and Definitions: Read the Safety Information on page 4. 2. Determine where to install the firebox. See pages 10-11. DANGER Frame the opening. See page 11. Install optional drain tray. (See instructions with drain tray) Indicates a hazardous situation which, if not avoided, will result 5. Install the firebox. See pages 12. -
Page 4: Important Safety Information
IMPORTANT SAFETY INFORMATION FOR THE INSTALLER FOR THE HOMEOWNER • Leave instruction manual with the homeowner • Alert children and adults to the hazards of high surface • This firebox complies with ANSI Z21.91 for outdoor use with temperatures. Keep children and other at-risk individuals Z21.97 burners, 50,000 BTU MAX. away to avoid burns or clothing ignition. • Installation and repair should be done by a qualified service • Carefully supervise young children when they are in the person. This firebox should be inspected before use and at same area as the firebox. least annually by a qualified service person. -
Page 5: Homeowner Reference Information
4. Show owner how to start and operate outdoor burner (not penetration must be considered for construction that places the provided). firebox in structure walls or on moisture sensitive surfaces. When installed next to exterior walls: Empire Comfort Systems recommends the firebox chase be constructed outside the Always consult your local Building Department regarding structure's weather envelope. Where the platform meets the wall, regulations, codes or ordinances which apply to the installation of use a flashing detail similar to that required for attached decks. -
Page 6: Introduction
ACCESSORIES The following accessory parts can be obtained from your Empire Comfort Systems dealer. Contact your Empire Dealer for more acces- sory options. If you need additional information beyond what your dealer can furnish, contact Empire Comfort Systems Inc., 918 Freeburg Ave., Belleville, Illinois 62220-2623. -
Page 7: Firebox Dimensions
FIREBOX DIMENSIONS OUTER FIREBOX DIMENSIONS INNER FIREBOX DIMENSIONS INNER FIREBOX DIMENSIONS GAS INLET HOLES BOTH SIDES TOP VIEW SIDE VIEW INDEX DIMENSION DESCRIPTION DIMENSIONS (in inches) LETTER OP32 OP36 OP42 The maximum height of firebox face (excluding standoffs) 33-1/16 35-1/16 35-1/16 The maximum width of the firebox face (excluding nailing flanges) The maximum depth of the firebox 16-9/16 The height of the firebox opening 22-1/4 24-1/4 24-1/4 The width of the firebox opening The interior depth of the firebox... -
Page 8: Clearances
CLEARANCES Top Framing and Finishing: Combustible framing materials COMBUSTIBLE requires 3/4 inch to top of firebox. See Figure 1. FINISHED WALL OR MANTEL Sidewall Clearances: The clearance from the inside of the firebox to perpendicular combustible side wall should not be less than 6 inches. See Figure 2. 2 X 4 TOP PLATE Firebox Face Clearance: 3/8 inch from face and back 1 3/4 NON-COMBUSTIBLE inches. -
Page 9: Clearances
Television Considerations Installing a television above an firebox has become increasingly CEILING popular; however, the area above any firebox gets hot and most TV manufacturers recommend against placing their products near a heat source. If you install a television above this firebox, Empire Comfort Systems accepts no responsibility for damage or injuries. Follow COMBUSTIBLES the television manufacturer’s installation instructions, including any ALLOWED recommendations regarding proximity to heat sources. -
Page 10: Planning Installation
ATTENTION: Vinyl Soffit, Vinyl Ceiling, Vinyl Overhang Figure 4 Disclaimer Clearances are to heat resistant material (i.e. wood, metal). This does not include vinyl. Empire Comfort Systems Inc. will not be held responsible for heat damage caused to vinyl overhangs, vinyl ceilings or vinyl ventilated/unventilated soffits. Page 10... -
Page 11: Firebox Installation Instructions
TV manufacturers recommend against placing their products installation instructions that came with the burner or accessory near a heat source. (i.e. clearances, combustion and ventilation air, and enclosure If you install a television above this firebox, Empire Comfort information). Systems accepts no responsibility for damage or injuries. Follow WARNING the television manufacturer’s installation instructions, including... -
Page 12: Installing Hood
3/8" GAP REQUIRED Figure 10 Extended Hoods If the non-combustible facing material used to finish the firebox is over 1 inch thick, an extended hood that extends 2 inches farther into the room is recommended. Contract your Empire Dealer for details. VB4H32SS Stainless Steel Extended Hood VB4H36SS Stainless Steel Extended Hood... -
Page 13: Gas Line Connection
GAS LINE CONNECTION The firebox is designed to accept a gas line for an ANSI approved burner. Have the gas line installed by a qualified service person in accordance with all building codes. Consult local building codes to properly size the gas supply line leading to the hook-up at the installed burner. The Commonwealth of Massachusetts requires that a flexible gas connector cannot exceed three feet in length. Gas access holes are provided on both sides of the firebox. See Figure 12. -
Page 14: Parts View
PARTS VIEW PARTS LIST USE ONLY MANUFACTURER’S REPLACEMENT PARTS. USE OF ANY OTHER PARTS COULD CAUSE INJURY OR DEATH. Part No. Index No. Description OP32FB2MF OP36FB2MF OP42FB2MF 33847 33848 33849 Face, Bottom 33850 33851 33852 Face, Top 33853 33854 33854 Face, Side - Right 33855 33856... -
Page 15: Master Parts Distributor List
MASTER PARTS DISTRIBUTOR LIST To Order Parts Under Warranty, please contact your local Empire dealer. See the dealer locator at www.empirecomfort. com. To provide warranty service, your dealer will need your name and address, purchase date and serial number, and the nature of the problem with the firebox. -
Page 16: Warranty Terms
WARRANTY TERMS Empire Comfort Systems Inc. warranties this hearth product to be free from defects at the time of purchase and for the periods specified below. Hearth products must be installed by a qualified technician and must be maintained and operated safely, in accordance with the instructions in the owner’s manual. This warranty applies to the original purchaser only and is not transferable. All warranty repairs must be accomplished by a qualified gas appliance technician.